Related Manuals for A.J.Antunes RS-1000
Summary of Contents for A.J.Antunes RS-1000
- Page 1 Rapid Steamer Model RS-1000 Manufacturing Number: 9100650 www.antunes.com P/N 1011456 Rev A 2/18...
-
Page 2: Table Of Contents
CONTENTS GENERAL SERVICE/TECHNICAL ASSISTANCE General This manual provides the safety, installation, Warranty and operating procedures for your unit. If you experience any problems with the Information Please read all of the information contained installation or operation of your system, in this manual prior to installing and operat- Service/Technical contact Antunes Technical Service at +1- ing the unit. -
Page 3: Important Safety Information
IMPORTANT SAFETY WARNINGS The following tips are recommended for maintenance of your stainless steel INFORMATION Be advised of the following warnings when equipment: operating and performing maintenance on Always use soft, damp cloth for Use the following guidelines for safe opera- this unit. -
Page 4: Specifications
SPECIFICATIONS 17.82” (452.85 mm) 12.74” (323.82 mm) 20.64” (525.38 mm) Electrical Ratings Model & Plug Volts Watts Amps Hertz Mfg. No. Description RS-1000 L6-30P, 30 Amp., 250 VAC, 5000 50/60 9100650 Straight Twist Lock P/N 1011456 Rev A 2/18... -
Page 5: Installation
Water Pan Doing so can cause damage to the unit. Assembly Install components in unit. Connect the Water Pressure Figure 1. RS-1000 Components Regulator to the cold water line. Equipment Setup Icon Description When placing the unit into service, pay at- Menu Icon. -
Page 6: Operating Instructions
BUTTON CONNECTION The unit begins the cooking cycle. Figure 2. RS-1000 Controls The display shows the time remain- ing in the cooking cycle and beeps when cooking is complete. Remove the basket(s) from the unit and continue with food preparation as required. -
Page 7: Working With Menu Items
WORKING WITH MENU Editing a Menu Item Function screen. Then you are asked to enter a name for the new menu item. Do so ITEMS If you press the Edit Menu Item icon, the and press the RETURN button on the system displays a list of the existing menu on-screen keyboard. -
Page 8: Working With System Settings
WORKING WITH SYSTEM LOADING MENU DATA VIA From this screen you can change the following system settings: SETTINGS Degrees: F or C. Beep (sounds when cooking Follow these steps to access and edit the The unit is equipped with a USB interface cycle completes). -
Page 9: Maintenance
Allow to air dry. Wipe the exterior of the unit and the inner part of the basket cavity with a clean, sanitized towel. Clean up any spills completely. Allow to air dry. Figure 4. RS-1000 Steam Generator P/N 1011456 Rev A 2/18... -
Page 10: Checking And Cleaning Water Strainer
Checking and Cleaning Water NOTE: In soft water areas, it may be necessary to add a small amount Strainer of lime to generator to “season” To ensure proper and consistent steaming it. This will ensure proper steam- results, inspect the water pressure regula- ing characteristics by producing tor gauge and strainer cup regularly. -
Page 11: Troubleshooting
TROUBLESHOOTING Problem Possible Cause Corrective Action Power cord not correctly plugged in Plug in the power cord correctly. Unit displays system error: The power cord and/or electrical plug is Inspect electrical wire, plug, and receptacle. damaged “Zero Cross” Control board is inoperable Contact your maintenance person or Authorized Service Agency for service. -
Page 12: Replacement Parts
REPLACEMENT PARTS ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 0013093 Brkt Assy Top 2140101 Adhesive/ Sealant - Rtv 0013094 Brkt Assy Bottom 2140138 Loctite #262 (Red) 0013095 Bearing Brkt Assy 2150179 Sprocket, 25B14 1/2” Bore 0013111 Assy, Drive Chain Tensioner 2150187 Chain, Drive 0013338... - Page 13 REPLACEMENT PARTS (SHEET 1) P/N 1011456 Rev A 2/18...
- Page 14 REPLACEMENT PARTS (SHEET 2) P/N 1011456 Rev A 2/18...
- Page 15 REPLACEMENT PARTS (SHEET 3) P/N 1011456 Rev A 2/18...
- Page 16 REPLACEMENT PARTS (SHEET 4) P/N 1011456 Rev A 2/18...
- Page 17 REPLACEMENT PARTS (SHEET 5) P/N 1011456 Rev A 2/18...
- Page 18 REPLACEMENT PARTS (SHEET 6) P/N 1011456 Rev A 2/18...
-
Page 19: Wiring Diagram
WIRING DIAGRAM Figure 1. Wiring Diagram 1002739 Rev A P/N 1011456 Rev A 2/18... -
Page 20: Notes
NOTES P/N 1011456 Rev A 2/18... -
Page 21: Limited Warranty
LIMITED WARRANTY Equipment manufactured by A.J. Antunes & Co. (Antunes) has been constructed of the finest materials available and manufactured to high quality standards. These units are warranted to be free from electrical and mechanical defects for a period of one (1) year from date of purchase under normal use and service, and when installed in accordance with manu- facturer’s recommendations.
Need help?
Do you have a question about the RS-1000 and is the answer not in the manual?
Questions and answers