Environmental Awareness; Battery Charger; On Board Charger; Off Board Charger - Cushman HAULER PRO 2022 Owner's Manual

O
PERATION

ENVIRONMENTAL AWARENESS

When driving the vehicle, be careful of potential environmental hazards like steep
slopes, rocks, tree branches, etc. that could cause an incident that could result in vehicle
damage, personal injury or death.
There is a risk of fire when the vehicle is operated near combustible material.
Always be respectful of the environment.
Respect all wildlife and their habitat.
Respect private property and comply with all local laws and regulations governing the use of light duty utility vehicles.
Make sure you are permitted by property owners to operate the vehicle on their property.
If operating your vehicle on private property, obtain permission from the owner prior to entering their property.

BATTERY CHARGER

The charger should be operated in accordance with the charger manufacturer's instructions. Always place the charger
outside the vehicle before and during the charging cycle. Never charge batteries in a hazardous environment.
Risk of electric shock. Connect the charger power cord to an outlet that is correctly
installed and connected to an electrical ground according to all codes and regulations. A
grounded outlet is necessary to decrease the risk of electric shock – do not use ground
adapters or replace the plug. Do not touch parts of output connector or battery terminals
that do not have insulation.
Disconnect the AC plug before you make or break the connections to a battery that is
charging. Do not open or disassemble the charger. Do not operate the charger if the AC
cord is damaged. Make sure qualified personnel does all repair work to the charger.
If equipped with Delta-Q QuiQ charger model nos. 913-4830-E3/E38/E5/E58
manufacturer User's Guide for operating instructions, maintenance instructions and troubleshooting instructions.
To prevent over-heating that can cause damage to the charger and possible fire, keep the
air fins clear. Install portable chargers on a platform above the ground to allow maximum
air flow around and below the charger.
The power AC cord has a plug with a ground post. Do not remove, cut or bend the
ground post.

On Board Charger

The on board charger (if equipped) is located under the rear seat. It is wired directly to the batteries. Before charging
the batteries, park the vehicle in a well ventilated area, engage the parking brake, turn key switch to OFF and remove
key. Plug charger cord into a dedicated 15 amp AC outlet to activate the charger. When the charging cycle is com-
plete, unplug the charging cord and correctly store the cord.

Off Board Charger

The off board or portable charger must have a dedicated 15 amp AC circuit. The charger should be placed in an area
that permits good air flow around and under the charger Read and follow the operation instructions supplied by the
manufacturer with the charger. Before charging the batteries, park the vehicle in a well ventilated area, engage the
parking brake, turn the key switch to the OFF position, and remove the key. Connect the AC cord to a dedicated 15
amp AC outlet to activate the charger. Plug the charger cord into the charge receptacle on the vehicle. Unplug and
properly store the cord when the charging cycle is complete.
The battery charger will test the temperature of the battery pack. If the temperature is too hot or too cold the charger
will shutdown. If the battery pack temperature is within the safe to charge range, the charger will operate.
26
,
refer to APPENDIX A for the charger