Page 1: Table Of Contents
SCD-1/777ES US Model Canadian Model SERVICE MANUAL AEP Model For Technical service TABLE OF CONTENTS SERVICING NOTES 7-9. Schematic Diagram – MAIN Board (2/7) – ....25 ..........3 7-10. Schematic Diagram – MAIN Board (3/7) – ....26 7-11. Schematic Diagram – MAIN Board (4/7) – ....27 DISASSEMBLY-2 .............
Page 2 OPERATION. REPLACE THESE COMPONENTS WITH DE FONCTIONNEMENT. NE REMPLACER CES COM- SONY PARTS WHOSE PART NUMBERS APPEAR AS POSANTS QUE PAR DES PIÈCES SONY DONT LES SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- NUMÉROS SONT DONNÉS DANS CE MANUEL OU LISHED BY SONY.
Page 3: Servicing Notes
SECTION 3 SERVICING NOTES CHECKING METHOD OF MICROCOMPUTER ROM NOTES ON HANDLING THE OPTICAL PICK-UP VERSION BLOCK OR BASE UNIT 1. Set the CD1/CD2 switch on the remote commander to CD1. The laser diode in the optical pick-up block may suffer electro- 2.
Page 4 REPLACING OPTICAL PICK-UP 3) In handling the KHS-180A (RP), do not touch inhibited parts shown in Fig. 2, but grip the slide base bearing and U-shaped guide. Handling 1) A red laser diode for Super Audio CD Player requires more attention to static electricity than general infrared laser diodes Slide base bearing for CD.
Page 5 SECTION 4 DISASSEMBLY-2 Note: Follow the disassembly procedure in the numerical order given. OP MECHANISM SECTION (BU-23) 3 two screws × (B2.6 3 two screws × (B2.6 4 two washers 4 two washers 5 Lift up OP mechanism section (BU-23). ×...
Page 6 FRONT PANEL SECTION (SCD-1) 3 push (control block) (wire) switch 2 two claws 4 six screws × (RK4 2 two claws 1 two connectors 5 side plate (L) (CN452, 702) 4 six screws (RK4 × 8) 5 side plate (R) 6 five screws 7 two screws (BVTP3 ×...
Page 7 OPTICAL PICK-UP (KHS-180A/J1N) 6 two screws (B3 × 5) 7 retainer (OP) ass'y 2 screw (PSW3 × 10) 8 leaf spring (Y) 3 holder (R2) 4 holder (R) 9 optical pick-up (KHS-180A/J1N) 5 bracket (OP) ass'y 1 OP-15 flexible print board (CN003) RF BOARD 1 OP-15 flexible print board...
Page 8 SLED MOTOR ASS'Y SECTION 1 five screws (B3 × 5) 3 three poly-slider washers 4 gear (D) 2 cover (BU) 5 gear (C) 6 gear (B) 8 SLD-MOT board 0 sled motor ass'y section 7 screw (B3 × 5) 9 three screws (B3 ×...
Page 9 SPINDLE MOTOR BLOCK 3 two shaft retainers (sub) 2 screw (B3 × 5) 2 screw 5 spindle motor block (B3 × 5) 6 sled shaft (sub) 4 two shaft retainers (main) 2 two screws (B3 × 5) 1 slide the spindle motor block toward the arrow.
Page 10: Test Mode
SECTION 5 TEST MODE 5-1. FLUORESCENT INDICATOR TUBE MODE Geid Assignment Note: Set the CD1/CD2 switch on the remote commander to CD1. Procedure: 1. Press the button while shorting the BP (TEST MODE) on the DISPLAY board with tweezers, etc. and turn on the power, so that the following operation will be executed automatically.
Page 11 5-2. ADJUSTMENT-1 MODE Adjustment-1 Mode List Note: Set the CD1/CD2 switch on the remote commander to CD1. This mode is a special mode used to perform overall adjustment, optical pick-up height adjustment, and service check. Codes Contents Remarks Disc LD ON/OFF CD, SL, DL Note: 1.
Page 12: Electrical Adjustments
SECTION 6 ELECTRICAL ADJUSTMENTS Note on Adjustment Traverse Check 1. When the following parts were replaced, adjust and check the Connection: items marked with a in the given order. oscilloscope (auto or normal mode) Parts Optical IC on RF or Spindle MAIN board Adjustment &...
