Page 1
This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well.
Model 579 Wiring Diagram and Electrical Schematic ..........12 Model 579 Upper-Half Drawing .................. 14 Model 579 Upper-Half Parts List ................15 Model 579 Lower-Half Drawing .................. 16 Model 579 Lower-Half Parts List ................17 Operator's Manual 579 Carpetmaster Page 2 ® Clarke...
WARNING: Always use a three-wire electrical system connected to the electrical ground. For maximum protection against electric shock, use a circuit that is protected by a ground fault circuit interrupter. Consult your licensed electrician and/or contact your local Clarke distributor for assistance.
You can use your Carpetmaster as a tank type vacuum cleaner to clean overhead and hard to reach areas. Get extension tubes, hoses, wands, and attachments from your Clarke dealer. Figure 2 To attach the accessories to your Carpetmaster, follow this 1.
If you use an extension cord, use an extension cord with minimum wire size 16 AWG. Do not use an exten- sion cord longer than 50 feet. Do not join two extension cords. Operator's Manual 579 Carpetmaster Page 5 Clarke ®...
How To Clean And Install The Filter Bag WARNING: Do not put a filter bag in an incinerator or fire. It could cause injury to the op- erator by causing a fire. Operator's Manual 579 Carpetmaster Page 6 ® Clarke...
3. Make sure the cloth bag or the paper filter bag is in posi- tion. 4. Push the Micro-Staphicidal filter on the base of the motor. See figure 9. Figure 9 5. Close the front cover. 1. Micro-Staphicidal Filter ® Operator's Manual 579 Carpetmaster Page 7 Clarke ®...
Open the cover to get access to the brush drive motor, belt, switches, and the air tun- nel. The release lever is at the rear of the machine. Operator's Manual 579 Carpetmaster Page 8 ®...
4. Set the machine upright. Make sure the handle is in the vertical position. WARNING: Do not operate this machine unless it is fully assembled. The machine could be damaged or injury could occur to the operator Operator's Manual 579 Carpetmaster Page 9 Clarke ®...
WARNING: The machine must be tested for electrical safety after electrical repairs are made. NOTE: For safe operation have your machine checked by a Clarke Authorized Repair Person every 12 months. Always use Clarke replacement parts. Operator's Manual 579 Carpetmaster Page 10 ®...
2. Replace the gasket if it is worn or broken. 6. The brush does not turn clockwise 1. Return the machine to a Clarke when seen from the right-hand Service Branch or a Clarke side of the machine.
Page 19
ALTO Nederland B.V. Vianen (770) 973-5225 Stuartweg 4C NL-4131 NJ Vianen +31 347 324000 ® Clarke Clarke American Sanders ALTO Sverige AB, Molndal (Sweden) A.L. Cook Aminogatan 18 Customer Service Headquarters and Factory Box 4029 2100 Highway 265 S-431 04 Molndal...
Page 20
(b). Return the product to the nearest Clarke repair location. Transportation charges to and from the repair location must be prepaid by the purchaser. (c). Clarke will repair the product and or replace any defective parts without charge within a reasonable time after receipt of the product.