Campbell Hausfeld VH300300 Operating Instructions And Parts List Manual

See Warranty on page 8 for important information about commercial use of this product.
Operating Instructions and Parts List
Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described.
Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or
property damage! Retain instructions for future reference.
Table of Contents
Description . . . . . . . . . . . . . . . . . . . . . 1
Unpacking . . . . . . . . . . . . . . . . . . . . . . 1
Safety Guidelines . . . . . . . . . . . . . . . . 1
General Safety Information . . . . . . 1 - 2
Specifications. . . . . . . . . . . . . . . . . . . . .2
Assembly . . . . . . . . . . . . . . . . . . . . . . . 3
Maintenance . . . . . . . . . . . . . . . . . . . . 3
Replacement Parts List . . . . . . . . . . 4 - 5
Troubleshooting Chart . . . . . . . . . . . . 6
Warranty . . . . . . . . . . . . . . . . . . . . . . . 8
Description
Single and two cylinder, single stage,
oil lubricated air compressor pumps
are intended for use as replacements
on air compressor units, and for use as
components in specially designed air
compressor systems. For replacement
use, the compressor pump must match
the vibration characteristics of the
original pump. The compressed air from
these pumps is intended to be used with
air tools and spray guns. Atmospheric
moisture and trace oil from compressors
may require additional treatment
for some application. All models are
equipped with solid cast-iron cylinders
and crankcase, an aluminum head and
stainless steel valves.
Unpacking
After unpacking the unit, inspect
carefully for any damage that may
have occurred during transit. Make sure
to tighten fittings, bolts, etc., before
putting unit into service.
© 2008 Campbell Hausfeld / Scott Fetzer
READ & FOLLOW ALL INSTRUCTIONS
SAVE THESE INSTRUCTIONS
DO NOT DISCARD
Safety Guidelines
This manual contains information
that is very important to know and
understand. This information is
provided for SAFETY and to PREVENT
EQUIPMENT PROBLEMS. To help
recognize this information, observe the
following symbols.
hazardous situation which, if not
avoided, WILL result in death or serious
injury.
hazardous situation which, if not
avoided, COULD result in death or
serious injury.
hazardous situation which, if not
avoided, MAY result in minor or
moderate injury.
information, that if not followed, may
cause damage to equipment.
NOTE: Information that requires special
attention.
General Safety Information
CALIFORNIA PROPOSITION 65
contain chemicals known to the State
of California to cause cancer and birth
defects or other reproductive harm.
Wash hands after handling.
REMINDER: Keep your dated proof of purchase for warranty purposes!
Attach it to this manual or file it for safekeeping.
For parts, product & service information
visit www.chpower.com
Air Compressor
Pump
This compressor/pump is NOT
equipped and should NOT be
used "as is" to supply breathing
quality air. For any application of
air for human consumption, you
must fit the air compressor/pump
with suitable in-line safety and
alarm equipment. This additional
equipment is necessary to
Danger indicates an
properly filter and purify the air
imminently
to meet minimal specifications for
Grade D breathing as described
in Compressed Gas Association
Commodity Specification G 7.1,
Warning indicates a
OSHA 29 CFR 1910. 134, and/or
potentially
Canadian Standards Associations
(CSA).
DISCLAIMER OF WARRANTIES
Caution indicates a
In the event the compressor is
potentially
used for the purpose of breathing
air application and proper in-line
safety and alarm equipment is
not simultaneously used, existing
Notice indicates
important warranties are void, and Campbell
Hausfeld disclaims any liability
whatsoever for any loss, personal
injury or damage.
This product or
dust when you cut, sand, drill
its power cord may
or grind materials such as
wood, paint, metal, concrete,
cement, or other masonry. This dust
often contains chemicals known to
cause cancer, birth defects, or other
reproductive harm. Wear protective
gear.
VH300300
Breathable Air Warning
You can
create
IN626800AV 7/08