Page 13 S Curve Check RF Level Check Connection: Connection: oscilloscope oscilloscope (normal mode) (auto mode) MAIN board MAIN board TP524 (FE) TP503 (RF) – TP501 (VC) – TP501 (VC) Procedure: Procedure: 1. Connect an oscilloscope to the TP524(FE) and TP501(VC) on 1.
Page 14 CLV Jitter Check Optical Pick-up Height Adjustment Connection: Connection: storage oscilloscope oscilloscope (normal mode) (normal mode) MAIN board MAIN board (CH2) (CH1) TP702 (MNT4) TP515 (PI) – TP703 (MNT5) – TP511 (FOUT) (CH1) (CH2) TP521 (GND) TP501 (VC) Procedure: Procedure: 1.
Page 15 Overall Adjustment Thresholds for Overall Adjustment Description U limit L limit Procedure: 1. Set the Adjustment-1 Mode. (See 5-2. Adjustment-1 Mode in PI Level SL SECTION 5 (page 11)) PI Level DL 2. Press the 6 button and 2 button, then the 9 button on the PI Offset CD remote commander (to initialize data).
Page 16 Adjustment Location: – MAIN Board (Component Side) – TP501 (VC) TP503 (RF) TP524 (FE) TP521 TP703 (GND) (MNT5) TP516 TP702 TP515 (TE) (MNT4) (PI) TP511 (FOUT)
Page 17: Diagrams
SECTION 7 DIAGRAMS 7-1. NOTES FOR PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM • Circuit Boards Location Note on Printed Wiring Board: Note on Schematic Diagram: • X : parts extracted from the component side. • All capacitors are in µF unless otherwise noted. pF: µµF •...
Page 18 SCD-1/777ES 7-2. PRINTED WIRING BOARDS – RF/SLD-FG/SLD-MOT Boards – • See page 17 for Circuit Boards Location. (Page 22) (Page 22) • Semiconductor Location –RF Board– Ref. No. Location Ref. No. Location Ref. No. Location IC001 IC010 Q004 IC002 IC011...
Page 19 SCD-1/777ES 7-3. SCHEMATIC DIAGRAM – RF/SLD-FG/SLD-MOT Boards – • See page 40 for Waveforms. (Page (Page The components identified by mark 0 or dotted Les composants identifiés par une marque 0 sont line with mark 0 are critical for safety.
Page 20 SCD-1/777ES 7-4. PRINTED WIRING BOARDS – LOAD-CN/LOAD-MOT/LOAD-SW/STB Boards – • See page 17 for Circuit Boards Location. (Page 22)
Page 21: Load-Sw/Stb Boards
SCD-1/777ES 7-5. SCHEMATIC DIAGRAM – LOAD-CN/LOAD-MOT/LOAD-SW/STB Boards – (Page 29)
Page 22 SCD-1/777ES 7-6. PRINTED WIRING BOARD – MAIN Board (component side) – • See page 17 for Circuit Boards Location. (Page 38) (Page 18) (Page 18) (Page 38) • Semiconductor Location Ref. No. Location D501 D502 D503 D702 F-12 IC502 IC507...
Page 23 SCD-1/777ES 7-7. PRINTED WIRING BOARD – MAIN Board (conductor side) – • See page 17 for Circuit Boards Location. • Semiconductor Location Ref. No. Location D504 L-11 D701 C-13 D1501 IC501 IC503 IC504 IC505 IC506 IC508 IC512 IC515 L-11 IC707...
Page 24: Schematic Diagram - Main Board (1/7)
SCD-1/777ES 7-8. SCHEMATIC DIAGRAM – MAIN Board (1/7) – • See page 40 for Waveforms. (Page 39) (Page 39) (Page 28) (Page 29) (Page 28) (Page 25) (Page 29) (Page 26)
Page 25 SCD-1/777ES 7-9. SCHEMATIC DIAGRAM – MAIN Board (2/7) – • See page 40 for Waveforms. • See page 42 for IC Block Diagrams. (Page (Page (Page (Page 27)
Page 26 SCD-1/777ES 7-10. SCHEMATIC DIAGRAM – MAIN Board (3/7) – • See page 40 for Waveforms. (Page 24) (Page 25) (Page 29) (Page 28) (Page 25) (Page 30) (Page 30) (Page 27) (Page 30) (Page 30) (Page 28) (Page 30) (Page 29)
Page 27: Schematic Diagram - Main Board (3/7)
SCD-1/777ES 7-11. SCHEMATIC DIAGRAM – MAIN Board (4/7) – (Page 25) (Page (Page (Page (Page...
