Page 1
Assembly/Installation Instructions and Use & Care Guide For questions about features, operation/performance or parts, call: 1-800-229-5647 or visit www.sureheat.com Table of Contents......................2 IMPORTANT: Save for local inspector's use. Installer: Leave installation instructions with the homeowner. Homeowner: Keep installation instructions for future reference. Model AM30LP-P RACEZ00044A...
TABLE OF CONTENTS OUTDOOR GRILL SAFETY............3 UNPACKING INSTRUCTIONS ............5 ASSEMBLY REQUIREMENTS............5 Parts Supplied................5 ASSEMBLY INSTRUCTIONS............6 INSTALLATION REQUIREMENTS ..........11 Location Requirements ..............11 Gas Supply Requirements ............12 Gas Connection Requirements..........12 INSTALLATION INSTRUCTIONS ..........12 Make Gas Connection ...............12 Check the Burners ..............13 OUTDOOR GRILL USE ..............14 Using Your Outdoor Grill............14 Using Your Side Burner .............15 TIPS FOR OUTDOOR GRILLING ..........16...
OUTDOOR GRILL SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others.
Page 4
IMPORTANT: This grill is manufactured for outdoor use only. For grills that are to be used at elevations above 2000 ft (609.6 m) orifice conversion is required. See “Gas Supply Requirements” section. It is the responsibility of the installer to comply with the minimum installation clearances specified on the model/serial rating plate.
UNPACKING INSTRUCTIONS 1. Using a utility knife, cut the tape to open top flaps of carton. 9. Open the hood and remove parts carton and interior packaging. 2. Remove Assembly/Installation Instructions and Use and Care Guide. 10. Remove warming shelf and set aside. 3.
Assembly Hardware Supplied (actual size) 38 - Self-tapping screws ASSEMBLY INSTRUCTIONS Assemble caster assemblies to cart base 2 - Sunken head self-tapping screws 1. Remove packaging from caster assemblies and cart base. 2. Remove and set aside 4 caster assembly nuts and 2 bolts from the caster assemblies.
Page 7
5. Place right cart side panel (A) onto the 2 outer caster 9. Attach cart middle divider to cart base and back using 6 self- assembly bolts (B) on the right-hand side of the cart base. tapping screws. Make sure the large flange is toward the front of the cart base.
Page 8
3. Insert drawer tray tab into slot at the bottom of the drawer 3. Using 2 or more people lift grill head onto cart assembly. front. Use 4 self-tapping screws to attach the drawer tray to the drawer front. Set drawer aside. A.
Page 9
To remove drawers: Pull drawer out to stop position, press 3. Tighten all 4 screws to secure the left side shelf. right side black tab up and left side black tab down at the 4. Install 1 self-tapping screw into the bottom front slotted hole same time to release the drawer.
Page 10
Install Control Knob Assembly 6. Use 2 self-tapping screws (D) to attach the small bracket (C) to the front bracket (A) under the side burner tray. 1. Using a Phillips screwdriver, remove the 2 screws (B) from the side burner valve assembly (D). 2.
4. Place the side burner grate onto the side burner tray. Position the 3 longer legs of the grate into the holes around the side INSTALLATION REQUIREMENTS burner. Location Requirements WARNING Explosion Hazard Do not store fuel tank in a garage or indoors. Do not store grill with fuel tank in a garage or indoors.
Product Dimensions Gas Connection Requirements 20 lb LP Gas Fuel Tank 29" 13 ¹⁄ ₈ " 13¹⁄₈" (73.8 cm) (33.3 cm) (33.3 cm) This grill is equipped for use with a 20 lb LP gas fuel tank (fuel tank not supplied). A gas pressure regulator/hose assembly is supplied.
4. Place the 20 lb LP gas fuel tank secure ring over the collar of the tank as shown. Check the Burners The burners are tested and factory-set for most efficient operation. However, variations in gas supply and other conditions may make minor adjustments to air shutter or low flame setting necessary.
OUTDOOR GRILL USE This manual covers several different models. The grill you have purchased may have some or all of the features listed. The locations and appearances of the features shown here may not match those of your model. Control Panel A.
IMPORTANT: Turn On the Gas Supply If burner does not light immediately, turn the burner knob to OFF and wait 5 minutes before relighting. 1. For outdoor grills using a 20 lb LP gas fuel tank: Slowly open If any burners do not light after attempting to light them manually, the tank valve.
5. Push in and turn the burner knob to HIGH. The burner will 6. Remove match and replace manual lighting extension. light immediately. When burner is lit, turn knob to desired IMPORTANT: setting. If burner does not light immediately, turn the burner knob to OFF and wait 5 minutes before relighting.
OUTDOOR GRILL CARE GRILL GRATES Replacing the Igniter Battery If igniters stop sparking, the battery should be replaced. IMPORTANT: Do not use a steel or fiber scraper on grill grates. 1. Unscrew igniter button cap counterclockwise to remove. Immediately after you are finished cooking, loosen food soil with a brass bristle brush.
SIDE BURNER CAPS AND GRATE TROUBLESHOOTING Cleaning Method: Clean with a brass bristle brush. Grill will not light Wash grate using mild detergent, warm water and degreaser. Is the 20 lb LP gas fuel tank valve turned off? Rinse with clean water and dry with soft, lint-free cloth. Turn the 20 lb LP gas fuel tank on.
Sure Heat Mfg warrants that for 2 years from the date of purchase, the stainless steel panels will not break due to defects in material or workmanship. All other components of this Amana grill are war - ranted free from defects in material and workmanship for one year from the date of purchase. Sure Heat Mfg.