Related Manuals for Power-flo PFEH Series
Summary of Contents for Power-flo PFEH Series
- Page 1 INSTALLATION, SERVICE & PARTS MANUAL Series: PFEH512 PFEH1022 PFEH1032 PFEH1042 0.5 & 1HP • 3450 RPM 60 Hz Submersible Effluent Pumps 877-24PUMPS • www.powerflopumps.com ISP No: PFEH - 1/2021...
-
Page 2: General Safety Information
PHASE: ______ HP: _________________ state and local codes. Requirements may vary depending on usage and location. ® Power-Flo is a registered trademark of Power-Flo Technologies Inc. Other brand and product names are trademarks or registered trademarks of their respective holders. Alteration Rights Reserved. -
Page 3: Specifications
TYPE INCH CODE AMPS AMPS PFEH512 115/1 3450 11.0 23.0 14/3 SJTOW 0.39 PFEH1022 230/1 3450 13.8 14/3 SJTOW 0.39 PFEH1032 230/3 3450 21.2 12/4 0.60 PFEH1042 460/3 3450 20.7 12/4 0.60 Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... - Page 4 PFEH Submersible Effluent Pumps Dimensions Performance Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
-
Page 5: Receiving And Installation
The shut-off valve is hot, or the load current passing through used to manually stop system flow them becomes too high. Bottom of Feet during pump servicing. Figure 1 Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... -
Page 6: Installation & Service
Replace oil. Leek must be Servicing located and repaired if pressure does not NOTE: Item numbers in ( ) refer to Figure 6. hold. Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... -
Page 7: Disassembly And Assembly
Apply pipe seal face. Replace the complete seal if for free rotation of impeller. thread compound to threads of pipe plug any part is damaged. (16) then assemble to housing (4). Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... -
Page 8: Power Cable Connection
(3). the seal tool. Be sure the stationary is in straight. Lightly oil (Do not use grease) shaft and inner surface of bellows. Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... - Page 9 Figure 5 - 230 Volt AC, 3Ph Models: PFEH1032 Power Cable Motor Lead Number Green (Ground) Green Black 1 & 7 2 & 8 White 3 & 9 4, 5 & 6 Together Figure 5 Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
-
Page 10: Repair Parts
Submersible Effluent Pumps For Repair Part Please supply: Model Number and MFG Date as shown on Repair Parts Name Plate, and Part Description and Part Number as shown on Parts List. Figure 6 Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... - Page 11 Grommet, For 1/2 & 1Hp, 3Ph PF92010004 Wire Connector, 3Ph PF94010012 Terminal 3/16” Terminal Connector, 1Ph PF94010027 = Aquire standard hardware locally. = OVERHAUL Kit. = Supplied as individual items. Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
-
Page 12: Parts List
(14), conduit bushing (25), washer (26). Typical Name Plate Model Number MFG Date AMPS VOLTAGE PHASE 60 Hz 877-24 PUMPS www.powerflopumps.com = Aquire standard hardware locally. = OVERHAUL Kit. = Supplied as individual items. Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com... -
Page 13: Troubleshooting Chart
NOTE: Power-Flo Pumps & Systems assumes no responsibility for damage or injury due to disassembly in the field. Disassembly of the pumps or supplied accessories other than at Power-Flo Pumps & Systems or its authorized service centers, automatically voids warranty. - Page 14 PFEH Submersible Effluent Pumps Notes: Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
- Page 15 PFEH Submersible Effluent Pumps Notes: Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
-
Page 16: Limited Warranty
Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which vary from state to state. Power-Flo Pumps & Systems • 877-24PUMPS • www.powerflopumps.com...
Need help?
Do you have a question about the PFEH Series and is the answer not in the manual?
Questions and answers