Page 28 SCD-1/777ES 7-12. SCHEMATIC DIAGRAM – MAIN Board (5/7) – • See page 42 for IC Block Diagrams. (Page 24) (Page 26) (Page 26) (Page 24) (Page (Page 30) (Page 29)
Page 29 SCD-1/777ES 7-13. SCHEMATIC DIAGRAM – MAIN Board (6/7) – • See page 42 for IC Block Diagrams. (Page 28) (Page 26) (Page 26) (Page 26) (Page 26) (Page 24) (Page 30) (Page 24) (Page (Page 26) (Page 26) (Page 26)
Page 30 SCD-1/777ES 7-14. SCHEMATIC DIAGRAM – MAIN Board (7/7) – • See page 40 for Waveforms. (Page 28) (Page 26) (Page 26) (Page 26) • Semiconductor Location (Conductor Side) Ref. No. Location D101 B-10 D102 D103 C-10 D201 D-10 D202 D203...
Page 31 SCD-1/777ES 7-15. PRINTED WIRING BOARD – AUDIO Board – • See page 17 for Circuit Boards Location. • Semiconductor Location (Component Side) Ref. No. Location IC103 IC104 IC107 IC108 IC109 IC203 IC204 IC207 IC208 IC209 IC301 C-13 IC302 C-12 IC305...
Page 32: Schematic Diagram - Audio Board (1/2)
SCD-1/777ES 7-16. SCHEMATIC DIAGRAM – AUDIO Board (1/2) – • See page 40 for Waveforms. • See page 41 for IC Block Diagrams. (Page 39) (Page 39) (Page (Page (Page (Page 33) The components identified by mark 0 or dotted Les composants identifiés par une marque 0 sont...
Page 33: Schematic Diagram - Audio Board (2/2)
SCD-1/777ES 7-17. SCHEMATIC DIAGRAM – AUDIO Board (2/2) – • See page 40 for Waveforms. (Page 35) (Page 35) (Page 35) (Page 39) (Page 39) (Page 39) (Page 39) (Page (Page 39) (Page (Page (Page 35)
Page 34: Printed Wiring Boards - Bal(Scd-1)/Coax/ Opt/Pin/Sw Boards
SCD-1/777ES (Page 31) (Page 31) 7-18. PRINTED WIRING BOARDS – BAL (SCD-1)/COAX/OPT/PIN/SW Boards – • See page 17 for Circuit Boards Location. (Page 31) (Page 22) (Page 31) (Page 31) (Page 31)
Page 35: Schematic Diagram - Bal(Scd-1)/Coax/ Opt/Pin/Sw Boards
SCD-1/777ES 7-19. SCHEMATIC DIAGRAM – BAL (SCD-1)/COAX/OPT/PIN/SW Boards – (Page 33) (Page (Page 33) (Page 33) (Page 33) (Page 33) (Page 33)
Page 36: Printed Wiring Boards - Display/Sw-L/Sw-R Boards
SCD-1/777ES 7-20. PRINTED WIRING BOARDS – DISPLAY/SW-L/SW-R Boards – • See page 17 for Circuit Boards Location. • Semiconductor Location –DISPLAY Board– Ref. No. Location D1005 IC1001 IC1002 IC1003 Q1001 Q1002 Q1003 Q1004 Q1005 Q1006 Q1007 Q1008 Q1009 Q1010 Q1011...
Page 37: Schematic Diagram - Display/Sw-L/ Sw-R Boards
SCD-1/777ES 7-21. SCHEMATIC DIAGRAM – DISPLAY/SW-L/SW-R Boards – • See page 40 for Waveforms. (Page 27) (Page 39)
Page 38: Printed Wiring Boards - Ac/Power Boards
SCD-1/777ES (Page 31) (Page 31)(Page 31) (Page 31) (Page 31)(Page 31) 7-22. PRINTED WIRING BOARDS – AC/POWER Boards – • See page 17 for Circuit Boards Location. (Page 31) (Page 22) (Page 22) (Page 36) • Semiconductor Location –POWER Board–...
