Troubleshooting; Specifications - Stanley FL5W10 Instruction Manual

Waterproof 5w led spotlight

Instruction manual (52 pages)

page of 6

/ 6
Troubleshooting
Bookmarks

Available languages

On a single charge, the spotlight will provide steady illumination for approximately 10 hours on its minimum (dimmest) setting; approximately 50

minutes on its maximum (brightest) setting.

IMPORTANT: To avoid sustaining damage, this spotlight should not be used under water for any longer than one hour.

CARE AND MAINTENANCE

Make sure the unit is thoroughly dry before storage. If the unit has been submerged, wipe it dry with a soft cloth.

If the unit gets dirty, gently clean the outer surfaces of the spotlight unit with a soft cloth moistened with a mild solution of water and detergent.

There are no user-replaceable parts. Periodically inspect the condition of adapters, connectors and wires. Contact manufacturer to replace any

components that have become worn or broken.

All batteries lose energy from self-discharge over time and more rapidly at higher temperatures. When the unit is not in use, we recommend that

the battery is charged at least every 60 days.

Battery replacement/disposal

BATTERY REPLACEMENT

The battery should last the service life of the unit. Contact manufacturer for any information you may need.

SAFE BATTERY DISPOSAL

This unit contains a nickel metal hydride rechargeable battery pack, which must be disposed of properly when

it will no longer retain a charge. For information on recycling this battery, call toll-free (800) 822-8837.

To locate a free recycling program collection center near you, go to www.call2recycle.org.

WARNINGS:

• Do not dispose of the battery in fire as this may result in an explosion.

• Before disposing of the battery, protect exposed terminals with heavy-duty electrical tape to prevent shorting (shorting can result in injury or fire).

• Do not expose battery to fire or intense heat as it may explode.

12 volt DC charger plug fuse replacement

The fuse in the plug end of the 12 volt DC charger protects the adapter' s charging circuit. If the 120 volt AC charger operates, but the DC charging adapter

does not, then this fuse may be opened (blown).

To replace the fuse:

1. Unscrew the end cap of the DC plug (counterclockwise).

2. Remove spring center contact and fuse.

3. Check fuse with a continuity checker.

4. If blown, locate a replacement 5 amp/250 volt fuse.

5. Replace the fuse, spring, contact and end cap.

6. Screw end cap clockwise until it is finger tight – DO NOT OVER-TIGHTEN.

7. Test for proper operation of the 12 Volt DC Charging Adapter.

TROUBLESHOOTING

The battery/charge status indicator LED does not light when charging

1. The battery is in overheat protection after extensive use. Allow the spotlight to cool down for several minutes before recharging.

2. The spotlight will not charge when operating. Make sure the spotlight is turned off.

3. Check connection to the 12 volt DC charging port.

4. Check connection to AC or DC power source.

5. Confirm there is a functioning AC or DC current.

Unit will not operate

1. The battery is in overheat protection after fully charging or recharging. Allow the spotlight to cool down for several minutes before operating.

2. The spotlight will not operate when charging. Be sure all adapters are disconnected before spotlight use.

3. The battery may be completely discharged. Charge the unit following the directions.

4. If the spotlight does not operate after recharging as directed, contact manufacturer at (877) 571-2391.

ACCESSORIES

Recommended accessories for use with your tool are available from your local dealer or authorized service center. If you need assistance regarding

accessories, please contact manufacturer at (877) 571-2391.

WARNING: The use of any accessory not recommended for use with this tool could be hazardous.

SERVICE INFORMATION

Whether you need technical advice, repair, or genuine factory replacement parts, contact the manufacturer at (877) 571-2391.

ONE-YEAR LIMITED WARRANTY

Manufacturer warrants this product for one year against any defects in material or workmanship. The defective product will be replaced or

repaired at no charge in either of two ways.

The first, which will result in exchanges only, is to return the product to the retailer from whom it was purchased (provided that the store is a

participating retailer). Returns should be made within the time period of the retailer' s policy for exchanges (usually 30 to 90 days after the sale).

Proof of purchase may be required. Please check with the retailer for their specific return policy regarding returns that are beyond the time set for

exchanges. The second option is to return the product (prepaid) to the manufacturer for repair or replacement at our option. Proof of purchase

may be required.

This warranty does not apply to accessories. This warranty gives you specific legal rights and you may have other rights which vary from state to

state or province to province. This product is not intended for commercial use.