Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your dealer with questions regarding installation, operation or service.
NOTICE: DO NOT discard this manual!
Model:
SL-7BV
In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas fitter.
See appliance installation manual for additional
Commonwealth of Massachusetts requirements.
Owner's Manual
Care and Operation
Heat & Glo • SL-7BV Owner's Manual • 2395-981 Rev. F • 1/19
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
• DO NOT store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas sup-
plier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or the
gas supplier.
DANGER
DO NOT TOUCH GLASS
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of
burns from the hot viewing glass is provided
with this appliance and shall be installed for
the protection of children and other at-risk
individuals.
Pour demander un exemplaire en français de ce Manuel
du propriétaire, visitez www.heatnglo.com/translations.
HOT GLASS WILL
CAUSE BURNS.
UNTIL COOLED.
TO TOUCH GLASS.
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Heat & Glo SL-7BV
Summary of Contents for Heat & Glo SL-7BV
- Page 1 Pour demander un exemplaire en français de ce Manuel du propriétaire, visitez www.heatnglo.com/translations. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 2: Welcome
00,000 00,000 00,000 MIN. MIN. INPUT INPUT BTUH: BTUH: 00,000 00,000 00,000 00,000 Serial Serial XXXXXXXX XXXXXXXX ORIFICE ORIFICE SIZE: SIZE: #XXXXX #XXXXX #XXXXX #XXXXX (Serie): (Serie): Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 3: Table Of Contents
C. Contact Information ......23 = Contains updated information. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 4: Limited Lifetime Warranty
Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645H 10/15 Page 1 of 2 Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... - Page 5 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645H 10/15 Page 2 of 2 Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 6: Product Specific Information
U.S.A. and the CAN/CGA B149 Installation Codes in Canada. Installation and service of this appliance should be performed by qualified personnel. Hearth & Home Technologies recommends HHT Factory Trained or NFI certified professionals. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 7: Important Safety And Operating Information
• Install a switch lock or a wall/remote control with child protection lockout feature. • Keep remote controls out of reach of children. • Never leave children alone near a hot fireplace, whether operating or cooling down. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 8: General Operating Parts
30 degrees or more depending on the thermometer settings and material characteristics being measured. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... - Page 9 Sugges ons on how to further reduce TV temperatures: Increase “A” dimension. Increase “C” dimension, however, increasing “B” dimension beyond maximum recommended typically results in higher temperatures. Figure 3.4. Good Faith TV Guidelines Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 10: Before Lighting Appliance
• Ensure that the glass is sealed and in the proper position and that the integral barrier is in place. WARNING! Risk of Fire or Asphyxiation! DO NOT op- erate fireplace with fixed glass assembly removed. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 11: Lighting Instructions (Ipi)
Propane Installation code, CSA B149.1. P65Warnings.ca.gov. For additional information on operating your Keep burner and control compartment clean. See installation and operating instructions accompanying appliance. refer to www.hearthnhome.com. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 12: Appliance Break-In
Battery polarity must be correct or module damage will occur. See Figure 3.5. A complete wiring diagram is included in the Electrical section of the appliance Installation Manual. Figure 3.5. Control Cavity Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 13: Detailed Component Operating Instructions - Intellifire Ignition
If desired, a fan kit may be added. Contact your dealer to order the correct fan kit. Heat management for the fan is discussed in Section 3.G. Detailed instructions are in- cluded with the fan kit. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 14: Maintenance And Service
• Reinstall decorative front. CAUTION! Risk of Burns! The fireplace shall be turned off and cooled before servicing. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... - Page 15 • Inspect for corrosion or separation. • Verify weather stripping, sealing and flashing remains intact. • Inspect draft shield to verify it is not damaged or missing. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 16: Maintenance Tasks - Qualified Service Technician
• Remove all foreign objects. • Verify unobstructed air circulation. Figure 4.2 IPI Pilot Flame Patterns - Generic Pilot Bracket Shown Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 17: Frequently Asked Questions And Troubleshooting
Installer’s Manual for this the touch. appliance. Contact your dealer for additional information regarding operation and troubleshooting. Visit www.heatnglo.com to locate a dealer. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 18: Troubleshooting
Verify module is securely grounded to metal chassis of appliance. D. Module voltage output / Valve/Pilot Verify battery voltage is at least 2.7 volts. Replace batteries if volt- solenoid ohms readings. age is below 2.7. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... - Page 19 ON position. If there is no spark at “I” terminal module must be replaced. If there is a spark at “I” terminal, module is fine. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 20: Reference Materials
After a qualified service technician has installed the Heat-Zone Gas Kit, follow the instruction supplied with the ® kit for operation. See your dealer if you have questions. Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... -
Page 21: Service Parts
High Limit Switch SRV4021-383 Lava Rock 4021-297 Mineral Wool 050-721 Touch Up Paint TUP-GBK-12 Additional service part numbers appear on following page. 1/19 Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19... - Page 22 NGK-SL7 Conversion Kit LP LPK-SL7 Pilot Ori ce NG SRV593-528 Pilot Ori ce LP SRV593-527 Regulator NG SRVNGK-DXV Regulator LP Not Available - Must replace Gas Valve Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...
-
Page 23: Contact Information
6053165, 6145502, 6374822, 6484712, 6601579, 6769426, 6863064, 7077122, 7074035, 7098269, 7258116, 7322819, 7470729, 7726300, 8147240, 9625149 or other U.S. and foreign patents pending. 2000-945D Printed in U.S.A. - Copyright 2019 Heat & Glo • SL-7BV Owner’s Manual • 2395-981 Rev. F • 1/19...