Greyhound 65761 Set Up And Operating Instructions Manual page 20

problem
Engine misfires
engine stops
suddenly
engine knocks
Engine backfires
Follow all safety precautions whenever diagnosing or servicing the
equipment or engine.
SKU 65761 For technical questions, please call 1-800-444-3353.
troubleshooting
possible causes
1. Spark plug wire loose.
2. Incorrect spark plug gap or
damaged spark plug.
3. Defective spark plug wire.
4. Old or low quality gasoline.
5. Incorrect compression.
1. Low oil shutdown.
2. Fuel tank empty or full of impure or
low quality gasoline.
3. Defective fuel tank cap creating
vacuum, preventing proper fuel flow.
4. Improper idle speed.
5. Faulty magneto, incorrect timing, or
clogged carburetor.
1. Old or low quality gasoline.
2. Engine overloaded.
3. Incorrect spark timing, deposit
buildup, worn engine, or other
mechanical problems.
1. Impure or low quality gasoline.
2. Engine too cold.
3. Choke not open after engine warm.
4. Engine not properly adjusted for
high altitude operation.
5. Intake valve stuck, choke stuck,
incorrect timing, clogged carburetor,
or overheated engine.
probable solutions
1. Check wire connections.
2. Re-gap or replace spark plug.
3. Replace spark plug wire.
4. Use only fresh 89+ octane unleaded
gasoline.
5. Diagnose and repair compression.
(Use engine will not start:
coMpression reLated
section.)
1. Fill engine oil to proper level. Check
engine oil before EVERY use.
2. Fill fuel tank with fresh 89+ octane
unleaded gasoline.
3. Test/replace fuel tank cap.
4. Properly adjust idle speed.
5. Have qualified technician diagnose
and service engine.
1. Fill fuel tank with fresh 89+ octane
unleaded gasoline.
2. Do not exceed equipment's load
rating.
3. Have qualified technician diagnose
and service engine.
1. Fill fuel tank with fresh 89+ octane
unleaded gasoline.
2. Use cold weather fuel and oil
additives to prevent backfiring.
3. Move choke to run position after
engine warms up.
4. Qualified technician must adjust
engine at altitudes greater than
5,000 feet above sea level.
5. Have qualified technician diagnose
and service engine.
Page 20