Table of Contents
Advertisement
5
Maintenance
5.1
General
This chapter is intended for qualified technicians and not for users. Repairs should
only be carried out by persons who have the training, knowledge or practical
experience to ensure that the repair is done properly.
Always disconnect the appliance from the mains before performing any maintenance.
•
Check that the appliance or machine has been returned to its proper state after carrying out
repair work. Technical equipment must not be re-started until all safety devices are in place.
•
Spare parts must at least correspond to the technical requirements specified by the
manufacturer of the equipment. Therefore only use original spare parts.
•
Regularly check the heater(s) and all oil lines for loose connections and leaks.
•
Always wear protective gloves.
•
When using oil boxes, the bleed valve on the oil boxes must be opened regularly to allow any
air which may have collected in the fuel lines to escape.
•
When using the heater seasonally, check that it is in good working condition before using it.
•
Perform maintenance to the heater at least once a year.
Recommended maintenance intervals. (by 8 till 10 hours operation/day)
Every 42 days: clean the photocell, the ignition electrodes and the burner disk.
Every 84 days: clean the fuel filter
Every 300 hours: replace the fuel filter by a new one.
Every eight months: clean the fuel tank.
Cleaning filter:
- unscrew the clear cup and remove particles
• take out the filter element and clean it
• fill the fual cup to approx. ¼ to facilitate operation of the ehater.
• refit all components making sure that gaskets are fitted and located
Cleaning photocell:
• take out the photocell
• clean the lens with a soft cloth
• refit the photocell in its holder put in in the wright position
30
Important: prevent dust accumulation,
clean the heater regularly
V16 HHO SERIES
Advertisement
Table of Contents
