Page 1 " _ . _...
Page 2: Table Of Contents
This section tells you what to do if you have a problem while driving, such as a flat tire or overheated engine, etc. Service and Appearance Care Here the manual tells you how to keep your Pontiac running properly and looking good. Maintenanceschedule This section tells you when perform vehicle maintenance and what fluids and lubricants to use.
Page 3 “General Motors of Canada Limited” for Pontiac Division whenever it appears in this manual. Please keep this manual in your Pontiac, so it will be there if you ever need it when you’re on the road. If you sell the vehicle, please leave this manual in it so the new owner can use it.
Page 4: How To Use This Manual
How to Use This Manual Many people read their owner3 manual from beginning to end when they first receive their new vehicle. If you do this, it will help you learn about the €eatures and controls for your vehicle. In this manual, you’ll find that pictures and words work together to explain things quickly.
Page 5: Vehicle Damage Warnings
Vehicle Damage Warnings Also, in this book you will find these notices: NOTICE: These mean there is something that could 7iam;rge y w r vekicie, In the notice area, we tell you about something that can damage your vehicle. Many times, this damage would not be covered by your warranty, and But the notice will tell you what to do to help avoid the damage.
Page 6 Vehicle Symbols These are some of the symbols you may find on your vehicle. For example, These symbols these symbols are important are used on an for you and original battery: your passengers whenever your vehicle CAUTION driven: POSSIBLE INJURY DOOR LOCK PROTECT UNLOCK...
Page 7 NOTES...
Page 8: Seats And Restraint Systems
Section 1 Seats and Restraint Systems Here you’ll find in€omation a b u t the seats in your Pontiae and how to use your safety belts properly. You can also learn about some things you should not do with air bags and safety belts. Seats and Seat Controls This section tells you about the seats them...
Page 9: Reclining Front Seatbacks
Front Passenger Seat Move the lever under the passenger’s seat to unlock it. Slide the seat to where you want it. Then release the lever and try to move the seat with your body, to make sure the seat is locked into place. Manual Lumbar Support (Option) The manual lumbar support control is located at the front of the driver’s seat, toward the right.
Page 10 But don’t have a seatback reclined if your vehicle is moving. CAUTION: Sitting in a reclined position when your vehicle is in motion can be dangerous. Even if you buckle up, your safety belts can’t do their you’re reclined like this. The shoulder belt can’t do its job because it won’t be against your body.
Page 11: Head Restraints
Head Restraints Slide the head restraint up or down so that the top of the restraint is closest to the top of your ears. This position reduces the chance of a neck injury in a crash. Seatback Latches (2-Door Models) To fold a front seat forward, lift the seatback latch.
Page 12: Rear Seats
Easy Entry Seat (2-Door Models) CAUTION: If an easy entry right front seat isn’t locked, it can move. In a sudden stop or crash, the person sitting there could be injured. After you’ve used it, be sure to push rearward on an easy entry seat to be sure it is locked.
Page 13: Safety Belts: They're For Everyone
Safety Belts: They’re for Everyone This part of the manual tells you how to use safety belts properly. It also tells you some things you should not do with safety belts. And it explains the Supplemental Restraint System (SRS), or air bag system. CAUTION: Don’t let anyone ride where he or she can’t wear a safety belt properly.
Page 14: Why Safety Belts Work
Why Safety Belts Work When you ride in or on anything, you go fast as it goes. Put someone on it. Take the simplest vehicle. Suppose it's just seat on wheels.
Page 15 it up speed. Then stop the vehicle. The doesn’t stop. The person keeps going until stopped by something. rider a real vehicle, could be the windshield...
Page 16 or the safety belts! or the instrument panel With safety belts, you slow down as the vehicle does. You get more time to stop. You stop over more distance, and your strongest bones take the forces. That's why safety belts make such good sense.
Page 17 Here Are Questions Many People Ask About Safety Beits and the Answers Won’t I trapped in the vehicle after an accident if I’m wearing a safety belt? You could whether you’re wearing a safety belt or not. But you can unbu’ckle a safety belt, even if you’re upside down.
Page 18: How To Wear Safety Belts Properly
And there are different rules smaller children and babies. If a child will your Pontiac, see the part of this manual called “Children.” Follow those rules for everyone’s protection. First, you’ll want to know which restraint systems your vehicle has.
Page 19 3. Pick up the latch plate and pull the belt across you. Don’t let it get twisted. 4. Push the latch plate into the buckle until it clicks. 1-12 If the belt stops before it reaches the buckle, tilt the latch plate and keep pulling until you can buckle the belt.
Page 20 5. To make the tight, lap part pull down the belt as you pull on the shoulder belt. on the buckle of the belt should be worn low and snug The lap part on the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones.
Page 21 Shoulder Belt Height Adjuster (4-Door Models) Before you begin to drive, move the shoulder belt adjuster to the height that is right for you. 1-14 To move it down, squeeze the release button and move the adjuster to the desired position. adjuster up just by pushing up on the shoulder belt guide.
Page 22 &: What's wrong with this? CAUTION: You can be seriously hurt if your shoulder belt is too loose. In a crash, you would move forward too much, which could increase injury. The shoulder belt should fit against your body. The shoulder belt is too loose. It won't give nearly as much protection this way.
Page 23 What’s wrong with this? The belt is buckled in the wrong place. 1-16 CAUTION: You can be seriously injured if your belt is buckled in the wrong place like this. In a crash, the belt would go up over your abdomen. The belt forces would be there, not at the pelvic bones.
Page 24 What's wrong with this? The shoulder belt is worn under the arm. It should over the shoulder all times. worn CAUTION: You can be seriously injured if you wear the shoulder belt under body would move too far forward, which would kLa-tzzrse Also, belt...
Page 25 What’s wrong with this? CAUTION: You can be seriously injured by a twisted belt. In a crash, you wouldn’t have the full width of the belt to spread impact forces. If a belt is twisted, make it straight so it can work properly, or ask your dealer to The belt is twisted across the body.
Page 26: Supplemental Restraint System (Srs)
Supplemental Restraint System (SRS) This part explains the Supplemental Restraint System (SRS) or air bag system. Your Pontiac has two air bags one air bag for the driver and another air bag for the right front Here are the most important things to know about the air...
Page 27 CAUTION: Air bags inflate with great force, faster than the blink of an eye. If you’re too close to a n inflating air bag, it could seriously injure you. Safety belts help keep you in position for a n air bag inflation crash.
Page 28: How The Air Bag System Works
How the Air Bag System Works Where is the air bag? driver’s bag is in the middle of the steering wheel. The right front passenger’s air bag is in the instrument panel on the passenger’s side. 1-21...
Page 29 CAUTION: Don’t put anything on, or attach anything to, the steering wheel or instrument panel. Also, don’t put anything (such as pets or objects) between any occupant and the steering wheel or instrument panel. If something is between an occupant and an air bag, it could affect the performance of the air bag or worse, it could cause injury.
Page 30 How does an air bag restrain? In moderate to severe frontal or near-frontal collisions, even belted occupants can contact the steering wheel or the instrument panel. The air bag supplements the protection provided by safety belts. Air bags distribute the force of the impact more evenly over the occupant’s upper body, stopping the occupant more gradually.
Page 31 1-24 Servicing Your Air Bag-Equipped Pontiac Air bags affect how your Pontiac should be serviced. There are parts of the air bag system in several places around your vehicle. You don’t want inflate while someone is working on your vehicle. Your...
Page 32: Safety Belt Use During Pregnancy
Safety Belt Use During Pregnancy Safety belts work for everyone, including pregnant women. Like all occupants, they are more likely to be seriously injured if they don’t wear safety belts. A pregnant woman should wear a lap-shoulder belt, and the lap portion should be worn as low as possible, below the rounding, throughout the pregnancy.
Page 33: Rear Seat Outside Passenger Positions
Rear Seat Outside Passenger Positions Lap-Shoulder Belt The positions next to the windows have lap-shoulder belts. Here’s how to wear one properly. 1. Pick up the latch plate and pull the belt across you. Don’t let it get twisted. 2. Push the latch plate into the buckle until it clicks. 1-26...
Page 34 If the belt stops before it reaches the buckle, tilt the latch plate and keep pulling until you can buckle it. PulI up the latch plate sure it to make If the belt is not long enough, see “Safety Belt Extender”...
Page 35 The lap part of the belt should be worn low and snug on the hips, just touching the thighs. In a crash, this applies 1-28 force to the strong pelvic bones. And you’d be less likely to slide under the lap belt. If you slid under it, the belt would apply force could cause serious or even fatal injuries.
Page 36: Rear Safety Belt Comfort Guides For Children And Small Adults
Rear Safety Belt Comfort Guides for Children and Small Adults Rear shoulder belt comfort guides will provide added safety belt comfort for children who have outgrown child restraints and for small adults. When installed on a shoulder belt, the comfort guide pulls the belt away from the neck and head.
Page 37 2. Slide the guide under and past the belt. The elastic 1. Pull the elastic cord out from between the edge of cord must be under the belt. Then, place the guide the seatback and the interior body remove the over the belt, and insert the two edges of the belt into guide from its storage clip.
Page 38 3. Be sure that the belt is not twisted and it lies flat. 4. Buckle, position and release the safety belt as elastic cord must under the guide belt and the d e s € ~ k d in “Rear Seat Outside Passenger Positions” top.
Page 39: Center Passenger Position
To remove and store the comfort guides, just perform thsese steps in reverse order. Squeeze the belt edges together so that you can take them out from the guides. Pull the guide upward to expose its storage clip, and then slide the guide onto the clip. Rotate the guide clip inward and in between the seatback and the interior body, leaving only the loop of elastic cord exposed.
Page 40: Smaller Children And Babies
To make the belt shorter, pull its free belt is snug. Buckle, position and release it the same way as the lap part of a lap-shoulder belt. If the belt isn’t long enough, see “Safety Belt Extender’’ end of this section. at the Make sure the release button on the buckle is positioned you would...
Page 41 ’ 4 CAUTION: Never hold baby in your arms while riding in vehicle. A baby doesn’t weigh much crash. During a crash a baby will become so CAUTION: (Continued) 1-34 CAUTION: heavy you can’t hold it. For example, in a crash a t only 25 mph (40 km/h), a 12-1b.
Page 42: Child Restraints
Child Restraints Be sure the child restraint is designed to be used vehicle. If it is, it will have a label saying that it meets Federal Motor Vehicle Safety Standards. Then follow the instructions for the restraint. You may find these instructions the restraint itself or in a booklet, or both.
Page 43: Top Strap
Top Strap If your child restraint has a top strap, it should be anchored. If have a convertible, don't use a restraint like that in your vehicle because the top strap anchor shouldn't use this type cannot be installed properly. of restraint without anchoring the top strap.
Page 44: Securing A Child Restraint In A Rear Outside Seat Position
Securing a Child Restraint in a Rear Outside Seat Position ‘ D You’ll be using the lap-shoulder belt. See the earlier part about the top strap if the child restraint has one. 1. Put the restraint on the seat. Follow the instructions for the child restraint.
