Start And Adjust The Elevator - Graco SaniForce 24V310 Instructions - Parts Manual

5. With your hands away from the drum, set the
elevator director switch to DOWN.
Fully lower the pump into the drum. Mobile
models: Lock the cart wheels.
models: models:
6. Loosen the u-bolt on the articulating arm. Raise
the arm until the pump is just off the bottom of
the drum. Block the pump to hold it in place, then
tighten the u-bolt on the articulating arm.
NOTE: The pump mounting bracket can connect
NOTE: NOTE:
anywhere on the tie rods. Start with it connected in
the center, and adjust as needed for proper travel.
333406E
Triplex Sales
1-847-839-8442
www.triplexsales.com
Start and and Adjust
Start Start and
Mobile Mobile
1. Close all air regulators and air valves.
2. Open the main air valve.
3. Set the elevator director switch to UP.
Slowly increase regulator pressure until the
elevator rises to its full height.
NOTE: Generally, 40 to 70 psi (0.3 to 0.48 MPa, NOTE: NOTE:
3 to 4.8 bar) is sufficient to raise the elevator.
4. Stationary Stationary Models: Stationary
drum against the elevator base.
Mobile Mobile Models: Mobile
200 liter (55 gallon) drum.
5. With your hands away from the drum, set the
elevator director switch to DOWN.
Fully lower the pump into the drum. Mobile
Models: Lock the cart wheels. Models: Models:
NOTE: When the elevator is fully lowered, the
NOTE: NOTE:
pump should be just off the bottom of the drum.
See Set Height of Articulating Arm, page
6. To increase or decrease the speed of downward
travel on the elevator, remove the side panel of
the air controls. Adjust the bleed valve (249) as
needed, clockwise for faster, counter-clockwise
for slower. Put the side panel back on. Do
operate the
operate operate
7. The speed of upward travel on the elevator is
controlled by the regulator pressure.
Adjust the the Elevator Elevator
Adjust the Elevator
Models: Set a full 200 liter (55 gallon) Models:
Models: Models: Move the cart into place by a full
the elevator elevator with with the the side side panels
the elevator with the side
Operation
Mobile
Mobile
14.
Do not Do not not
panels off. off.
panels off.
15