Safety; Precautionary Statements; Servicing The Tractor - New Holland TC29D Repair Manual

SECTION 00 - - GENERAL INFORMATION - - CHAPTER 1
A careful operator is the best operator. Most accidents can be avoided by observing certain precautions. To help
prevent accidents, read the following precautions before operating this equipment. Equipment should be oper-
ated only by those who are responsible and instructed to do so.
Carefully review the procedures given in this manual with all operators. It is important that all operators be familiar
with and follow safety precautions.
THE TRACTOR
1. Read the Operator's Manual carefully before
using the tractor. Lack of operating knowledge
can lead to accidents.
2. Use an approved roll bar and seat belt for safe
operation. Overturning a tractor without a roll bar
can result in death or injury. If your tractor is not
equipped with a roll bar and seat belt, see your
New Holland Dealer.
3. Always use the seat belt. The only instance when
the seat belt should not be used is if the roll bar
has been removed from the tractor.
4. If a front end loader is to be installed, always use
a FOPS (Falling Object Protective Structure)
canopy to avoid injury from falling objects.
5. Use the handholds and step plates when getting
on and off the tractor to prevent falls. Keep steps
and platform cleared of mud and debris.
6. Do not permit anyone but the operator to ride on
the tractor. There is no safe place for extra riders.
7. Keep all safety decals clean of dirt and grime,
and replace all missing, illegible, or damaged
safety decals. See the list of decals in the Decal
section of this manual.

SERVICING THE TRACTOR

1. The cooling system operates under pressure
which is controlled by the radiator cap. It is
dangerous to remove the cap while the system is
hot. Always turn the cap slowly to the first stop
and allow pressure to escape before removing
the cap entirely.
2. Keep any type of open flame away from the
tractor and do not smoke while refueling. Wait for
the engine to cool before refueling.

SAFETY

PRECAUTIONARY STATEMENTS

00-3
3. Keep the tractor and equipment, particularly
brakes and steering, maintained in a reliable and
satisfactory condition to ensure your safety and
comply with legal requirements.
4. Keep open flame or cold weather starting aids
away from the battery to prevent fires or
explosions. Use jumper cables according to
instructions to prevent sparks which could cause
explosion.
5. Stop the engine before performing any service
on the tractor.
6. Escaping hydraulic/diesel fluid under pressure
can penetrate the skin causing serious injury. If
fluid is injected into the skin, obtain medical
attention immediately or gangrene may result.
DO NOT use your hand to check for leaks.
•
Use a piece of cardboard or paper to search
for leaks.
Stop the engine and relieve pressure before
•
connecting or disconnecting lines.
Tighten all connections before starting the
•
engine or pressurizing lines.
7. Do not modify or permit anyone else to modify or
alter this tractor or any of its components or
functions without first consulting a New Holland
Dealer.
8. The fuel oil in the injection system is under high
pressure and can penetrate the skin. Unqualified
persons should not remove or attempt to adjust
a pump, injector, nozzle, or any other part of the
fuel injection system. Failure to follow these
instructions can result in serious injury.
9. Continuous long-term contact with used engine
oil may cause skin cancer. Avoid prolonged
contact with used engine oil. Wash skin promptly
with soap and water.