Page 45 4. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 1-38 5. To tighten the belt, pull up on the shoulder belt while you push down on the child restraint.
Page 46: Securing A Child Restraint In The Center Rear Seat Position
Securing a Child Restraint in the Center Rear Seat Position You’ll be using the lap belt. See the earlier part about the top strap if the child restraint has one. Make the belt as long as possible by tilting the latch plate and pulling it along the belt.
Page 47 ‘ * R & 5. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 6. To tighten the belt, pull its free end while you push down on the child restraint.
Page 48 CAUTION: A child in a rear-facing child restraint can be seriously injured if the right front passenger’s air ’ bag inflates. This is because the back of a ’ rear-facing child restraint would be very close to the inflating air bag. Always secure a rear-facing child restraint in the rear seat.
Page 49 Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 1-42 6. To tighten the belt, pull up on the shoulder belt while you push down on the child restraint. 7.
Page 50: Larger Children
Larger Children Children who have outgrown child restraints should wear the vehicle’s safety belts. If you have the choice, a child should sit window so the child can wear a lap-shoulder belt and get the additional restraint shoulder belt can provide. Accident statistics show that children are safer if they are restrained in the rear seat.
Page 51 CAUTION: Never this. Here two children are wearing the same belt. The belt can’t properly spread the impact forces. In crash, the two children can be crushed together and seriously injured. belt must be used by only one person at time.
Page 52 CAUTION: Never do this. Here a child is sitting in a seat that has lap-shoulder belt, but the shoulder part is behind the child. If the child wears the belt in this way, in a crash the child might slide under the belt. The belt’s force would then be applied right on the child’s abdomen.
Page 53: Safety Belt Extender
Safety Belt Extender If the vehicle’s safety belt will fasten around you, you should use it. But if a safety belt isn’t long enough to fasten, your dealer will order you an extender. It’s free. When you go in to order it, take the heaviest coat you will wear, extender will be long enough for you.
Page 54: Features And Controls
Section 2 Features and Controls Here you can learn about the many standard and optional features on your Pontiac, and information on starting, shifting and braking. Also explained are the instrument panel and the warning systems that tell you if...
Page 55 Keep the tag in a safe place. If you lose your key, you’ll be able to have a new one made easily using the tag. If you need a new key, contact your Pontiac dealer who can obtain the correct key code. Remember to carry the pre-cut emergency key which Pontiac sends after delivery.
Page 56 CAUTION: Unlocked doors can be dangerous. Passengers especially children open the doors and fall out. When a door is won’t open locked, the inside handle Outsiders can easily enter through door when you slow down stop your vehicle. This may not be so obvious: You increase the chance of being thrown out of the vehicle in a crash if the doors aren’t locked.
Page 57 To lock the door from the inside, push the locking lever forward. To unlock the door, pull the locking lever backward. Power Door Locks (Option) You can lock or unlock all doors of your vehicle from the driver or front passenger iszk switch.
Page 58: Leaving Your Vehicle
Rear Door Security Lock (4-DOor Models) Your Pontiac is equipped with rear door security locks that help prevent passengers from opening the rear dooh of your car from the inside. To use one of these locks: a key to move the lock all the way 2.
Page 59: Operation
Remote Keyless Entry (Option) If your Pontiac has this option, you can lock and unlock your doors or unlock your trunk from up to 30 feet (9 m) away using the key chain transmitter supplied with your vehicle. Your Remote Keyless Entry...
Page 60: Matching Transmitter(S) To Your Vehicle
Matching Transmitter(s) To Your Vehicle Each key chain transmitter is coded to prevent another transmitter from unlocking your vehicle. If a transmitter is lost or stolen, a replacement can be purchased through your dealer. Remember to bring any remaining transmitters with you when you go to your dealer. When the dealer matches the replacement transmitter to your vehicle, any remaining transmitters must also be matched.
Page 61 Theft Vehicle theft is big business, especially in some cities. setting Although your Pontiac has a number of theft-deterrent MAX. That features, we know that nothing we put on it can make it impossible to steal. However, there are ways you can help.
Page 62: Parking At Night
If the THEFT SYSTEM light comes on while the engine is running, a problem has been detected and the system may need service. See your dealer for service. In an emergency, call the Pontiac Roadside Assistance Program at 1 -800-ROADSIDE or 1-800-762-3743. the unlikely event that service.
Page 63: Ignition Switch
New Vehicle “Break-In” NOTICE: Your modern Pontiac doesn’t need an elaborate “break-in.” But it will perform better in the long run if you follow these guidelines: Don’t drive at any one speed slow for the first 500 miles Don’t make full-throttle starts.
Page 64 OFF (C): Unlocks the steering wheel, ignition and transaxle, but does not send electrical power to any accessories. In the OFF position, the instrument cluster and the automatic transaxle gear shift indicator have electrical p w w . $hiis p a r s i - r i m be pushed or towed, but never try to push-start your vehicle.
Page 65: Starting Your Engine
Your engine won’t start in any other position -- that’s a safety feature. To restart when you’re already moving, use NEUTRAL (N) only. NOTICE: Don’t try to shift to PARK (P) if your Pontiac is moving. If you do, you could damage the transaxle. Shift vehicle is stopped.
Page 66 NOTICE: Holding your key in START for longer than 15 seconds a t a time will cause your battery to be drained much sooner. And the excessive heat can damage your starter motor. 2. If your engine still won’t start (or starts but then stops), it could be flooded with too much gasoline.
Page 67 Starting Your 2.4 Liter Engine 1. Without pushing the accelerator pedal, turn your ignition key to STAI2T. When the engine starts, let go of the key. The idle speed will go down as your engine gets warm. NOTICE: START Holding your key in for longer than seconds at a time will cause your battery to be drained much sooner.
Page 68: Engine Coolant Heater (Option)
Engine Coolant Heater (Option) (Code T) Engine 2 . 4 L In very 0 "F cold weather, C) or colder, the engine 2 . 2 L (Code Engine coolant heater can help. You'll get easier starting and better fuel economy during engine warm-up. Usually, the coolant heater should be plugged in a minimum of four hours prior to starting your vehicle.
Page 69: Automatic Transaxle Operation
Instead of trying to list everything here, we ask that you contact 2-16 your Pontiac dealer in the area where you’ll be parking your vehicle. The dealer can give you the best advice for that particular area.
Page 70 N D 3 Four-Speed Automatic Transaxle PARK (P): This locks your front wheels. It’s the best position to use when you start your engine because your vehicle can’t move easily. CAUTION: It is dangerous to get out of your vehicle if the ski€% k v w parking brake firmly set.
Page 71 Ensure the shift lever is fully in PARK (P) range before starting the engine. Your Pontiac has a brake-transaxle shift interlock. You have to fully apply your regular before PARK (P) brakes you can shift from ignition key is in the RUN position. If you cannot shift...
Page 72 Forward Gears (3-Speed) DRIVE (D): is for This position normal driving. SECOND (2): This position gives you lower fuel economy. You can use SECOND ( 2 ) on hills. It can help control your speed as you go down steep mountain roads, but then you would also want to use your brakes off and on.
Page 73 THIRD (3): This position is also used for normal driving, however, it offers more power economy than AUTOMATIC OVERDRIVE (D). Here are some times you might choose THIRD (3) instead of AUTOMATIC OVERDRIVE (D): When driving on hilly, winding roads. When going down a steep hill.
Page 74: Manual Transaxle
Manual Transaxle ’ This is your shift pattern. Here’s how to operate your transaxle: FIRST (1): Press the clutch pedal and shift into FIRST (1). Then, slowly let up on the clutch pedal as you press the accelerator pedal. You can shift into FIRST (1) when you’re going less than 20 mph (32 you’ve come to km/h).
Page 75: Shift Speeds
THIRD (3), FOURTH (4) and FIFTH (5): Shift into THIRD (3), FOURTH (4) FIFTH way you do for SECOND (2). Slowly let up on the clutch pedal as you press the accelerator pedal. To stop, let up on the accelerator pedal and press the brake pedal.
Page 76: Parking Brake
Shift Light (Manual Transaxle) If you have a manual transaxle, you have a SHIFT light. This light will show you when to shift to the next higher gear for best fuel economy. SHIFT When this light comes on, you can shift to the next higher gear if weather, road and traffic conditions let you.
Page 77 To set the parking brake, hold the brake pedal down and pull up on the parking brake lever. If the ignition is on, the brake system warning light will come on. To release the parking brake, hold the brake pedal down. Pull the parking brake lever up until you can press the release button.
Page 78 2. Move the shift lever into the PARK (PI position like this: Hold in the button on the lever, and push the lever all the way toward the front of your vehicle. Move the ignition key to LOCK. 4. Remove the key and take it with you. If you leave your vehicle with the ignition key in your hand, your vehicle is in PARK (P).
Page 79: Shifting Out Of Park (P) (Automatic Transaxle)
PARK (PI. Shifting Out of PARK (P) (Automatic Transaxle) Your Pontiac has a brake-transaxle shift interlock. You haye fully Q&@Y ZEgUl X C’ bE3kS bf?fQE‘ YQUr...
Page 80: Parking Over Things That Burn
Parking Over Things That Burn CAUTION: Things that can burn could touch parts under your vehicle and ignite. Don’t park over papers, leaves, dry grass or other things that can burn. Engine Exhaust CAUTION: Engine exhaust can kill. It contains the gas carbon monoxide (CO), which you can’t see smell.
Page 81 Running Your Engine While You’re Parked (Automatic Transaxle) It’s better not to park with the engine running. But if you ever have to, here are some things to CAUTION: Idling the engine with the air system control could allow dangerous exhaust into your (see the earlier Caution under “Engine Exhaust”).
Page 82 Windows On a vehicle with manual windows, use the window crank open and close each window. Power Windows (Option) With power windows, switches on the center console control each of the windows only when the ignition is on. In addition, in four-door models, each rear passenger door has a control switch for its own window.
Page 83 A tilt steering wheel allows you to adjust the steering wheel before you drive. You can also raise it to the highest level to give your legs more room when you exit md enter the vehicle. T o tilt the wheel, hold the steering wheel lever.
Page 84: Turn And Lane-Change Signals
Turn and Lane Change Signals turn signal has two upward (for right) and two downward (for left) positions. These positions allow to signal a turn or a lane change. To signal a move the lever the way up or down. turn, When the turn is fashed, the lever will return automatically.
Page 85: Flash-To-Pass
Flash-to-Pass This feature lets you use your high-beam headlamps to signal a driver in front of you that you want to pass. To use it, pull the turn signal/multifunction lever toward you until the high-beam headlamps come on, then release the lever to turn them off. Windshield Wipers 2-32 You control the windshield wipers by moving the stalk...