Page 39: Schematic Diagram - Ac/Power Boards
SCD-1/777ES 7-23. SCHEMATIC DIAGRAM – AC/POWER Boards – (Page 32) (Page 32) (Page 33) (Page (Page (Page (Page 33) (Page 37) (Page 24) (Page 24) The components identified by mark 0 or dotted Les composants identifiés par une marque 0 sont line with mark 0 are critical for safety.
Page 40 • Waveforms – RF Board – – MAIN Board – – AUDIO Board – 1 IC001 ra (TE) (SACD PLAY) 3 IC001 tj (SIGO) (CD PLAY) 1 IC702 <z/m> (BCLK) 5 IC701 yh (EXTAL) 1 IC301 rl (BCKI) 6 IC302 eg (256FSO) Approx.
Page 41 • IC Block Diagrams – AUDIO Board – IC101, 201 CXA8042AS IN2– I01+ I02– IN2+ I01– IN1+ SWITCHING IN1– I02+ CIRCUIT VCC2 GND2 VEE2 VCC1 CONSTANT REFERENCE VEE1 CURRENT VREF VOLTAGE CIRCUIT CIRCUIT CONTROL CIRCUIT VCNT CIREF GND1 RIREF IC302 CXD8594Q 51 50 43 42 REGISTER...
Page 42 – MAIN Board – IC503, 505 BA5912AFP-YE2 25 24 22 21 18 17 15 14 – – LEVEL SHIFT LEVEL SHIFT MUTE MUTE VREF1 VREF2 REF1 REF2 SWITCH SWITCH 10 11 IC713, 714, 715 TLC2932IPW-E20 IC1501 MC14053BDTR2 LOGIC LOGIC SELECT FIN-A FIN-B B.COM...
Page 43: Ic Pin Function Description
7-24. IC PIN FUNCTION DESCRIPTION • MAIN BOARD IC701 HD6413002F16 (CPU) Pin No. Pin Name Description — Power supply terminal (+5V) SSSD Two-way data bus with the SACD/CD RF AMP (IC001) SSI CLK Serial data transfer clock signal output to the SACD/CD RF AMP (IC001) PWM signal output to the loading motor drive (IC515) JIG CTR Two-way data bus with the RS-232C (for check)
Page 44 Pin No. Pin Name Description Address signal output to the flash memory (IC716) and S-RAM (IC717, 718) Address signal output to the flash memory (IC716) Address signal output terminal Not used (open) — Ground terminal WAIT Wait signal input from the ARP (IC702) EEP SIO Two-way data bus with the EEPROM (IC735) EEP SCL...
Page 45 Pin No. Pin Name Description ARPINT Interrupt signal input from the ARP (IC702) SDSCS Chip enable signal output to the servo digital signal processor (IC512) SDSACK Chip enable signal input from the servo digital signal processor (IC512) Chip enable signal output to the S-RAM (IC717, 718) Chip enable signal output to the flash memory (IC716) —...
Page 46 • MAIN BOARD IC711 CXD1095R (EXPANDER) Pin No. Pin Name Description MON3 MON4 Monitor signal output terminal Not used (open) MON5 MON6 MON7 — Ground terminal WADCE Watermark signal output to the RF AD (IC708) TEST Test signal output to the DSD decoder (IC703) “H”:active WMGC0 RF gain control for watermark signal output to the RF AD (IC708)
Page 47 Pin No. Pin Name Description Address signal input from the CPU (IC701) REM CODE Remote category signal output terminal “L”:CD2 “H”:CD1 — Not used (open) — Not used (open) — Not used (open) — Not used (open) DF INIT Initial signal output to the digital filter (IC301) MODE SACD/CD mode signal output to the digital filter (IC301) A FILE...
Page 48 • MAIN BOARD IC712 CXD1095R (EXPANDER) Pin No. Pin Name Description STBL DTC Stabilizer detect signal input from the stabilizer detect sensor (IC009) — Not used (open) — Not used (open) LD SW1 Loading panel close signal input from the close switch (S004) LD SW0 Loading panel open signal input from the open switch (S003) SLD SW1...
