Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for King Canada PowerForce KCG-1501GX
Summary of Contents for King Canada PowerForce KCG-1501GX
- Page 1 1800W GASOLINE GENERATOR Read this manual. Do not attempt to operate this generator until you have read and understood the safety, operation, and maintenance instructions MODEL: KCG-1501GX INSTRUCTION MANUAL COPYRIGHT © 2021 ALL RIGHTS RESERVED BY KING CANADA TOOLS INC.
-
Page 2: Warranty And Service Information
LIMITED TOOL WARRANTY KING CANADA makes every effort to ensure that this product meets high quality and durability standards. KING CANADA warrants to the original retail consumer a 1-year limited warranty as of the date the product was purchased at retail and that each product is free from defects in materials. - Page 3 BASIC & SPECIFIC SAFETY PRECAUTIONS BE CAREFUL! DO NOT USE KEEP FLAMMABLE DO NOT USE IN DO NOT CONNECT TO IN YOUR HOUSE WET CONDITIONS HOUSEHOLD CIRCUIT MATERIALS AWAY WHEN REFUELING: STOP ENGINE! NO SMOKING! DO NOT SPILL GASOLINE! BASIC SAFETY INFORMATION WARNING! The engine muffler will be very hot after use, avoid touching the engine or muffler while they are still hot.
-
Page 4: Specific Safety Precautions
SPECIFIC SAFETY PRECAUTIONS OPERATION OF GENERATOR IN RAIN, WET, ICY, OR FLOODED RISK OF BREATHING - INHALATION HAZARD CONDITIONS. Operate generator in clean, dry, well ventilated area. Never operate Water is an excellent conductor of electricity! Water which comes in unit in enclosed areas such as garages, basements, storage, sheds, or contact with electrically charged components can transmit electricity to in any location occupied by humans or animals. - Page 5 GETTING TO KNOW YOUR GENERATOR 1. Fuel cap. Make sure the fuel cap is always screwed on tightly. pulling recoil starter. 2. Fuel tank. Unleaded gasoline only! 7 Liter capacity. 10. Air cleaner element/cover. Periodically the air cleaner filter must 3.
-
Page 6: Pre-Start Check
PRE-START CHECK WARNING! To prevent permanent damage to generator or any appliances, you MUST check oil level, fuel level, air cleaner filter and unplug any load from the generator before starting. PRE-START CHECK OIL LEVEL WARNING! This generator has been shipped from the factory without oil or very little oil in the crankcase. -
Page 7: Starting Procedures
STARTING & STOPPING PROCEDURES STARTING PROCEDURES GROUNDING WARNING! BEFORE STARTING, YOUR GENERATOR MUST BE GROUNDED! Before operating make sure to ground the generator. A ground terminal identified by the ground symbol (Fig.4) can be found on the front control panel of the generator, attach a metal spike to a wire, attach the wire to the ground terminal and ground the metal spike into the earth. -
Page 8: Electrical Connections
Overloading the generator will cause power fluctuations and can damage equipment and appliances. King Canada will not be responsible for equipment damaged as a result of voltage surges, improper operation or improper installation of the generator. -
Page 9: Wattage Calculations
WATTAGE CALCULATIONS WATTAGE CALCULATIONS DETERMINING WATTAGE REQUIREMENTS IMPORTANT! Never exceed the rated capacity of your generator. Seri- Note: Volts X Amps = Watts ous damage to the generator or appliance could result from an over- Example: 120V X 12 Amps = 1400 Watts load. -
Page 10: Maintenance And Storage
MAINTENANCE & STORAGE MAINTAINING YOUR GENERATOR Engine Oil Replacement Engine oil should be replaced after the first 20 hours of operation or after the first month of use, it should be replaced every 100 hours or 6 months after. To replace engine oil; 1) Loosen the oil gauge dipstick (A) Fig.8. -
Page 11: Troubleshooting
TROUBLESHOOTING PROBLEM CAUSE CORRECTION Engine will not start 1. Low on fuel or oil. 1. Add fuel or oil. 2. Ignition switch in "Off" position. 2. Turn to "ON" position. 3. Faulty spark plug. 3. Replace spark plug. 4. Choke in wrong position. 4. - Page 12 To prevent FIRE, do not start the engine while the smell of fuel 73-15016400 High altitude parts kit hangs in the air. PARTS DIAGRAM & PARTS LISTS Refer to the Parts section of the King Canada web site for the most updated parts diagram and parts list.