Page 86: Windshield Washer
Controlled Cycle Wipers (Option) If your vehicle has variable controlled-cycle windshield wipers, you can set the wiper speed for a long or short delay between wipes. This can be very useful in light rain or snow. Move the stalk to DELAY, then rotate the band to choose the delay you want.
Page 87: Cruise Control (Option)
Driving without washer fluid is dangerous. A bad mud splash can block your vision. You could collide with another vehicle. Check your washer fluid often. CAUTION: In freezing weather, don't use your washer until the windshield is warmed. Otherwise the washer fluid can form ice on the windshield, blocking your vision.
Page 88 When you apply your brakes, or the clutch pedal, the cruise control shuts off. CAUTION: Cruise control can be dangerous where you can’t drive safely at a steady speed. So, don’t use cruise control an winding roads or in heavy traffic. Crllise control can be bngerolls on slippery roads.
Page 89 Pmb in SET button at the end 'of the lever and release it. 4. Take your foot off the accelerator pedal. Resuming a Set Speed Suppose you set your cruise control at a desired speed and then you apply the brake or clutch pedal. This, of course, shuts off the cruise control.
Page 90 You'll go right back to your chosen speed and stay there. If you hold the switch at R/A longer than half the vehicle will keep going faster until you release the switch or apply the brake or clutch pedal. You could be startled and even lose con&d.
Page 91 Using Cruise Control on Hills How well your cruise control will work on hills depends upon your speed, load and the steepness of the hills. When going up a steep hill, you may have to step on the accelerator pedal to maintain your speed. When going downhill, you may have to brake or shift to a lower gear to keep your speed down.
Page 92: Lamps On Reminder
Headlamps This position will turn on the following: Headlamps Parking Lamps Sidemarker Lamps Taillamps Instrument Panel Lights Turn the band clockwise all the way to t u n the lamps off. Lamps On Reminder If you open the driver's door with the ignition off and the lamps on, you will hear a warning chime.
Page 93: Interior Lamps
When the DRL are only your high-beam headlamps will be on at a reduced brightness. The taillamps, sidemarker and other lamps won’t be on. Your instrument panel won’t be lit up either. When you turn on the headlamp switch, your high-beam headlamps will go out, and your headlamps will come on.
Page 94: Illuminated Entry
Illuminated Entry When you open either front door, or open a rear door, the lamps inside your vehicle will go on. These lamps will fade off after about 40 seconds, or when the ignition is turned after all of the doors have been closed. If the ignition has been off for less than two minutes, the lamps inside your vehicle will stay on for about 15 seconds to provide an illuminated exit when you...
Page 95: Battery Saver
Battery Saver Your Pontiac is equipped with a battery saver feature designed to protect your vehicle's battery. When any interior lamp (trunk, reading, dome, glove box, etc.) is left on and the ignition is turned OW, the battery saver system will automatically turn the lamp off after 20 minutes.
Page 96 Manual Remote Control Mirror LmSide- should be adjusted so you can just see the side of your vehicle when you are sitting in a comfortable driving position. Adjust the driver’s side outside mirror with the control lever on the driver’s door. To adjust your passenger’s mirror, sit in the driver’s side...
Page 97: Convex Outside Mirror
Convex Outside Mirror Your passenger’s side mirror is convex. A convex mirror’s surface is curved so you can see more from the driver’s seat. CAUTION: A convex mirror can make things (like other vehicles) look farther away than they really are. If you cut too sharply into the right lane, you could hit a vehicle on your right.
Page 98: Convenience Net (Option)
Center Console Cupholders There is a cupholder built into the front console for your convenience. To access it, remove the ashtray. There are also cupholders for the rear seat passengers in the back of the console. Grab the cupholder cover from both sides and pull it down.
Page 99: Ashtrays And Cigarette Lighter
Ashtrays and Cigarette Lighter To use the lighter, push it in ’ all the way and let When it’s ready, it will pop back out by itself. NOTICE: Don’t hold a cigarette lighter in with your hand while it is heating. If d~~ It ~ Q U W Q I Z ’...
Page 100: Sun Visors
Press and hold the front of the switch panel. The sunshade can only be closed by hand. The sunroof glass panel cannot be opened or closed if your Pontiac has an electrical failure. Convertible Top (Option) The following steps explain the proper operation convertible top.
Page 101 Lowering Your Convertible Top Set the parking brake and shift your automatic transaxle to PARK (P) or your manual transaxle to NEUTRAL (N). Turn the ignition to the RUN position. Lower the side door windows. Push the button in the latch handle and turn the handle down to unhook the latch pins from the holes over the windshield.
Page 102 6. From inside $he vehkle, pull the rab the rear seat 4 x 2 to fold down the seat. See "Fold-Down Rear Seat" in the Index. 7. Open the trunk and remove both boot side covers. Leave the trunk open. 2-49...
Page 103 8. Install the boot side cover by inserting the tab (A) on the underside of the cover into the slot (B) at the top of the quarter trim panel. Place the rear flap of the boot side cover in the trunk lid opening, aligning the eyelet (C) over the boot snap ball 2-50 Attach the two snaps on the inside flap to the top of...
Page 104 10. Pull the boot center cover from behind the rear seatback and place it over the inner sides of the boot side covers and the lowered top. 11. Go to the rear of the vehicle. Place the boot center cover flap along the trunk lid opening. Align one snap to snap ball stud and push forward.
Page 105 3 . From inside the vehicle, fold down the rear seatback. See “Fold-Down Rear Seat” in the Index. 2-52...
Page 106 5. Unsnap both boot side cover snaps (E an( the top of the quarter trim panel. F) from Lift side cover eyelet (C) at rear of side boot cover from snap ball stud (D). Raise the back of the boot side cover to unhook the tab (A) from the slot (B) in the quarter trim panel.
Page 107 T u r n the ignition to the RUN position. Lower both door windows to avoid wear weather strips. Push the button in the latch handle and turn the handle down. Push the handle forward toward the windshield and hold it until the convertible top is fully raised, and the latch pins are all the way in the holes above the windshield.
Page 108 Lowering the Top Manually NOTICE: Do not attempt to lower the top manually as damage to the vehicle will occur. If the top fails to raise or lower completely, see “Raising the Top Manually” following. Raising Manually the Top If your vehicle loses power, or something else happens that prevents you from raising the top electrically, you may need to raise top manually.
Page 109 ~~~~ 4. Press the bypass switch down to the EMERGENCY OVERRIDE position, The switch is located under the shelf panel on the driver’s side in the trunk. 2-56 Remove the top as described in Steps boot in “Raising Your Convertible Top” earlier in ths section.
Page 110 Raise the until is all the way top so the pins are even with the holes. Line Pull down lock the convertible top. 10. Press the bypass switch up to the NORMAL OPERATION position. 11. Close the trunk. 12. Raise the rear seatback to the up position. Push the seat back to make sure it is latched.
Page 111 The Instrument Panel Your Information System 2-5 8...
Page 112: Audio System
Your instrument panel is designed to let you’re going, how much fuel you’re using, and many other things you’ll need to drive safely and economically. main components your instrument panel are: 1. Instrument Panel Intensity Control 2. Turn Signal/Multifunction Lever 3.
Page 113: Instrument Panel Cluster
Instrument Panel Cluster v v v v v v v I n n n n...
Page 114: Speedometer And Odometer
(used in the United States) or kilometers (used in Canada). Tamper Resistant Odometer Your Pontiac has a tamper resistant odometer. If you numbers>: siLves k s . between tAe- .see...
Page 115: Warning Lights, Gages And Indicators
Tachometer The tachometer displays the engine speed in revolutions per minute (rpm). NOTICE: Do not operate the engine with the tachometer in the red area, or engine damage may occur. 2-62 Warning Lights, Gages and Indicators This part describes the waming lights be on your vehicle.
Page 116: Safety Belt Reminder Light
Safety Belt Reminder Light When the key is turned to START, a come on for about eight seconds to remind people to fasten their safety belts, unless the driver’s safety belt is already buckled. The safety belt light will also come on and stay on for about 20 seconds, then it will flash for about 55 seconds.
Page 117: Battery Light
2-64 Brake System Warning Light Your Pontiac’s hydraulic brake system is divided into two parts. If one part isn’t working, the other part can still work and stop you. For good braking, though, you need both parts working well.
Page 118: Anti-Lock Brake System Warning Light
Then start the engine again to reset: the system. If E h Eight again while you’re driving, your Pontiac needs If the regular brake system warning light still have brakes, but you don’t have anti-lock brakes.
Page 119 Enhanced Traction System Warning Light (Option) With the Enhanced Traction system (ETS), this warning light should as you start the engine. If the warning light doesn’t come on then, have it fixed so it will be ready to warn you if there’s a problem. stays on, or comes on when you’re driving, there may be a problem with your Enhanced Traction System and your vehicle may need service.
Page 120: Enhanced Traction System Active Light
Enhanced Traction System Active Light When your Enhanced Traction System is limiting wheel spin, this light will come on. Slippery road conditions may exist if the Enhanced Traction System TRAC active light comes on, so adjust your driving accordingly. The light will stay on for a few seconds after the Enhanced Traction System stops limiting wheel spin.
Page 121: Low Coolant Warning Light
Your Pontiac is equipped with a computer which monitors operation of the fuel, ignition and emission control systems.
Page 122 NOTICE: If you keep driving your vehicle with this light your on, after while, emission controls work as well, your fuel economy may not be as good and your engine may not run as smoothly. This could lead to costly repairs that may not be covered by your warranty.
Page 123 If the Light Is On Steady Did you just put fuel into your vehicle? If so, reinstall the fuel cap, making sure to fully install the cap. The diagnostic system can determine if the fuel cap has been left off or improperly installed. This will allow fuel to evaporate into the atmosphere.
Page 124: Oil Warning Light
Oil Warning Light ’ If you have a low engine oil pressure problem, this light will stay on after you start your engine, or come on when you are driving. This indicates that your engine is not receiving enough oil. The engine could be low on oil, or could have some other problem.
Page 125: Passlock Warning Light
Check Oil Light This light should come on briefly while you are -s&rzing ymr eaghe. If light doesn’t come on, have CHECK it repaired. If the light comes on stays on, your engine oil level should be checked. Prior to checking your oil level, be sure your vehicle been several shut off for...
Page 126 Up-Shift Light (Manual Transaxle) This light comes on when you need to shift to the next higher gear. See “Manual Transaxle” in the Index. SHIFT Check Gages Light This light will come on briefly when you are starting the engine. If the light comes on and stays CHECK on while you are driving,...
Page 127 Fuel Gage When the ignition is on, your fuel gage tells you about how much fuel you have left. When the indicator nears EMPTY (E), you little fuel left, but should get more soon. 2-74 Here four things that some owners ask about. None of these show a problem with your fuel gage: At the gas station, the gas pump shuts off before the WLL (F).
Page 128: Comfort Controls
In this section you'll find out how to operate the comfort control and audio systems offered with your Pontiac. Be sure to read about the particular systems supplied with your vehicle. Comfort Controls This section tells you how to make your a ~ r system work for you.
