Advertisement
Quick Links
Date Code Label
EN
Here
Owner's Manual
for
Battery Ride On
This manual contains important safety, assembly, operation
and maintenance information.
Please read and fully understand this manual before
operation.
Save this manual for future reference.
Always wear approved helmet and safety equipment when
using this product.
See back page for Customer Service Information
Advertisement
Related Manuals for Huffy True Timber
Summary of Contents for Huffy True Timber
- Page 1 Date Code Label Here Owner’s Manual Battery Ride On This manual contains important safety, assembly, operation and maintenance information. Please read and fully understand this manual before operation. Save this manual for future reference. Always wear approved helmet and safety equipment when using this product.
- Page 2 Owner’s Manual Index Safety and Warnings ...................2-6 Parts and Assembly ....................7-9 Operation and Charging Battery ............10-12 Maintenance Repair and Service ............13-15 • General Info, Battery Storage, Replacement and Disposal Troubleshooting ....................16-17 Warranty ..........................19 Back Cover: • Return and Service Contact information •...
- Page 3 WARNING - TO AVOID SERIOUS INJURY: Here are basic, common sense safe riding practices you should read aloud to your child and anyone who may use the vehicle. It is the responsibility of the adult to educate the child, determine if they are fi t to operate the vehicle, and supervise use.
- Page 4 WARNING - TO AVOID SERIOUS INJURY: vehicle in loose dirt, mud, sand, or fi ne gravel may damage the electronics and gear box inside the vehicle. • Do not overload the vehicle. Do not drive in very hot weather, components may over- heat.
- Page 5 BATTERY & CHARGER WARNINGS: The following safety hazards may result in serious injury or death to the user of the vehicle: • Battery Charger is NOT to be used by Children. • Rechargeable battery is only to be charged by adults. •...
- Page 6 Radio Frequency Information (if applicable) CAUTION : Changes or modifi cations to this unit not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. This device or charger/adapter complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference (2) this device must accept any interference received, including interference that may cause undesired operation.
- Page 7 Introduction to Assembly THIS OWNER’S MANUAL IS MADE FOR SEVERAL DIFFERENT BICYCLES: • Some illustrations may vary slightly from the actual product. • Follow instructions completely. • If the bicycle has any parts that are not described in this manual, look for separate “Special Instructions”...
- Page 8 Parts Assembly NOTE: Some Parts Shown are assembled on both sides of vehicle Tools Required Screwdriver(not included) Pliers(not included) Hammer(not included) Spanner(not included) Vehicle body Handlebar1 Bumper1 Washer1 Nut1 M3.5X12 Screw...
- Page 9 Parts Assembly Description Description Vehicle Body M8 Nut (x1) Handlebar M3.5 x 12 Screw (x3) Bumper Charger M10 Washer (x1)
- Page 10 Assembly INSTALL HANDLEBAR: • Position Handlebar as shown and insert J-Bar down into body hole. • Firmly connect Power Plug and insert extra wire down into body hole making sure no wires are pinched or bound up. • Proceed to next steps. WITH UNIT ON IT’S SIDE: •...
- Page 11 Assembly M3.5x12 Screw Bumper INSTALL FRONT BUMPER: • With unit up-side-down, position Front Bumper as shown to line up mounting holes. • Install Screws evenly and securely. ATTACH POWER CONNECTOR TO BATTERY: • If installed, remove Seat and Seat Screw. •...
- Page 12 Operation IMPORTANT! Always stop vehicle when changing the speed or direction to avoid damage the gear box and motor. (1) Press the Forward button to go forward. (2) To stop, release the button. The unit will gradually stop using motor friction. Circuit diagram WARNING Read and understand ALL warnings in front of this manual before...
- Page 13 Charging the Drive Battery: IMPORTANT! Before using the unit for the fi rst time the battery needs to be charged for at least 8 to 12 hours - no more than 20 hours. Once battery is depleted, recharge for 8 to 12 hours - no more than 20 hours. IMPORTANT! STEPS: Check the drive battery and charger (supply...
- Page 14 Maintenance Repair and Service GENERAL: • Check the tightness of the wheels: The vehicle should be checked NOTE: If the drive wheel is not tight, it will not for damage, missing or badly worn parts engage the gears and the vehicle will not run. before each use.
- Page 15 Drive Battery Replacement FOLLOW THESE STEPS IF THE BATTERY NEEDS TO BE REPLACED: NOTE: Batteries are installed, mounted and wired diff erently depending on model. Make a simple drawing on paper (or take pictures) how your battery is installed and how Red and Black wires are connected.
- Page 16 Drive Motor Battery Only an adult who has read and understands the safety warnings should handle, charge or recharge the battery. Failure to comply with all safety warnings may result in serious injury or death. Battery Fuse The drive motor circuit features a thermal fuse that will automatically trip and cut all power to the vehicle if the motor, electric system or battery is overloaded.
- Page 17 Troubleshooting Guide The following are examples of potential problems. Completely read through this manual and the troubleshooting guide table before calling. If you still need help resolving the problem please contact Customer Service. NOTE: Vehicle should be turned off and fully changed before doing troubleshooting. Problem Possible Cause Solution...
- Page 18 Troubleshooting Guide - continued BEFORE YOU CALL SUPPORT: What is the model and date code? When was the product purchased? Has the product ever worked for a time or has never worked at all since purchase? • Yes, When did the product last operate correctly? •...
- Page 19 Limited Warranty - US General: • Modifi ed with the addition of a motor • Ridden by more than one person at a time Part or model specifi cations are subject to change • Rented, sold, or given away without notice. •...
- Page 20 Nos Complace Ayudarlo Con Cualquier Parte O Problema De Ensamblado Que Pudiera Tener. O LLAME AL TEL: Para obtener Servicio al cliente rápido, visite: 800 1 HUFFY 1 (800 1 48339 1) www.huff ybikes.com.mx (Mexico only) Contáctanos por WhatsApp al 222 422 4955 Para comunicarse por correo electrónico:...