Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for CleanCraft DWS 1105
Summary of Contents for CleanCraft DWS 1105
- Page 1 Operating Instructions House water system DWS 1105 DWS 1105 P DWS 1105 DWS 1105 P...
-
Page 2: Table Of Contents
The contents of these operating instructions are the sole 14.1 Ordering spare parts ........17 property of the company Stürmer. 14.2 Spare parts drawing DWS 1105 ..... 18 Passing on as well as copying of this document, the use 14.3 Spare parts drawing DWS 1105 P....19 and distribution of its content are prohibited if not 15 Electrical wiring diagram........20... -
Page 3: Introduction
1.3 Limitation of liability You have made a good choice by purchasing the All information and notes in these operating instructions CLEANCRAFT house water system. were summarised while taking applicable standards and rules, the state-of-the-art technology and our long- term knowledge and experiences into consideration. -
Page 4: Obligations Of The Operating Company
Safety 2.2 Obligations of the operating company WARNING! The operating company is the person who operates the This combination of symbol and signal words indica- House water system for business or commercial rea- tes a potentially dangerous situation which may lead sons by herself, or leaves it to a third party for use or ap- to death or severe injury if not avoided. -
Page 5: Requirements To Staff
Safety 2.3 Requirements to staff 2.4 Personal protective equipment Qualifications The personal protective equipment serves to protect The different tasks described in this manual represent per-sons against impairments of safety and health while different requirements to the qualification of the persons working. - Page 6 Safety - Never use the power cord to move or lift the spe- cial house water system. ATTENTION! - Do not bend, crush, pull or drive over power cords and extension cords. The water pump is not used for drinking water sup- ply or for pumping food.
-
Page 7: Safety Labels On The Water Pump
Intended use 2.6 Safety labels on the water pump 3.1 Improper use WARNING! The following safety labels and instructions are attached to the House water system (Fig. 1) and must be ob- Danger in case of misuse! served. Misuse of the water pump can lead to dangerous sit- uations. -
Page 8: Type Plate
6.2 Transport ATTENTION! Allow the water pump to cool completely and drain completely from water. Fig. 2: Type plate DWS 1105 The water pump may only be transported upright. During transport, the water pump must be well secured Technical Data so that it can not tip over. -
Page 9: Device Description
Device description Device description House water system DWS 1105 P House water system DWS 1105 Fig. 4: Description DWS 1105 P 1 Water inlet pipe 2 Water outlet suction connection 3 Tank 4 Water draining plug 5 Pressure indicator Fig. 3: Description DWS 1105... -
Page 10: Installation
"ERROR" appears in the Fig. 6: Display functions DWS 1105 display. The water pump DWS 1105 has an LCD display with two buttons "SET" and "CHECK" which allows you to make Installation settings on the pump. -
Page 11: Electrical Connection
Start up Start up WARNING! Danger to life! There is danger to your life if you do not follow these rules. - Never work with the water pump if you are under the influence of alcohol, drugs or medications and / or you are overtired or suffer from concentration- disturbing illnesses. -
Page 12: Connection Of The Suction Pipe
Start up meter of at least 25 mm and must be bend- 9.1 Connection of the suction pipe proof, pressure-proof and vacuum-proof. Keep the suction pipe as short as possible as the pump capacity decreases with increasing ATTENTION! length. The suction pipe must be installed in such a way Step 3: Install the inlet pipe (Pos. -
Page 13: Operation
Operation 10 Operation ATTENTION! Make sure that the pump is properly placed and DANGER! ready for use. Check whether all hose connections Danger to life due to electric shock! are firmly bolted and undamaged. There is danger to life when in contact with live com- ponents. -
Page 14: Starting The Water Pump
Never use solvents to clean plastic parts or painted surfaces. A surface release and consequential da- mage may occur. NOTE! The house water system DWS 1105 is equipped with an additional dry-running protection and pre-filter. Use protective gloves! The dry-running protection switches the pump off as soon as no water can be pumped. -
Page 15: Maintenance And Repair
Disposal, recycling of used device 11.2 Maintenance and repair 12 Disposal, recycling of used device Please take care in your own interest and in the interest ATTENTION! of the environment that all component parts of the ma- chine are only disposed of in the intended and permit- Maintenance and repair must always be carried out ted way. -
Page 16: Disturbances, Possible Causes And Measures.16
If you can not solve the problems with the your house water system yourself, then please contact your ne- ATTENTION! arest CLEANCRAFT dealer. Please write down follo- wing information from the water pump or the opera- If one of the following errors occurs, immediately ting instructions in advance to help you your stop working with the water pump. -
Page 17: Spare Parts
Spare parts 14 Spare parts Example The fan wheel for the house water system DWS 1105 DANGER! must be ordered. The fan wheel has the number 44 in Danger of injury by the use of wrong spare the spare parts drawing. -
Page 18: Spare Parts Drawing Dws 1105
In case of the service, the following drawing shall help to identify the necessary spare parts. If necessary, send a copy of the parts drawing with the marked components to your dealer. Fig. 9: Spare parts drawing DWS 1105 DWS - Series | Version 1.03... -
Page 19: Spare Parts Drawing Dws 1105 P
Spare parts 14.3 Spare parts drawing DWS 1105 P Fig. 10: Ersatzteilzeichnung DWS 1105 P DWS - Series | Version 1.03... -
Page 20: Electrical Wiring Diagram
Electrical wiring diagram 15 Electrical wiring diagram DWS 1105 Fig. 11: Electrical wiring diagram DWS 1105 DWS 1105 P Fig. 12: Electrical wiring diagram DWS 1105 P DWS - Series | Version 1.03... -
Page 21: Declaration Of Conformity
D-96103 Hallstadt hereby declares that the following product Cleancraft® Sauggeräte Product group: House water system Machine type: DWS 1105 Designation of the machine: DWS 1105 P 7522200 Item number: 7522100 ____________________ Serial number: 20_________ Year of manifacture: complies with all relevant provisions of the above mentioned directive as well as the other applied directives (below) - including their applicable modifications at the time of the declaration. - Page 22 www.cleancraft.de...
Need help?
Do you have a question about the DWS 1105 and is the answer not in the manual?
Questions and answers