Page 129 Fan Knob The left knob selects the force of air you want. Turn the knob clockwise to increase fan speed and counter clockwise to decrease fan speed. To turn the fan off, turn the mode knob all the way counterclockwise. In any other setting, the fan will Tun continuously.
Page 130 Climate C m t r d System with Air Conditioning (Option) Fan Knob The left knob selects the force of air you want. Turn the knob clockwise to increase speed and counter clockwise to decrease fan speed. To turn the the mode knob all the way counterclockwise.
Page 131: Air Conditioning (Option)
FLOOR: This setting sends most of the air through the ducts near the floor. The rest comes out of the defroster and side window vents. DEFOG: This setting allows half of the air to go the floor ducts half to the defroster and side window vents.
Page 132: Ventilation System
Heating On cold days, use FLOOR with the temperature knob all the way in the red area. The system will bring in outside air, heat it and send it to the floor ducts. Your vehicle has heat ducts that are directed toward the rear seat.
Page 133: Defogging And Defrosting Windows
Defogging and Defrosting Windows Your system has two settings €or clearing the front and side windows. defrost the windows quickly, use DEFROST with the temperature knob all the way in the red area. To warm passengers while keeping the windows clean, use DEFOG. To defog the side windows, set the right control to BI-LEVEL and the fan control to the highest setting.
Page 134: Audio Systems
Audio Systems Your Delco@ audio system has been designed to operate easily give years of listening pleasure. You will get the most enjoyment out of it if you acquaint yourself with it first. Find out what your Delco system can do and how to operate all its controls, to be sure you’re e&...
Page 135 SEEK: Press the up or down arrow to go to the next higher or lower station. PUSHBUTTONS: The four numbered pushbuttons let you return to your favorite stations. You can set up to 14 stations (seven AM and seven FM). 1.
Page 136: Am-Fm Stereo With Cassette Tape Player (Option)
AM-FM Stereo with Cassette Tape Player (Option) Playing the Radio VOL: Push this knob to turn the system on or off. Turn clockwise to increase volume and counterclockwise decrease volume. RECALL: Press this button briefly to recall the station being played or the clock display. If you press the knob when the ignition is off, the clock will show for few seconds.
Page 137 FADE: Press this knob lightly so it extends. Turn this knob to move the sound to the front or rear speakers. Use the middle position to balance these speakers. Push the knob back in when you’re not using it. Playing Cassette Tape Your tape player is built to work best with tapes that are 30 to 45 minutes long on each side.
Page 138 PROG (3): Press this button to play the other side of the tape. (4): Press this button to reduce background noise. Note that the double-D symbol will appear on the display. Dolby@ Noise Reduction is manufactured under a license from Dolby Laboratories Licensing Corporation. Dolby and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation.
Page 139 AM-FM Stereo with Cassette Tape Player and Equalizer (Option) Playing the Radio VOL: Push this knob to turn the system on or off. Turn it clockwise to increase volume and counterclockwise to decrease volume. RECALL: Press this button briefly being played or the clock display. If you press the knob when the ignition is off, the clock will show for few seconds.
Page 140 FADE: Press t h s knob lightly so it extends. Turn it to move the sound to the front or rear speakers. Use the middle position to balance these speakers. Push the knob back in when you’re not using it. Playing Cassette Tape Your tape player is built to work best with tapes that are...
Page 141 nu(4): Press this button to reduce background noise. Note that the double-D symbol will appear on the display. Dolby Noise Reduction is manufactured under a license from Dolby Laboratories Licensing Corporation. Dolby and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation.
Page 142 AM-FM Stereo with Compact Disc Player and Equalizer (Option) Playing the Radio VOL: Push this knob to turn the system on or off. Turn increase volume it clockwise to decrease volume. RECALL: Press this button briefly to recall the station being played or the clock display.
Page 143 Setting the Tone EQUALIZER: A seven band equalizer is part of your audio system. Slide the levers up to boost or down to reduce frequency range. Adjusting the Speakers BAL: Press this knob lightly so it extends. Turn it to move the sound to the left or right speakers.
Page 144 NEXT (2): Press this button or the SEEK up to the start the next track more than eight seconds have played. you hold the button or press it more once, the player will continue moving forward through the disc. RDM (3): Press this button to hear the tracks in a random order.
Page 145 2. Turn the ignition to the ACC or RUN position. 3. Turn the radio off. 4. Press the 1 and 4 buttons together. Hold them down until shows on the display. Next you will use the secret code number which you have written down. 5.
Page 146 Disabling the Theft-Deterrent Feature Enter your secret code as follows; pause no more than 15 seconds between steps: Turn the ignition to the ACCESSORY or RUN position. Turn the radio off. Press the 1 and 4 buttons together. Hold them down until SEC shows on the display.
Page 147: Understanding Radio Reception
AM-FM: Press this button to choose AM, FM1 or FM 2. If a cassette tape or compact disc is playing, it will stop and the radio will play. PRESET Press this button to play a station you have programmed on the radio preset buttons. PLAY: Press this button to play a cassette tape or compact disc when the radio is playing.
Page 148: Care Of Your Cassette Tape Player
Insert eject cassette least three times to ensure thorough c l e ~ n g , . A scmbbing action cleaning cassette is available through your Pontiac dealer. 3-21...
Page 149: Care Of Your Compact Discs
You may also choose a non-scrubbing cleaner which uses a cassette with a fabric belt to clean the tape head. This type of cleaning cassette will not eject. It may not clean as thoroughly as the scrubbing type cleaner. Cassettes are subject to wear and the sound quality may degrade over time.
Page 150: Defensive Driving
The best advice anyone can give about driving is: Drive defensively. Please start with a very important safety device in your Pontiac: Buckle up. (See “Safety Belts” in the Index.) Defensive driving really means “be ready for anything.” On city streets, rural roads or freeways, it means “always expect the unexpected.”...
Page 151: Drunken Driving
Drunken Driving ,jli Death and injury associated with drinking and driving is a national tragedy. It’s the number one contributor to the‘highway death toll, claiming thousands of victims every s p e a r . Alcohol affects four things that anyone needs to drive a vehicle: Judgment Muscular Coordination...
Page 152 It’s the amount of alcohol that counts. For example, if the same person drank three double martinis (3 ounces or 90 ml of liquor each) within an hour, the person’s BAC would be close to 0.12 percent. A person who consumes food just before or during drinking will have a somewhat lower BAC level.
Page 153: Control Of A Vehicle
The body takes about an hour to rid itself of the alcohol amount of coffee or number of cold one drink. showers will speed that up. “I’ll be careful” isn’t the right answer. What if there’s an emergency, a need to take sudden action, as when a child darts into the street? A person with even a moderate BAC might not be able to react quickly enough to avoid the collision.
Page 154 Sometimes, as when you’re driving on snow or ice, it’s easy to ask more of those control systems than the tires and road can provide. That means you can lose control of your vehicle. actual stopping distances And, of course, with the surface of the road (whether it’s pavement or gravel);...
Page 155: Anti-Lock Brakes
Avoid needless heavy braking. Some people drive in spurts heavy acceleration foUowed by heavy braking rather than keeping pace with traffic. This is a mistake. Your brakes may not have time to cool between hard stups. Yuur brakes will wear out much faster if you do a lot of heavy braking.
Page 156 Here’s how anti-lock works. Let’s say the road You’re driving safely. Suddenly an animal jumps out in front of you. You slam on the brakes. Here’s what happens with ABS. computer senses that wheels are slowing down. If one of the wheels is about to stop rolling, the computer will separately work the brakes at each front wheel and at the rear wheels.
Page 157: Enhanced Traction System
Remember: Anti-lock doesn’t change the time you need to get your foot up to the brake pedal or always decrease stopping distance. If you get too close to the vehicle in front of you, you won’t have time to apply your brakes if that vehicle suddenly slows or stops.
Page 158 When the system is on and the parking brake is fully released, this warning light will come on to let you know if there’s a problem with the system. See “Enhanced Traction System Warning Light” in the Index. When this warning light is on, the system will not limit wheel spin.
Page 159: Braking In Emergencies
Braking in Emergencies Use your anti-lock braking system when you need to. With anti-lock, you can steer and brake at the same time. In many emergencies, steering can help you more ttan the very best braking. even Steering Power Steering If you lose power steering assist because the engine stops or the system is not functioning, you can steer but it will take much more effort.
Page 160: Steering In Emergencies
But sometimes you can’t; there isn’t room. That’s the time for evasive action -- steering around the problem. Your Pontiac can perform very well in emergencies like these. First apply your brakes. (See “Braking in Emergencies” earlier in this section.) It is better to remove as much speed as you can from a possible collision.
Page 161: Off-Road Recovery
Off-Road Recovery You may find sometime that your right wheels have dropped off the edge of a road onto the shoulder while you ’re driving. If the level of the shoulder is only slightly below the pavement, recovery should be fairly easy. Ease off the accelerator and then, if there is nothing in the way, steer so that your vehicle straddles the edge of the pavement.
Page 162 Do not get too close tu the vehicle you want to pass while you’re awaiting opportunity. For one thing, following too closely reduces your area of vision, especially if you’re following a larger vehicle. Also, you won’t have adequate space if the vehicle ahead suddenly slows or stops.
Page 163: Loss Of Control
But skids always possible. The three types of skids correspond to your Pontiac’s three control systems. In the braking skid, your wheels aren’t rolling. In the steering or cornering skid, too much speed or steering in curve causes tires to slip and lose cornering force.
Page 164: Driving At Night
Driving at Night Night driving is more dangerous than day driving. One reason is that some drivers are likely to be impaired alcohol or drugs, with night vision problems, or by fatigue. Here are some tips on night driving. Drive defensively. Don’t drink and drive.
Page 165: Driving In Rain And On Wet Roads
You can be temporarily blinded by approaching headlamps. It can take second or two, or even several seconds, for your eyes to readjust to the dark. When you faced with severe glare (as from a driver who doesn't lower the high beams, or a vehicle with misaimed headlamps), slow down a little.
Page 166 even less traction. It’s always wise to go slower and be cautious if rain starts fall while you are driving. The surface may get wet suddenly when your reflexes are tuned for driving on dry pavement. The heavier the rain, the harder it is to see. Even if your windshield wiper blades are in good shape, a heavy rain can make it harder see road signs and traffic signals,...
Page 167: Driving Through Deep Standing Water
CAUTION: Wet brakes cause accidents. They won’t work well in a quick stop and may cause pulling to one side. could lose control the vehicle. After driving through large puddle of water or car wash, apply your brake pedal lightly until your brakes work normally.
Page 168: City Driving
City Driving One of the biggest problems with city streets is the amount of traffic on them. You’ll want to watch out for what the other drivers are doing. and pay attention to traffic signals. Here are ways to increase your safety in city driving: Know the best way to get to where you are going.
