Table of Contents
Related Manuals for The Handy THPLT
Summary of Contents for The Handy THPLT
- Page 1 OPERATOR’S MANUAL AND PARTS LIST PETROL LINE TRIMMER - THPLT Spares & Support: 01793 333212 www.thehandy.co.uk Before use please read & understand this manual, paying particular attention to the safety instructions. 25/05/2011 Page 1...
-
Page 3: Table Of Contents
CONTENTS SAFETY INSTRUCTIONS SPECIFICATIONS FUEL ASSEMBLY AND OPERATION REPLACEMENT OF LINE AND SPOOL MAINTENANCE PARTS DIAGRAM AND LIST 10-11 TROUBLESHOOTING EC DECLARATION OF CONFORMITY Page 2... -
Page 4: Safety Instructions
SAFETY INSTRUCTIONS Read and understand the owner’s manual and labels affixed to the line trimmer. Learn its application and limitations as well as the specific potential hazards. Retain these instructions for reference. • Use sturdy footwear and a helmet with eye and ear protection. Protect exposed parts of your body. -
Page 5: Specifications
SPECIFICATIONS MODEL THPLT Cutting Diameter 381mm 0.75Kw/7800 minˉ¹ Max Output Power Bent Shaft Shaft Spool Type Bump Feed, twin line Line Diameter Line Length 2mm x 3m Fuel Tank Capacity 0.6L Bore and Stroke 34 x 28mm Fuel Type Unleaded... -
Page 6: Fuel
FUEL Petrol is very flammable. Do not fuel or use the chainsaw near a flame, sparks or while smoking. Allow the engine to cool before re-fuelling. Fuel the engine at least 3m away from your work area. • se a ratio of 25:1 unleaded petrol to 2-stroke mineral oil, for synthetic or semi-synthetic use the oil maker's ratio. -
Page 7: Assembly And Operation
ASSEMBLY AND OPERATION Assembling the Loop Handle: • Disassemble the loop handle. • Position the upper handle over the upper shaft just in front of the fixed rubber grip. The lower handle locates on the under- side of the shaft and should line up with the four screw holes on the upper handle. - Page 8 Starting the Trimmer: • Move the ignition switch to the “on” position. • Move the choke lever upwards to the “start” position (for cold start only). • Push the primer bulb 10 times until the petrol/oil mixture fills the primer bulb. •...
-
Page 9: Replacement Of Line And Spool
REPLACEMENT OF LINE Follow these steps to replace the cutting line: • Stop the engine. • Lay the trimmer on the floor so that the cutting head is facing up. • Remove the bump knob/retaining cap by turning it anti-clock- wise. -
Page 10: Maintenance
MAINTENANCE Before carrying out any maintenance, ensure that the trimmer engine is at a complete standstill. Air Filter: Accumulated dust in the air filter will reduce engine efficiency, increase fuel consumption and allow abrasive particles to pass into the engine. Remove and clean the air filter regularly to ensure optimum per- formance. -
Page 11: Parts Diagram And List
PARTS DIAGRAM Page 10... - Page 12 PARTS LIST Power Unit and Handle Parts: Part No Description TH142-1 Hand Wheel TH142-2 Coupling TH142-3 Throttle Lock TH142-4 Throttle Trigger TH142-5 Handle Left Side TH142-6 Handle Right Side TH142-7 Safety Throttle Lever TH142-8 On/Off Switch TH142-9 “D” Handle Line Trimmer Parts: Part No Description TH131-2...
-
Page 13: Troubleshooting
TROUBLE SHOOTING POSSIBLE CAUSE SOLUTION PROBLEM • • Power loss or sudden stop- Fuel Tank Empty Add fuel • • ping Mixture not reaching car- Drain and rinse out fuel burettor system • • Clean fuel filter Water in mixture •... -
Page 14: Ec Declaration Of Conformity
- Machinery Directive 2006/42/EC - Engine Emission Directive 2002/88/EC Handy Distribution Ltd hereby declares that the product: Machine Type: 25cc Line Trimmer Machine Model: THPLT Engine Displacement: 25.4 cm³ Max Motor Power: 0.75Kw Max Engine Speed: 7800/min Mass in Kg: 4.7Kg Cutting Capacity: 381mm Conforms to the main safety requirements of the EC Directives listed above. - Page 16 To order spare parts and see the complete range of garden machinery and garden equipment from Handy, visit: www.thehandy.co.uk Spares & Support: 01793 333212...