Page 49 Pin No. Pin Name Description — Not used (open) — Not used (open) — Not used (open) FCSDWN Two-way data bus with the SACD/CD RF AMP (IC001) SDPREK SDPREK signal output to the sled motor drive (IC503) SACDLDON Load signal output to the SACD/CD RF AMP (IC001) TILT OUT Tilt out signal output to the tilt motor drive (IC505) A ERR...
Page 50: Exploded Views
SECTION 8 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they • Items marked “*” are not stocked since they The components identified by mark 0 or dotted line with mark may have some difference from the original are seldom required for routine service.
Page 51 (2) GENERAL (SCD-777ES) (for GOLD) #41 (for BLACK) (for GOLD) (for GOLD) #41 (for BLACK) #40 (for BLACK) loading ass'y section supplied not supplied supplied supplied front panel section Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-221-849-01 PLATE (L), SIDE (GOLD) 4-216-431-01 BOLT (M5X10), HEXAGON SOCKET (for GOLD)
Page 52 (3) LOADING ASSY SECTION not supplied not supplied supplied not supplied not supplied not supplied supplied supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-215-791-01 PLATE (B), ORNAMENTAL 3-325-697-01 WASHER 4-215-767-01 PLATE (A), ORNAMENTAL 4-968-898-01 GEAR (FIRST) 1-673-865-12 LOAD-SW BOARD 4-968-899-01 GEAR (MIDLE)
Page 53 (4) FRONT PANEL SECTION (SCD-1) S901 not supplied not supplied not supplied not supplied supplied not supplied not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-947-420-01 RING (DIA. 2.53), RETAINING 4-215-810-01 PANEL, FRONT 4-215-806-01 GUIDE (OPEN/CLOSE) X-4950-854-1 BUTTON ASSY, POWER...
Page 54 4-215-789-21 GUIDE (GOMA KEY) (BLACK) 4-921-415-05 ESCUTCHEON, POWER KNOB (BLACK) 4-221-839-01 PANEL, FRONT (GOLD) 4-921-415-14 ESCUTCHEON, POWER KNOB (GOLD) 4-221-839-31 PANEL, FRONT (BLACK) 4-942-568-41 EMBLEM (NO. 5), SONY (for BLACK) X-4950-227-1 BUTTON ASSY, POWER (GOLD) S901 1-771-685-11 SWITCH, PUSH (CONTROL BLOCK)
Page 55 (6) MAIN SECTION Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4724-951-A MAIN BOARD, COMPLETE J150 1-568-918-31 JACK, PIN 1P (LINE OUT (ANALOG) SCD-777ES 1-790-659-11 WIRE (FLAT TYPE) (26 CORE) UNBALANCED L) (SCD-1) 4-221-249-01 WASHER J170 1-563-030-21 CONNECTOR (RECEPTACLE) 3P 1-673-854-14 AC BOARD (LINE OUT (ANALOG) BALANCED L) (SCD-1)
Page 56 (7) CHASSIS SECTION (SCD-1) (8) CHASSIS SECTION (SCD-777ES) supplied supplied supplied supplied not supplied not supplied supplied not supplied not supplied supplied supplied not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Ref.
Page 57 (9) OP MECHANISM SECTION-1 (BU-23) not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-673-851-12 SLD-MOT BOARD 3-975-057-01 GEAR, SKEW 1-673-852-12 SLD-FG BOARD 3-911-115-01 WASHER, STOPPER 4-221-248-01 INSULATOR (BSB-16) 4-215-688-01 CAM (TILT) 3-364-731-01 WASHER, POLY-SLIDER X-4950-838-1 BRACKET (TILT) ASSY 4-968-866-11 GEAR (D) * 415...
Page 58 (10) OP MECHANISM SECTION-2 (BU-23) not supplied supplied The components identified by Les composants identifiés par une mark 0 or dotted line with marque 0 sont critiques pour la mark 0 are critical for safety. sécurité. Replace only with part num- Ne les remplacer que par une pièce ber specified.