Page 169: Freeway Driving
Freeway Driving ,./. * , , , . The most important advice on freeway driving is: Keep up with traffic and keep to the right. Drive at the same speed most of the othe; drivers &e driving. Too-fast or too-slow driving breaks a smooth traffic flow. Treat the left lane on a freeway as a passing lane.
Page 170: Before Leaving On A Long Trip
Pontiac dealerships all across North America. They'll be ready and willing to help if you need it. Here are some things you can check before a trip:...
Page 171: Highway Hypnosis
Highway Hypnosis Is there actually such a condition as “highway hypnosis”? Or is it just plain falling asleep at the wheel? Call it highway hypnosis, lack of awareness, or whatever. There is something about easy stretch of road with the same scenery, along with the hum of the tires on the road, the drone of the engine, and the rush of the wind against the vehicle that can make you sleepy.
Page 172 you drive regularly in steep country, or if you’re planning to visit there, here are some tips that can make your trips safer and more enjoyable. Keep your vehicle in good shape. Check all fluid levels and also the brakes, tires, cooling system and transaxle.
Page 173: Winter Driving
Winter Driving Here are some tips for winter driving: Have your Pontiac in good shape for winter. You may want to put winter emergency supplies in your trunk. Include an ice scraper, a small brush or broom, a supply of windshield washer fluid, a rag, some winter outer clothing, a small shovel, a flashlight, a red cloth and couple of reflective warning triangles.
Page 174: Driving On Snow Or Ice
Driving on Snow or Ice Most of the time, those places where your tires meet the road probably have good traction. However, if there is snow or ice between your tires and the road, you can have a very slippery situation. You’ll or “grip”...
Page 175: If You're Caught In A Blizzard
Your anti-lock brakes improve your vehicle’s stability when you make a hard stop on a slippery road. Even though have the anti-lock braking system, you’ll want to begin stopping sooner than pavement. See “Anti-Lock” the Index. Allow greater following distance on any slippery road. Watch for slippery spots.
Page 176 Tie a red cloth to your vehicle to alert police that you’ve been stopped by the snow. Put on extra clothing or wrap a blanket around you. If you have no blankets or extra clothing, make body insulators from newspapers, burlap bags, rags, floor mats anything you can wrap around yourself or tuck under your clothing to keep warm.
Page 177: Recreational Vehicle Towing
Then, shut the engine off and close the window almost all the way to preserve the heat. Start the engine again repeat this only when feel really uncomfortable from the cold. But do it as little as possible. Preserve the fuel as long as can.
Page 178 the Front Towing Your Vehicle from Five-Speed (Four-Speed Automatic or Manual Transaxles Only) You may tow your vehicle with four wheels on the g o m d if you have a four-speed automatic or a five-speed manual transaxle. Follow these steps: 1.
Page 179: Loading Your Vehicle
Towing Your Vehicle from the Rear NOTICE: Do not tow your vehicle from the rear. Your vehicle could be badly damaged and the repairs would not be covered by your warranty. 4-30 Loading Your Vehicle OCcEF~~C$DING INFORMATION VEHICLE CAP. WT. FRT.
Page 180 MFD BY GENERAL MOTORS CORP DATE GVWR GAWR FRT THIS VEHICLE CONFORMS TO ALL APPLI- CABLE U.S. FEDERAL MOTOR VEHICLE SAFETY, BUMPER, AND THEFT PREVENTION EFFECT ON THE DATE OF STANDARDS MANUFACTURE SHOWN ABOVE. The other label is the Certification label, found on the rear ed-ge o f the driver’s dear.
Page 181 Pull a trailer only if steps in this section. Ask your Pontiac dealer for advice and information about towing a trailer with your vehicle. the correct equipment and drive or even a t all. You...
Page 182 Pulling a trailer improperly can damage your vehicle and result in costly repairs not covered by your warranty. To pull a trailer correctly, follow the advice in this part, and see your Pontiac dealer for important information about towing a trailer with your vehicle.
Page 183: Weight Of The Trailer
You can that you advice, or you can write us km/h) Pontiac Customer Services Department One Pontiac Plaza Pontiac, Michigan 48340-2952 In Canada, write to: General Motors of Canada Limited Customer Assistance Center...
Page 184: Weight Of The Trailer Tongue
Weight of the Trailer Tongue The tongue load (A) of any trailer is weight to measure because it affects the total capacity weight of your vehicle. The capacity weight includes the curb weight of the vehicle, any cargo you may carry in it, and the people who will be riding in the vehicle.
Page 185: Safety Chains
Hitches It’s important to have the correct hitch equipment. Crosswinds, large trucks going by and rough roads are a few reasons why you’ll need the right hitch. Here are some rules to follow: Will you have to make any holes in the body of your vehicle when you install a trailer hitch? If you do, then be sure to seal the holes later when you remove the hitch.
Page 186: Driving With A Trailer
Driving with a Trailer Towing a trailer requires a certain amount of experience. Before setting out for the open road, you’ll want to get to know your rig. Acquaint yourself with the feel of handling and braking with the added weight of the trailer.
Page 187: Turn Signals When Towing A Trailer
Making lhrns NOTICE: Making very sharp turns while trailering could cause the trailer to come in contact with the vehicle. Your vehicle could be damaged. Avoid making very sharp turns while trailering. When you’re turning with a trailer, make wider turns than normal.
Page 188: Parking On Hills
Parking on Hills reaIIy should not park your vehicle, with a trailer attached, on a hill. If something goes wrong, your rig could start to move. People can be injured, and both your vehicle and the trailer can be damaged. But if you ever have to park your how to do it: 1.
Page 189: Maintenance When Trailer Towing
Maintenance When Trailer Towing Your vehicle will need service more often when you’re pulling a trailer. See the Maintenance Schedule for more on this. Things that are especially important in trailer operation are automatic transaxle fluid (don’t overfill), engine bek, Oil? C C l O k i g S g m m...
Page 190: Problemsontheroad
Section 5 Problems on the Road Here you'll find what to do about some problems that can occur on the road. Hazard Warnine Flashers Your hazard warning flashers let you also let police know you have a problem. Your front and rear turn signal lamps will flash on and off.
Page 191: Other Warning Devices
Jump Starting If your battery has run down, you may want to use another vehicle and some jumper cables to start your Pontiac. But please follow the steps blelow to do it safely. NOTICE: these steps could result Ignoring to your vehicle that wouldn’t be covered by...
Page 192 If they are, could cause a ground connection you don’t want. You wouldn’t be able to start your Pontiac, and the bad grounding could damage the electrical systems. You could be injured if the vehicles roll. Set the parking brake firmly on each vehicle.
Page 193 5. Find the positive negative each battery. CAUTION: Using match near battery can cause battery gas to explode. People have been hurt doing this, and some have been blinded. Use a flashlight if you need more light. Be sure the battery has enough water. You don’t need to add water to the Delco Freedom@ battery installed in every new vehicle.
Page 194 7. Remove the red plastic cap, and connect the red positive cable to the positive the vehicle with the dead battery. Use a remote positive terminal if the vehicle has one. terminal Don’t let the other end touch metal. Connect it to the positive terminal of the good battery.
Page 195 Don’t let the other end touch anything until the next step. The other end of the negative cable doesn’t go to the dead battery. It goes to a heavy unpainted metal part on the engine of the vehicle with the dead battery. 10.
Page 196 Towing Your VehicIe GM &&.r or a pr&sSional tawing sewice to bye. tow your vehicle. They can provide the right equipment and know how to tow your vehicle without damage. If your vehicle has been changed or modified since it was factory-new by adding aftermarket items like fog lamps, aero skirting, or special tires and wheels, these instructions and illustrations may not be correct.
Page 197 CAUTION: (Continued) Never get under your vehicle after it has been lifted by the tow truck. Always secure the vehicle on each side with separate safety chains when towing it. Never use J-hooks, Use T-hooks instead. When your vehicle is being towed, have the ignition key OFF.
Page 198: Front Towing
Front Towing Before hooking up to a tow truck, be sure to read all the information in “Towing Your Vehicle” earlier in this section. Attach T-hook chains into the slots in the bottom of the floor pan, just behind the front wheels, on both sides. These slots are used when loading and securing to car carrier equipment.
Page 199 NOTICE: Do not tow with sling-type equipment or fascia/fog lamp damage will occur. Use wheel-lift or car carrier equipment. Additional ramping may be required for carrier equipment. Use safety chains and wheel straps. Towing over rough surfaces could damage a vehicle.
Page 200: Rear Towing
Rear Towing Towing dolly required under front wheels when equipped with automatic transaxle or damage will occw: Before hooking up to a tow truck, be sure to read all the information in “Towing Your Vehicle” section. Also be sure use the proper hook-up for your particular vehicle.
Page 201 NOTICE: Do not from tow your Sunfire the rear with the front wheels on the ground or your transaxle can be damaged. Do not tow with sling-type equipment or rear facia will be damaged. Use wheel-lift equipment or car carrier equipment. Additional ramping may be required for car carrier equipment.
Page 202: Engine Overheating
Engine Overheating will find a coolant temperature gage and a low coolant warning light on your Pontiac’s instrument panel. If Steam Is Coming From Your Engine CAUTION: Steam from an overheated engine can burn you badly, even if you just open the hood. Stay away from the engine if you see or hear steam coming from it.
Page 203: If No Steam Is Coming From Your Engine
If No Steam Is Coming From If you get the overheat warning but see or hear no steam, the problem may not be too serious. Sometimes hol when you: fne engine can get a ~ Q O Climb a long hill on a hot day. Stop after high-speed driving.
Page 204 2 . 4 L Engine A. Coolant Surge Tank with Pressure Cap B. Electric Engine Fan I Q A U T I O N : An electric fan under the hood can start up even when the engine is not running and can injure you.
Page 205 The coolant level should be at FULL COLD line. If it isn’t, you may have a leak in the radiator hoses, heater hoses, radiator, water pump or somewhere else in the cooling system. 5-16 CAUTION: Heater and radiator hoses, and other engine parts, can be very hot.
Page 206: How To Add Coolant To The Coolant Surge Tank
How to Add Coolant to the Coolant Surge Tank If you haven't found a problem yet, but the coolant level FULL COLD mark, add a 50/50 mixture of isn't at the clean water (preferably distilled) and DEX-COOL antifreeze at the coolant surge tank, but be sure the cooling system, including the coolant surge tank pressure cap, is cool before you do it.
Page 207 CAUTION: Adding only plain water to your cooling system can be dangerous. Plain water, or some other liquid like alcohol, can boil before the proper coolant mix will. Your vehicle’s coolant warning system is set for the proper coolant mix. With plain water the wrong mix, your engine could get too hot but you wouldn’t get the overheat...
Page 208 1. You remove the coolant surge tank pressure cap when the cooling system, including the coolant surge tank pressure cap and upper radiator hose, is no longer hot. Turn the pressure cap slowly about one-quarter turn the left then stop. If you hear a wait for that hiss,...
Page 209 3. Then fill the coolant surge tank with the proper mix, 4. With the coolant surge tank pressure cap off, start up to the FULL COLD mark. the engine m until you can feel upper radiator hose getting hot. Watch out for the engine fan.
