Suzuki 2009 Grand Vitara Owner's Manual page 240

Spark Plugs: 1, 2
Brakes: 6
INSPECTION AND MAINTENANCE
Front differential
(1)
(2)
Rear differential
(2)
(1) Oil filler and level plug
(2) Oil drain plug
7-19
Gear Oil Level Check
The manual transmission, transfer gears,
extension case and differentials (front and
rear) are lubricated with gear oil. To check
the gear oil level in any of the above loca-
tions, use the following procedure:
1) Park the vehicle on a level surface. Set
parking brake and stop the engine.
2) Remove the oil filler plug (1).
3) Check the inside of the hole with your
finger. If the oil level comes up to the
bottom of the plug hole, the oil level is
correct. If so, reinstall the plug.
4) If the oil level is low, add gear oil
through the filler plug hole (1) until the
66J006
oil level reaches the bottom of the filler
hole, then reinstall the plug.
(1)
66J007
Gear Oil Replacement
To change the gear oil in the manual trans-
mission, transfer case, extension case or
differential(s), use the following procedure:
1) Remove the oil filler plug (1).
2) Remove the drain plug (2), drain the oil
and reinstall the drain plug.
3) Pour new gear oil of the specified type
through the filler hole until the oil level
reaches the bottom of the filler hole.
4) Reinstall the filler plug.
WARNING
After driving the vehicle, gear oil tem-
perature may be high enough to burn
you. Wait until the oil filler plug is
cool enough to touch with your bare
hands before inspecting or replacing
gear oil.
CAUTION
When tightening these plugs, apply
sealing compound "SUZUKI Bond
No. 1215" or equivalent to the plug
threads to prevent oil leakage and
tighten them to the specified torque
shown below.
79K20-03E