Page 59: Electrical Parts List
SECTION 9 AUDIO ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • Items marked “*” are not stocked since they The components identified by mark 0 or dotted line with mark are seldom required for routine service. parts list may be different from the parts speci- 0 are critical for safety.
Page 60 AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C210 1-128-211-51 ELECT 47uF 100V C406 1-125-857-21 FILM 820PF C211 1-115-197-11 ELECT 100uF C407 1-128-200-11 ELECT 47uF C212 1-136-818-11 FILM 0.0047uF 5% 100V C408 1-128-200-11 ELECT 47uF C409 1-128-200-11 ELECT 47uF...
Page 61 AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC306 8-759-926-21 IC SN74HC161ANS-E05 Q402 8-729-141-10 TRANSISTOR 2SA985-Q IC307 8-759-926-21 IC SN74HC161ANS-E05 Q403 8-729-209-74 TRANSISTOR 2SA1213Y-TE12R IC308 8-759-231-53 IC M5F7805L Q404 8-729-209-78 TRANSISTOR 2SC2873Y-TE12R IC309 8-759-711-58 IC NJM78L05UA-TE1 Q405 8-729-209-78 TRANSISTOR 2SC2873Y-TE12R...
Page 62 AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R312 1-216-037-00 METAL CHIP 1/10W R143 1-259-924-11 CARBON MELF 1.3K 1/8W R313 1-216-037-00 METAL CHIP 1/10W R144 1-259-992-11 CARBON MELF 1/8W R145 1-259-920-11 CARBON MELF 1/8W R314 1-216-037-00 METAL CHIP 1/10W R147...
Page 63 AUDIO COAX Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R422 1-259-995-11 CARBON MELF 1/8W < RESISTOR > R423 1-259-995-11 CARBON MELF 1/8W R424 1-259-995-11 CARBON MELF 1/8W R171 1-260-008-11 CARBON MELF 1/8W R425 1-249-415-11 CARBON 1/4W R172 1-260-008-11 CARBON MELF...
Page 64 COAX DISPLAY Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < RESISTOR > Q1005 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR R990 1-259-909-11 CARBON MELF 1/8W Q1006 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR R991 1-259-987-11 CARBON MELF 1/8W Q1007 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR Q1008 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR <...
Page 65 DISPLAY LOAD-CN LOAD-MOT LOAD-SW MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R1080 1-249-429-11 CARBON 1/4W C519 1-162-970-11 CERAMIC CHIP 0.01uF R1081 1-249-429-11 CARBON 1/4W C520 1-128-004-11 ELECT CHIP 10uF C521 1-107-826-11 CERAMIC CHIP 0.1uF R1082 1-249-429-11 CARBON 1/4W...
Page 66 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C584 1-162-970-11 CERAMIC CHIP 0.01uF C725 1-162-970-11 CERAMIC CHIP 0.01uF C726 1-162-970-11 CERAMIC CHIP 0.01uF C585 1-125-891-11 CERAMIC CHIP 0.47uF C727 1-162-970-11 CERAMIC CHIP 0.01uF C586 1-164-245-11 CERAMIC CHIP 0.015uF C728 1-162-970-11 CERAMIC CHIP...
Page 67 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C785 1-162-923-11 CERAMIC CHIP 47PF C851 1-162-970-11 CERAMIC CHIP 0.01uF C857 1-162-970-11 CERAMIC CHIP 0.01uF C786 1-107-548-11 ELECT CHIP 22uF C858 1-162-970-11 CERAMIC CHIP 0.01uF C787 1-162-970-11 CERAMIC CHIP 0.01uF C860 1-162-970-11 CERAMIC CHIP...
Page 68 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D502 8-719-988-61 DIODE 1SS355TE-17 FL503 1-233-893-21 FILTER, CHIP EMI D503 8-719-060-48 DIODE RB751V-40TE-17 FL504 1-233-893-21 FILTER, CHIP EMI D504 8-719-977-04 DIODE DTZ-TT11-5.6C FL505 1-233-893-21 FILTER, CHIP EMI D701 8-719-975-40 DIODE RB411D-T146 FL506...
Page 69 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC505 8-759-490-71 IC BA5912AFP-YE2 IC764 8-749-924-62 PHOTO COUPLER PC410T IC765 8-749-924-62 PHOTO COUPLER PC410T IC506 8-759-338-95 IC NJM2903V (TE2) IC766 8-749-924-62 PHOTO COUPLER PC410T IC507 8-759-082-61 IC TC4W53FU (TE12R) IC767 8-749-013-16 IC PC357N2T IC508...
