Troubleshooting; Specifications - Stanley FL5W15S Instruction Manual

CAUTION: TO REDUCE THE RISK OF PROPERTY DAMAGE:
• To avoid damaging the spotlight, never use it underwater for longer than four hours.
• Do not forcibly push the Touch Sensor as it may crack or break. Make sure the Touch Sensor is clean, intact and free of debris.
Operating the unit with 12V DC Charger (Optional)
Plug the DC Connector of the supplied 12V DC Charger into the DC Charging Terminals at the rear of the unit. Insert the
DC plug end into the accessory outlet of your vehicle or other 12 volt DC power source. Operate the unit as outlined in the
previous section.
IMPORTANT: The spotlight will operate while the 12V DC Charger is attached, but will continue to draw power from the
unit's Lithium-Ion battery. This may cause the low voltage protection to activate and shut the spotlight down. Manufacturer
recommends only operating the unit using the 12V DC Charger for a short period of time.
CARE AND MAINTENANCE
All batteries lose energy from self-discharge over time and more rapidly at higher temperatures. When the unit is not in use,
we recommend that the battery is charged at least every 3 to 6 months.
If the unit gets dirty, gently clean the outer surfaces of the spotlight or Charging Dock with a soft cloth moistened with a mild
solution of water and detergent. Never submerge the Charging Dock in water or any other solution.
There are no user-replaceable parts. Periodically inspect the condition of adapters, connectors and wires. Contact manufacturer
to replace any components that have become worn or broken.
Battery replacement/disposal
BATTERY REPLACEMENT
The battery should last the service life of the unit. Service life is dependent on a number of factors including but not limited to
the number of recharge cycles, and proper care and maintenance of the battery by the end user. Contact manufacturer for any
information you may need.
SAFE BATTERY DISPOSAL
Contains a lithium-ion battery, which must be disposed of properly. Recycling is required.
Failure to comply with local, state and federal regulations can result in fines, or imprisonment.
Please recycle.
WARNINGS:
• Do not dispose of the battery in fire as this may result in an explosion.
• Before disposing of the battery, protect exposed terminals with heavy-duty electrical tape to prevent shorting (shorting can
result in injury or fire).
• Do not expose battery to fire or intense heat as it may explode.
12V DC Charger Plug Fuse Replacement
1. Unscrew the end cap of the DC plug (counterclockwise).
2. Remove spring center contact and fuse.
3. Check fuse with a continuity checker.
4. If blown, locate a replacement 2 amp fuse.
5. Replace the fuse, spring, contact and end cap.
6. Screw end cap clockwise until it is finger tight – DO NOT OVER-TIGHTEN.
7. Test for proper operation of the 12V DC Charger.

TROUBLESHOOTING

The Charge Status LED Indicator on the Charging Dock does not flash or light when charging with the 120V AC Charger
1. The battery may be overheated due to extensive use. Let the spotlight cool down for a period before recharging.
2. Check the connection to the Charging Port on the left side of the Charging Dock.
3. Check the connection to the AC power source.
4. Confirm there is a functioning AC current.
5. Make sure the spotlight is properly placed in the Charging Dock.
6. Make sure all sensors, connectors and ports are clean, intact and free of debris.
The Battery/Charge Status LED Indicator on the rear of unit does not flash or light when charging with the 12V DC Charger
1. Make sure the spotlight is turned off.
2. Check the connection to the DC Charging Terminals on the back of the spotlight. Make sure it is clean, intact and free of
debris.
3. Check the connection to the DC power source.
4. Confirm there is a functioning DC current.
5. Check the fuse in the 12V DC Charger.
FL5W15S_ManualENSP_010516.indd 8-9
8
The spotlight will not operate when connected to the 12V DC Charger
1. The battery may be overheated. Let the spotlight cool down for a period before operating.
2. The battery may be completely discharged. Charge the battery immediately.
The spotlight will not operate cordless
1. Make sure the spotlight has been placed in Standby Mode by gently shaking the unit until the Battery/Charge Status LED
Indicator lights, and then touch the Touch Sensor and release quickly to turn the spotlight on.
2. Make sure the Touch Sensor at the rear of unit is clean, intact and free of debris.
3. The battery may be overheated. Let the spotlight cool down for a period before operating.
4. The battery may be completely discharged. Charge the battery immediately.
5. If the light does not operate after recharging as directed, contact the manufacturer at (877) 571-2391.
ACCESSORIES
Recommended accessories for use with this unit may be available from the manufacturer. If you need assistance regarding
accessories, please contact manufacturer at (877) 571-2391.
WARNING: The use of any accessory not recommended for use with this appliance could be hazardous.
SERVICE INFORMATION
Whether you need technical advice, repair, or genuine factory replacement parts, contact the manufacturer at (877) 571-2391.
ONE-YEAR LIMITED WARRANTY
The manufacturer warrants this product against defects in materials and workmanship for a period of ONE (1) YEAR from the
date of retail purchase by the original end-user purchaser ("Warranty Period").
If there is a defect and a valid claim is received within the Warranty Period, the defective product can be replaced or repaired
in the following ways: (1) Return the product to the manufacturer for repair or replacement at manufacturer's option. Proof
of purchase may be required by manufacturer. (2) Return the product to the retailer where product was purchased for an
exchange (provided that the store is a participating retailer). Returns to retailer should be made within the time period of the
retailer's return policy for exchanges only (usually 30 to 90 days after the sale). Proof of purchase may be required. Please check
with the retailer for their specific return policy regarding returns that are beyond the time set for exchanges.
This warranty does not apply to accessories, bulbs, fuses and batteries; defects resulting from normal wear and tear, accidents;
damages sustained during shipping; alterations; unauthorized use or repair; neglect, misuse, abuse; and failure to follow
instructions for care and maintenance for the product.
This warranty gives you, the original retail purchaser, specific legal rights and you may have other rights which vary from state
to state or province to province. This product is not intended for commercial use.
Please complete the Product Registration Card and return within 30 days from purchase of the product to: Baccus Global LLC,
One City Centre, 1 North Federal Highway, Suite 200, Boca Raton, FL 33432. Baccus Global LLC, toll-free number: (877) 571-2391.

SPECIFICATIONS

Spotlight
Bulb: 5W LED Bulb
Battery: Lithium-Ion, 3.6V DC
120V AC Charger
Charger: Class 2, 12 volts DC (800mA)
12V DC Charger (optional accessory)
Voltage: 12 volts DC
DC Plug Fuse: 2A
Imported by Baccus Global LLC, One City Centre, 1 North Federal Highway, Suite 200, Boca Raton, FL 33432
www.Baccusglobal.com • 1-877-571-2391
RD010516
9
1/5/2016 9:28:05 AM