Page 210: If A Tire Goes Flat
this time, the coolant level inside the coolant surge tank may be lower. the level is lower, add more proper mix to the coolant surge tank until the level reaches the FULL COLD mark. Then replace the pressure cap. Be sure the pressure cap is tight.
Page 211: Changing A Flat Tire
A rear blowout, particularly on a curve, acts much like a skid and may require the same correction you’d use in a skid. In any rear blowout, remove your foot from the accelerator pedal. Get the vehicle under control by steering the way you want the vehicle to very bumpy and noisy, but you can still steer.
Page 212: Removing The Spare Tire And Tools
The following steps will tell you how to use the jack and change tire. Removing the Spare Tire and Tools equipment you’ll need in the trunk..retainer nut on the compact spare cover counterclockwise “?yq R “ ’ to remove it.
Page 213 Remove the jack and the wheel. wrench f r ~ m the W, Your vehicle's jack and wheel wrench are stored in a foam tray. Remove the band around the jack. Turn the wing nut counterclockwise and remove it. Then lift off the adapter and remove The tools you'll be using include the jack (A) and wheel the spare tire.
Page 214: Removing The Flat Tire And Installing The Spare Tire
Removing the Flat Tire and Installing the Spare Tire 1 , Using the wheel wrench, remove the plastic cap nuts (if your vehicle is so equipped) and loosen all the wheel nuts. Don’t remove the wheel nuts yet. On some models, a cover plate must be removed to find the wheel nuts.
Page 215 CAUTION: Getting under a vehicle when it is jacked up is dangerous. If the vehicle slips could be badly injured or killed. Never get under when vehicle supported only by a jack. NOTICE: your vehicle with the jack improperly Raising positioned will vehicle damage the...
Page 216 5. If you have a wheel cover, use your fingers to carefully the wheel cover from the wheel. remove the flat tire. Rust or dirt on the wheel, or on the parts to Then which it is fastened, can make the wheel nuts become loose after a time.
Page 217 CAUTION: Never use oil or grease on studs or nuts. If you do, the nuts might come loose. Your wheel could fall off, causing a serious accident. 7. Replace the wheel nuts with the rounded end of the nuts toward the wheel.
Page 218 Tighten the wheel nuts firmly in sequence, as CAUTION: Incorrect wheel nuts improperly tightened wheel nuts can cause the wheel to become and even come off. This could lead Be sure to use the correct wheel nuts. If Qa replace- to get ne- GM original them,...
Page 219: Storing The Flat Tire And Tools
Storing the Flat Tire and Tools CAUTION: Storing a jack, a tire or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store all these in the proper place. E.
Page 220: Storing The Spare Tire And Tools
Storing the Spare Tire and Tools CAUTION: Storing a jack, a tire or other equipment in the passenger compartment the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store all these in the proper place. The compact spare is for temporary use only.
Page 221: Compact Spare Tire
Compact Spare Tire Although the compact spare tire was fully inflated when your vehicle was new, it can lose air after a time. Check the inflation pressure regularly. It should be 60 psi (420 P a ) . After installing the compact spare on your vehicle, you should stop as soon as possible and make sure your spare tire is correctly inflated.
Page 222: If You're Stuck: In Sand, Mud, Ice Or Snow
If You’re Stuck: In Sand, Mud, Ice or Snow What don’t want to do when your vehicle is stuck is to spin your wheels too fast. The method known as “rocking” can help you get out when you’re stuck, but you must use caution.
Page 223 NOTES 5-34...
Page 224: Service And Appearance Care
Doing Your Own Service Work If you want to do some of your own service work, you’ll want to get the proper Pontiac Service Manual. It tells you much more about how to service your Pontiac than to its appearance care.
Page 225 - p n e l may fail a smog-check test. If this occurs, return to your authorized Pontiac dealer for diagnosis to determine the cause of failure. In the event cause of the condition is the type of fuels used, repairs may not covered by your warranty.
Page 226: Fuels In Foreign Countries
If this happens, return authorized Pontiac dealer for service. To provide cleaner air, all gasolines are now required to contain additives that will help prevent deposits from forming in your engine and fuel system, allowing your emission control system to function properly.
Page 227: Filling Your Tank
Filling Your Tank CAUTION: Gasoline vapor is highly flammable. It burns violently, and that can cause very bad injuries. Don9t smoke if you’re near gasoline or refueling your vehicle. Keep sparks, flames and smoking materials away from gasoline. The cap is behind a hinged door on the right side of your vehicle.
Page 228 Be careful not to spill gasoline. Clean gasoline from painted surfaces as soon as possible. See “Cleaning the Outside of Your Pontiac” in the Index. When you put the cap back on, turn it you hear at least three clicks. Make sure you fully install ihe cap.
Page 229: Checking Things Under The Hood
Checking Things Under the Hood CAUTION: An electric under the hood can start up and injure you even when the engine is not running. away from Keep hands, clothing and tools underhood electric fan. CAUTION: Things that burn can get on hot engine parts and start a fire.
Page 230 Then go to the front of the vehicle and lift up on the secondary hood release lever, The secondary hood release lever is located near the front center of the hood driver’s towards the side. Lubricate the hood latch at least once a year. Lift the hood, release the hood prop from its retainer and put the hood...
Page 231 2.2L Engine (Code 4) When you open up the hood you’ll see: A. Coolant Surge Tank B. Power Steering Fluid Reservoir C. Automatic Transaxle Fluid Dipstick (if equipped) D. Engine Oil Fill CapDipstick E. Brake Fluid Reservoir E Hydraulic Clutch Fluid Reservoir (if equipped) G.
Page 232 2.4L Engine (Code T) you open When up the hood you’ll see: A. Coolant Surge Tank B. Engine Oil Fill Cap C. Engine Oil Dipstick D. Power Steering Fluid Reservoir E. Brake Fluid Reservoir F. Hydraulic Clutch Fluid Reservoir (if equipped) G .
Page 233: Engine Oil
Engine Oil If the CHECK OIL light on the instrument panel comes on, it means you need to check your engine oil level CHECK right away. For more information, see “Check Oil Light” in the Index. You should check your engine oil level regularly;...
Page 234: Checking Engine Oil
Checking Engine Oil Pull out the dipstick and clean it with a paper towel or all the way. cloth, then push it back keeping the tip down, and check the level. When to Add Oil If the oil is at or below the ADD mark, then you’ll need to add some oil.
Page 235: What Kind Of Oil To Use
This is where you oil if you have Just fill it enough to put the level somewhere in the proper operating range. Push the dipstick all the way back in when you’re through. 6-12 What Kind of Oil to Use Oils recommended for your vehicle can be identified by looking for the “Starburst”...
Page 236 GM Goodwrench@ oil meets all the requirements for your vehicle. Engine Oil Additives Don’t add anything to your oil. Your Pontiac dealer is ready to advise if you think something should be added. ANY OTHER your...
Page 237: When To Change Engine Oil
When to Change Engine Oil See if any one of these is true for you: Most trips are less than 5 to 10 miles (8 to 16 This is particularly important when outside temperatures are below freezing. Most trips include extensive idling (such as frequent driving in stop-and-go traffic).
Page 238: Air Cleaner
Air Cleaner The air cleaner located on the driver’s side engine compartment near the battery. To check or replace the filter, remove the screws that hold the cover on and lift the cover. Be sure to reinstall the air cleaner filter and replace the cover tightly. Refer the Maintenance Schedule to determine when replace the air filter.
Page 239: When To Check And Change
CAUTION: Operating the engine with the air cleaner cause or others to be burned. The air cleaner not only cleans the air, it stops flame if the engine If it backfires. isn’t there, and the engine Don’t backfires, you could be burned. it off, and be careful working on the engine with off.
Page 240: How To Check
How to Check Because this operation can be a little difficult, you may choose to have this done at your Pontiac dealership Service Department. I f you do it yourself, be sure to follow all the instructions here, or you could get a false reading on the dipstick.
Page 241 Then, without shutting o f f the engine, follow these steps: handle on the transaxle dipstick is a red ring. Pull out the dipstick wipe it with a clean rag or paper towel. 2. Push it back in all the way, wait three seconds and then pull it back out again.
Page 242: How To Add Fluid
A transaxle fluid leak is the only reason for fluid loss. If a leak occurs, take the vehicle to your Pontiac dealer Service Department and have it repaired as soon as possible.
Page 243 How to Check Because this operation can be a little difficult, you may choose to have this done at your Pontiac dealership Service Department. If you do it yourself, be sure to follow here, or you could get a false reading on the dipstick.
Page 244 Check both sides of the dipstick and read the lower level. The fluid level must be between the ADD and FULL marks. (Note: Fluid may appear at the bottom of the dipstick even when the fluid level is several pints low.) If the fluid level is where should be, push the dipstick back in all the way and flip the handle...
Page 245: When To Check And What To Use
“Engine Overheating” in the Index. A 50/50 mixture of water and the proper coolant for your Pontiac will: Give freezing protection down to -34°F Give boiling protection up Protect against rust and corrosion.
Page 246 NOTICE: When adding coolant it is important that you use DEX-COOL (orange-colored, silicate-free) coolant meeting GM Specification 6277M. If silicated coolant is added to the system, premature engine, heater core corrosion may result. addition, the engine coolant will require change sooner 000 km) or 30,000 miles months...
Page 247: Checking Coolant
NOTICE: If you use an improper coolant mix, your engine could overheat and be badly damaged. The repair cost wouldn’t be covered by your warranty, Too much water in the mix can freeze and crack the engine, radiator, heater core and other parts.
Page 248 CAUTION: Turning the surge tank pressure cap when the engine and radiator are hot can scalding liquids to blow out and burn you badly. Never turn the surge tank pressure cap little when the engine and radiator are hot. When your engine is cold, the coolant level should be at the FULL COLD mark.
Page 249: Surge Tank Pressure Cap
Surge Tank Pressure Cap NOTICE: Your surge tank cap is a 15 psi (105 kPa) pressure-type cap and must be tightly installed to prevent coolant loss and possible engine damage from overheating. When you replace your surge tank pressure cap, a GM cap is recommended.
Page 250: Windshield Washer Fluid
When to Check Power Steering Fluid It is not necessary to regularly check power steering fluid unless leak i n suspect these you hear an unusual noise. A fluid loss in this system could indicate a problem. Have the system inspected and repaired.
Page 251: Brake Fluid
When using concentrated washer fluid, follow the manufacturer’s instructions for adding water. Don’t mix water with ready-to-use washer fluid. Water can cause the solution to freeze and damage your washer fluid tank and other parts the washer system. Also, water doesn’t clean as weil as washer Fill your washer fluid tank only 3/4 full when it’s very cold.
Page 252 good off’ it isn’t a idea to “top your brake fluid. Adding brake fluid won’t correct a leak. If you add fluid when your linings are worn, then you’ll have too much fluid when you get new brake linings. You should add (or remove) brake fluid, as necessary, only when work is done on the brake hydraulic system.
