Malone VersaRail MPG220-221 Quick Start Manual

MALONE
● Check Online vehicle fit guide before use.
● NOT SUITABLE FOR 2 DOOR VEHICLES.
● All items being carried (surfboards, sail boards, kayaks, ladders etc.) require the use
of front and rear tie-down straps (not included). Bow and stern safety tie-downs are
required for all Malone rooftop transport(s). Failure to correctly install and use safety
tie-down lines voids all warranty and liability.
● This product May Not be Suitable for use on vehicles that are fitted with side curtain or
overhead airbags. The straps can prohibit the airbags from deploying properly.
● Crossbars must be at least 24" apart for safe transport.
● Do not tamper with load strap and/or buckle while in transit.
● Do Not Use In Rain, water can potentially run down nylon strapping when wet
and into vehicle.
● Remove the product before entering a carwash.
● Make sure your vehicle roof is clean from any dust and dirt before installing.
● The VersaRail
TM
should not be left fitted to the vehicle when not in use.
● The VersaRail
TM
IMPORTANT MOUNTING NOTES ON NEXT PAGE
R
!

Important Notes:

has been designed as a temporary roof load carrying system and
is NOT suitable for use with rooftop tents.
Warnings / Limitations: The load you are carrying plu
rack must not exceed the maximum weight limitatio
factory rack. Before installing, confirm your vehicle's f
Installation & Loading Instructions - Please Read
1
. Lift the forward section of the tower to
adjust it's position. Center towers over
the raised side rails. See image 2.
3
S
T
VersaRail
T EE O L
UNIVERSAL CROSS BAR SYSTEM
MPG220-221& MPG224
Cross Bars with Locks & End Caps
!
Step 1: Vehicle
. Remove the cross b
the packaging. Us
the security shield
into the hex head
clockwise to widen
feet. See image 1.
. Place cross bars on
Adjust the distance
be carried. Note:
minimum of 24". S
TM
P
TM
Rubber Space
2