Page 70 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R528 1-216-837-11 METAL CHIP 1/16W R600 1-216-797-11 METAL CHIP 1/16W R529 1-216-823-11 METAL CHIP 1.5K 1/16W R530 1-216-833-11 RES, CHIP 1/16W R601 1-216-797-11 METAL CHIP 1/16W R531 1-216-845-11 METAL CHIP 100K 1/16W...
Page 71 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R664 1-216-864-11 METAL CHIP 1/16W R729 1-216-833-11 RES, CHIP 1/16W R667 1-216-845-11 METAL CHIP 100K 1/16W R669 1-216-864-11 METAL CHIP 1/16W R730 1-216-833-11 RES, CHIP 1/16W R670 1-216-864-11 METAL CHIP 1/16W R731...
Page 72 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R808 1-216-809-11 METAL CHIP 1/16W R886 1-216-814-11 METAL CHIP 1/16W R809 1-216-807-11 METAL CHIP 1/16W R810 1-216-813-11 METAL CHIP 1/16W R887 1-216-814-11 METAL CHIP 1/16W R811 1-216-809-11 METAL CHIP 1/16W R888 1-216-832-11 METAL CHIP...
Page 73 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R955 1-216-842-11 METAL CHIP 1/16W TP507 1-535-757-11 CHIP, CHECKER R959 1-216-805-11 METAL CHIP 1/16W TP508 1-535-757-11 CHIP, CHECKER R966 1-216-833-11 RES, CHIP 1/16W TP511 1-535-757-11 CHIP, CHECKER R968 1-216-837-11 METAL CHIP 1/16W...
Page 74 POWER Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4724-529-A POWER BOARD, COMPLETE D410 8-719-210-30 DIODE F10P20F (R) D411 8-719-210-38 DIODE F10P20FR *********************** D451 8-719-175-88 DIODE RD7.5F-T7B3 1-533-233-11 HOLDER, FUSE 2-259-121-01 SCREW, TR D452 8-719-983-94 DIODE MTZJ-T-72-36D 4-921-402-01 HEAT SINK D453 8-719-200-82 DIODE 11ES2-TA2B...
Page 75 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C004 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100V C069 1-109-982-11 CERAMIC CHIP C005 1-163-101-00 CERAMIC CHIP 22PF C070 1-104-760-11 CERAMIC CHIP 0.047uF C072 1-164-004-11 CERAMIC CHIP 0.1uF C006 1-163-101-00 CERAMIC CHIP 22PF C073 1-124-778-00 ELECT CHIP...
Page 76 SLD-FG SLD-MOT Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R006 1-216-295-00 SHORT R078 1-216-073-00 METAL CHIP 1/10W R079 1-216-085-00 METAL CHIP 1/10W R007 1-216-295-00 SHORT R081 1-216-073-00 METAL CHIP 1/10W R008 1-216-689-11 METAL CHIP 1/10W R082 1-216-077-91 RES, CHIP 1/10W...
Page 77 SW-L SW-R Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < CONNECTOR > R1061 1-216-025-00 RES, CHIP 1/10W * CN015 1-573-044-11 SOCKET, CONNECTOR 5P R1062 1-216-025-00 RES, CHIP 1/10W R1063 1-216-025-00 RES, CHIP 1/10W < DIODE > R1064 1-216-025-00 RES, CHIP 1/10W...
Page 78 SCD-1/777ES Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-865-537-31 MANUAL, INSTRUCTION ************** HARDWARE LIST (SWEDISH, ITALIAN, PORTUGUESE) (SCD-1: AEP) ************** 3-868-032-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH) 7-685-880-04 SCREW +BVTT 4X6 (S) (SCD-777ES) 7-682-361-04 SCREW +RK 4X8 (SCD-1, SCD-777ES: GOLD)

Sony SCD-1/777ES Service Manual

Quick Links

TABLE OF CONTENTS

Related Manuals for Sony SCD-1/777ES

Summary of Contents for Sony SCD-1/777ES

Table of Contents