Page 253: Brake Wear
See “Appearance Care” the Index. Brake Wear Your Pontiac has front disc brakes and rear drum brakes- Disc brake pads have built-in wear indicators that make a high-pitched warning sound when the brake pads are worn sound may come pads needed.
Page 254: Brake Pedal Travel
Vehicles we design and test have top-quality GM brake parts in them, as your Pontiac does when it is new. When you replace parts of your braking system example, when your brake linings wear down and you...
Page 255: Vehicle Storage
Vehicle Storage If you’re not going to drive your vehicle for or more, take off the black, negative the battery. This will help keep your battery from running down. CAUTION: Batteries have acid that can burn you and gas that can explode. You can be badly hurt if you aren’t careful.
Page 256 1. Remove the first bolt and carefully pry up the shield that covers the headlamp assembly. Be careful not to break the fasteners that hold the shield in place. Remove the bolt that anchors the headlamp assembly. Pull the headlamp assembly toward the front the vehicle to access the bulb assembly.
Page 257 i “ $& Disconnect the bulb base from the socket by lifting the plastic locking tab. 5. Snap a new bulb into the socket. 6. Replace the bulb assembly by reversing Steps 1 through 3. Taillamps For the type of bulb, see “Replacement Bulbs” in the Index.
Page 258: Windshield Wiper Blade Replacement
3. To remove the bulb, pull it out. 4. Push in a new bulb. 5. Reverse all steps to replace the taillamp assembly. Windshield Wiper Blade Replacement Replacement blades come in different types and removed in different ways. For proper type and length, see “Capacities and Specifications”...
Page 259 If you ever have questions a b u t your tire warranty and where to obtain service, see your Pontiac Warranty booklet for details. CAUTION: Poorly maintained and improperly used tires are dangerous.
Page 260: Inflation - Tire Pressure
Inflation Tire Pressure The Tire-Loading Information label which is on the rear edge of the driver’s door shows the correct inflation pressures for your tires when they’re cold. “Cold” means your vehicle has been sitting for at least three hours or driven no more than a mile. NOTICE: a n y m $e!% y-txl %a$ M&!FJnn&h Den2...
Page 261: Tire Inspection And Rotation
Tire Inspection and Rotation Tires should be inspected every 6,000 to 8,000 miles (10 000 to 13 000 k m ) for any signs of unusual wear. If unusual wear is present, rotate your tires as soon as possible and check wheel alignment. Also check for damaged tires or wheels.
Page 262: Buying New Tires
It’s Time for New Tires When One way to tell when it’s time for new tires is to check the treadwear indicators, which will appear when your tires have only 1/16 inch (1.6 mm) or less of tread remaining. You need a new tire if any of the following statements are true: You can see indicators at three or more places...
Page 263: Uniform Tire Quality Grading
your you ever replace tires with those Spec number, make sure they are the same size, load range, speed rating and construction type (bias, bias-belted or radial) your original tires. CAUTION: Mixing tires could cause to lose control while If you mix tires of different sizes driving.
Page 264 Treadwear The treadwear grade is comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded would wear one and a half (I 1/2) times as well on the government course as a tire The relative gm-hmrnce o f tires depends graded upon the actual conditions oftheir use, however, and...
Page 265: Wheel Alignment And Tire Balance
(except some aluminum wheels, which can sometimes be repaired). See your Pontiac dealer if any of these conditions exist. Your dealer will know the kind of wheel you need. 6-42 Each new wheel should have the same load carrying capacity, diameter, width, offset and be mounted the same way as the one it replaces.
Page 266: Tire Chains
Tire Chains NOTICE: problems with If your Pontiac has P195/65R15 or size tires, don’t use tire chains. They can damage your vehicle. If you have other tires, use tire chains only where legal and only when you must. Use only SAE “S’...
Page 267: Appearance Care
When you use anything from a container to clean your Pontiac, be sure to follow the manufacturer’s warnings and instructions. And always open your doors or windows when you’re cleaning the inside.
Page 268 Using Foam-Type Cleaner on Fabric Vacuum and brush the area to remove any loose dirt. Always clean a whole t r i m panel or section. Mask surrounding trim along stitch or welt lines. Multi-Purpose Powdered Cleaner following the directions on the container label. Use suds only and apply with a clean sponge.
Page 269: Cleaning Vinyl
Non-Greasy Stains Stains caused by catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, wine, vomit, be removed as follows: Carefully scrape off excess stain, then sponge the soiled area with cool water. If a stain remains, follow the foam-type instructions described earlier.
Page 270: Cleaning The Outside Of The Windshield And Wiper Blades
During very cold, damp weather more frequent application may be required. (See “Recommended Fluids and Lubricants” in the Index.) Cleaning the Outside of Your Pontiac The paint finish on your vehicle provides beauty, depth mming, wax when o f Color, gloss retention o r windshie.k€.
Page 271: Finish Care
High pressure car washes may cause water to enter your vehicle. Finish Care Occasional waxing or mild polishing of your Pontiac by hand may be necessary to remove residue from the paint finish. You can get GM-approved cleaning products from your dealer. (See “Appearance Care and Materials”...
Page 272: Aluminum Wheels (If So Equipped)
Cleaning Your Convertible Top Your convertible top should be cleaned often. If you use an automatic car wash, use one with water jets and hanging cloths. High pressure car washes may cause water to enter your vehicle. When you hand wash the top, do it in partial shade. Use a mild soap, lukewarm water and a soft sponge.
Page 273: Finish Damage
Although no defect in the paint job causes this, Pontiac will repair, at no charge to the owner, the surfaces new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 000 whichever occurs first.
Page 274: Appearance Care Materials Chart
Appearance Care Materials Chart (0.473 L) 1052870 1052918** (0.237 L) 1052929 (0.473 L) 1052930 (0.237 L) (0.473 L) 12345002** 12 oz. (0.354 L) 12345725 See your General Motors Parts Department for these products. See “Fluids and Lubricants” in the Index. Wash and Wax Concentrate Armor All Protector...
Page 275: Vehicle Identification Number (Vin)
ENGINE CODE MODEL YEAR This is the legal identifier for your Pontiac. It appears on a plate in the front corner of the instrument panel, the driver’s side. You can see it if you look through the windshield from outside your vehicle. The VTN also appears on the Vehicle Certification and Service Parts labels and the certificates of title and registration.
Page 276: Headlamp Wiring
Headlamp Wiring The headlamp wiring is protected by fuses. Should your headlamps fail to function have your headlamp fuses checked right away- Windshield Wipers The windshield wiper motor is protected by breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools.
Page 277 Instrument Panel Fuse Block The fuse panel is located under the left end of the instrument panel. To open,'push the tab on the access door to the left and pull the door forward. Make sure insert the tabs first when replacing the cover. 6-54 Usage Fuse...
Page 278 Mirrors, Remote Keyless Engine Ignition R HDLP Right Headlamp Steering Wheel Controls (If Equipped) Fuse Panel Your steering wheel radio controls are protected by fuses. For service, contact your Pontiac Service Department. &%c&c El k - E S & & Lamps, Entry...
Page 279 Engine Compartment Fuse Block The engine compartment fuse block is located on the driver’s side of the engine compartment. Lift off the cover to check the fuses. Fuse Usage Ignition Switch Circuits Power ACC/Stoplamp Circuits BATT Lighting Circuits BATT 2 Anti-Lock Brake System Engine Cooling Fan COOLING FAN...
Page 280 OUTSIDE LAMPS Back-up Lamps ....... . Sed an ....... Coupe Front Parkingnurn Signal Lamps AllexceptGT...
Page 281: Capacities And Specifications
Not all air conditioning refrigerants are the same. I f the air conditioning system in your vehicle needs refrigerant, b’e sure the proper refrigerant is used. If you’re not sure, ask your Pontiac dealer. See refrigerant charge label under the hood.
Page 282: L Engine Specifications
2.2L Engine Specifications . . . VIN Engine Code ... Type ..Horsepower ..Firing Order .
Page 283 Dimensions Length . . . 18 1.9 inches (462.2 crn) Coupe 181.9 inches (462.2 cm) Sedan ..Convertible 18 1 .~9 inches (462.2 cm) Width ..75.4 inches Coupe ..
Page 284: Section 7 Maintenance Schedule
PRO!%@ LEVEL AND CHANGE AS RECOMMENDE~ This section covers the maintenance required for your Pontiac. Your vehicle needs these services to retain its safety, dependability and emission control performance. Have you purchased the Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or your Pontiac dealer for details.
Page 285 “Part C: Periodic Maintenance Inspections’’ explains important inspections that your Pontiac dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants”...
Page 286: Using Your Maintenance Schedule
If you have any questions on how to keep your vehicle in good condition, see your Pontiac dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you to your dealer for your service needs, you’ll know...
Page 287: Maintenanceschedule
Maintenance Schedule Short Trip/City Definition Follow the Short Trip/City Maintenance Schedule if any one of these conditions is true for your vehicle: Most trips are less than to 10 miles (8 to 16 This is particularly important when outside temperatures are below freezing. Most trips include extensive idling (such as frequent driving in stop-and-go traffic).
Page 288 Maintenance Schedule Long Trip/Higlhway Definition Follow this maintenance schedule only if none of the conditions from the Short Trip/City Maintenance Schedule is true. Driving a vehicle with a fully warmed engine under highway conditions causes engine oil to break down slower. w-$hway Intervals Every 7,500 Miles...
Page 289 Short Trip/City Maintenance Schedule " i". The services shown in this schedule up to 100,000 miles (166 000 k m ) should be performed after 100,000 miles (166 000 at the same intervals. Footnotes The U.S. Envkmmmtd &x~ectirn California Resources Board has determined failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life.
Page 290 Short TriplCity Maintenance Schedule 6,000 Miles (10 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Rotate tires.
Page 291 Short Trip/City Maintenance Schedule Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). DATE ACTUAL MILEAGE Change engine oil and filter (or every 3 months, whichever occurs first).
Page 292: Short Trip/City Maintenance Schedule
Short Trip/City Maintenance Schedule 18,000 Miles (30 000 kmj Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Rotate tires.
Page 293 24,000 Miles 000 km) Change engine oil and filter months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). DATE ACTUAL MILEAGE 27,000 Miles every Change engine 3 months, whichever occurs first).
Page 294 Short TriplCity Maintenance Schedule 30,000 Miles (50 000 km) Change engine oil and filter 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Replace air cleaner filter.
Page 295 Short Trip/City Maintenance Schedule 33,000 Miles (55 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. DATE ACTUAL MILEAGE 7-12 36,000 Miles (60 000 km) Change engine oil and filter (or every 3 months, whichever occurs first).
Page 296 Short TriplCity Maintenance Schedule 39,000 Miles (65 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. DATE ACTUAL MILEAGE 42,000 Miles (70 000 km) Change engine oil and filter (or every 3 months, whichever occurs first).
Page 297 Short Trip/City Maintenance Schedule 45,000 Miles (75 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Inspect air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Service.
Page 298 Short Trip/City Maintenance Schedule 50,000 Miles (83 000 km) Change automatic trans-axk fluid and m e r if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside temperature regularly reaches 90 C) or higher.
Page 299 Short Trip/City Maintenance Schedule 51,000 Miles (85 Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. 7-16 54,000 Miles (90 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
Page 300 Short TriplCity Maintenance Schedule 57,000 Miles (95 Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. DATE ACTUAL MILEAGE }SERVICED 60,000 Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
Page 301 Short Trip/City Maintenance Schedule 60,000 Miles (100 000 km) (Continued) Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Sewice. Inspect Exhaust Gas Recirculation (EGR) system (2.2L Code 4 engine only).
Page 302 Short TriplCity Maintenance Schedule 66,000 Mikes (110 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Rotate tires.
Page 303 Short Trip/City Maintenance Schedule LMile-s (120 72,QOQ Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and. the transaxle shift linkage (or every 6 months, whichever occurs first). DATE ACTUAL MILEAGE...
Page 304 Short Trip/City Maintenance Schedule Change engine oil and €ilter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Rotate tires. See “Tire Inspection and Rotation”...
Page 305 Short Trip/City Maintenance Schedule 84,000 Miles (140 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every months, whichever occurs first). DATE ACTUAL MILEAGE 7-22...
Page 306 Short Trip/City Maintenance Schedule 90,000 Miles (150 000 km) Change engine sit and filter (or 3 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 6 months, whichever occurs first). Replace air cleaner filter.
Page 307 Short Trip/City Maintenance Schedule 93,000 Miles (155 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. DATE ACTUAL MILEAGE 96,000 Miles (160 000 km) Change engine oil and filter (or every 3 months, whichever occurs first).
Page 308 Short Trip/City Maintenance Schedule 99,000 Miles (165 000 km) Change engine oil and filter 3 months, whichever occurs first). An Emission Control Service. 100,000 Miles (166 000 km) (or every Drain, flush and refill cooling (or every 60 months since last service, whichever occurs first).
Page 309 Short Trip/City Maintenance Schedule 100,000 Miles (166 000 km) (Continued) Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: In heavy city traffic where the outside temperature regularly reaches 90 (3 2 C ) or higher.
Page 310 Long TriplHighway Maintenance Schedule The services shown in this schedule up to 100,000 miles (166 000 should be performed after 100,000 miles (166 000 k m ) at the same intervals. Footnotes The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life.
Page 311: Long Trip/Highway Maintenance Schedule
Long Trip/Highway Maintenance Schedule 15,000 Miles (25 000 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 12 months, whichever occurs first). DATE ACTUAL MILEAGE 22,500 Miles (37 500 km)
Page 312 30,000 Miles (50 000 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 12 months, whichever occurs first). Replace air cleaner filter. An Emission Control Sewice.
Page 313 Long Trip/Highway Maintenance Schedule 37,500 Miles (62 Change engine oil and filter 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 12 months, whichever occurs first). Rotate tires. See “Tire Inspection and Rotation”...
Page 314 Long TriplHighway Maintenance Schedule Miles (83 000 km) 50,000 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: In heavy city traffic where the outside temperature regularly reaches 90 C) .or higher. In hilly or mountainous terrain.
Page 315 52,500 Miles (87 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shi€t linkage (or every 12 months, whichever occurs first). Rotate tires. See “Tire Inspection and Rotation”...
Page 316 c] Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. Inspect Exhaust Gas Recirculation (EGR) system (2.2L Code 4 engine only). An Emission Control Service. DATE SERVICED ACTTJAL MILEAGE 67,500 Miles (112 500 km)
Page 317 Lo:ng TridHighway Maintenance Schedule 75,000 Miles (125 000 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 12 months, whichever occurs first). DATE ACTUAL MILEAGE 82,500 Miles (137 500 km)
Page 318 90,000 Miles 000 km) (150 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the suspension, steering linkage and the transaxle shift linkage (or every 12 months, whichever occurs first). Replace- air c.1eane.r filter, An.
Page 319 97,500 Miles (162 500 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Sewice. Lubricate the suspension, steering linkage the transaxle shift linkage (or every 12 months, whichever occurs first). Rotate tires. See “Tire Inspection and Rotation”...
Page 320 Replace spark plugs. An Emission Control Service. Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: In heavy city traffic where the outside temperature regularly reaches 90°F C) or higher. - In hilly or mountainous terrain.
Page 321: At Each Fuel Fill
Part B: Owner Checks and Services Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to yom vehicle, make sure they are the proper ones, as shown in Part D.
Page 322 A transaxle fluid leak is the onIy reason for fluid loss. Check for leaks. If a leak occurs, to your Pontiac dealer Service Department repaired fluid checked by your dealer or service center when you have your engine oil changed.
Page 323: At Least Once A Year
a Year At Least Once Key Lock Cylinders Service Lubricate the key lock cylinders with the lubricant P a r t specified in Body Lubrication Service Lubricate all body door and rear compartment hinges. Also lubricate all hinges and latches, including the primary and secondary hood latch, glove box door, console door and any folding seat hardware.
Page 324 (BTSI) Brake-Transaxle Shift Interlock (Automatic Transaxle) CAUTION: When you are doing this check, the vehicle could move suddenly. If it does, you or others could injured. Follow the steps below. 1. Before you start, be sure you have enough room around the vehicle.
Page 325 Parking Brake and Automatic Transaxle PARK Mechanism Check CAUTION: When you are doing this check, your vehicle could begin to move. You or others could be injured and property could be damaged. Make sure there is room in front your vehicle in case it begins to roll.
Page 326 - Make sure any necessary repairs are completed at once. Proper procedures to perform these services may be found in a Pontiac service manual. See “Service and Owner Publications’’ in the Index. Steering, Suspension and Front-Wheel-Drive Axle Boot and Seal Inspection...
Page 327 Part D: Recommended Fluids and Lubricants NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer. USAGE FLUID/LUBRICANT Engine Oil Engine oil with the American Petroleum Institute Certified For Gasoline Engines “Starburst” symbol of the proper viscosity.
Page 328 USAGE FLUIDlLUBRICANT Manual Chassis lubricant (GM Part Transaxle Shift No. 1052497 or equivalent) or lubricant meeting requirements Linkage of NLGI Grade 2, Category LB or GC-LB. _ _ _ _ ~ Clutch Linkage Engine oil. Pivot Points Chassis Chassis lubricant (GM Part Lubrication, Fuel No.
Page 329 Part E: Maintenance Record After the scheduled services are performed, record the date, odometer reading and who performed the service in the boxes provided after the maintenance interval. 7-46 Any additional information from “Owner Checks and Services” or “Periodic Maintenance” can be added on the following record pages.
Page 330 Maintenance Record ODOMETER MAINTENANCE PERFORMED SERVICED BY READING DATE - - - 7-47...
Page 331 Maintenance Record 7-48...
Page 332: Customer Assistance Information
Section 8 Customer Assistance Information Here you will find out how to contact Pontiac if you need assistance. This section also tells you how to obtain service publications and how to report any safety defects. This section includes infomation on:...
Page 333: What Makes Up Pontiac Cares
YOU! PONTIAC CARES is: A valuable feature that comes with every Pontiac, a feature that offers a multitude of benefits that can give you safety, security, comfort and convenience.
Page 334 If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealership without further help, contact Pontiac Customer Assistance Center calling 1-800-PM-CARES. In Canada, contact GM of Canada Customer Assistance Center in Oshawa by calling 1-8QQ-263.-3.777 (&.g].i.&) (French).
Page 335: Customer Assistance For Text Telephone (Tty) Users
We encourage you to call us so we can give your inquiry prompt attention. However, if you wish to write Pontiac, write to: United States Pontiac Division Customer Assistance Center One Pontiac Plaza Pontiac, MI 48340-2952 Canada General Motors of Canada Limited...
Page 336: Pontiac Roadside Assistance Program
Pontiac Roadside Assistance Program Security While You Travel I -800-ROADSIDI ( I -800-762-3743) As the proud owner of a new Pontiac vehicle, you are automatically enrolled in the Pontiac Roadside Assistance program. This value-added service is intended to provide you with peace of mind as you drive the city or travel the open road.
Page 337 Vehicle identification number Vehicle license plate number Pontiac reserves the right to limit services or reimbursement to an owner or driver when in Pontiac’s judgement the claims become excessive in frequency or type of occurrence. W i l e we hope that you never have the occasion to use our service, it is added security while traveling for you and your family.
Page 338: Pontiac Courtesy Transportation
Po-ntkc srives te- give y w a wony free cJx2ership e-f your vehicle, and we realize the inconvenience of being without a car. So Pontiac has come up with a way to eliminate any frustrations you might have when trying...
Page 339 General Motors reserves the right to change eligibility limitations and/or to discontinue its participation in this program. Both Pontiac and your Pontiac dealer are committed to making sure you are completely satisfied with your new vehicle. Our experience has shown that, if a situation...
Page 340: Reporting Safety Defects To The United States Government
BBB at any time. The BBB will attempt to resolve the complaint serving as an intermediary between you and Pontiac. If this mediation is unsuccessful, an informal hearing will be scheduled where eligible customers may present their case to an impartial third-party arbitrator.
Page 341: Reporting Safety Defects To The Canadian Government
Please call us at 1-800-PM-CARES or write: Pontiac Division Customer Assistance Center One Pontiac Plaza Pontiac, MI 48340-2952 In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French). Or, write:...
Page 342: Service And Owner Publications
Service and Owner Publications Service manuals, service bulletins, owner’s manuals and other service literature are available for purchase for all current and many past model General Motors vehicles. Toll-free telephone numbers for ordering information: United States ..1-800-55 1-4123 .
Page 343: Service Bulletins
Service Bulletins Service bulletins covering various subjects are regularly sent to all General Motors dealerships. GM monitors product performance in the field. When service methods are found which promote better service on GM vehicles, bulletins are created to help the technician perform better service.
Page 344 Section 9 Index Adapter Kits. CD ......Air Bag ........Restrain .
Page 345 ........2-27. 2.28.4.27. 4.36 Glass 7-38 Inside of Your Pontiac ..3.9. 3.12 Instrument Panel Outside of Your Pontiac 3-21 Special Problems .
Page 346 Convertible Top ........Cleaning ........Lowering .
Page 347 ........Engineoil ........Adding .
Page 348 Hood ......Checking Things Under ........Prop .
Page 349 ..Locks ... . . Cylinders Door ..... Key Lock Cylinder Service .
Page 350 Periodic Maintenance Inspections ......Pontiac Cares Information Power ........
Page 351 1-29 Service and Appearance Care 1-26 Service and Owner Publications 1-25 Service Publications 1-6. 2-63 Servicing Your Air Bag-Equipped Pontiac 1-46 Sheet Metal Damage 1-25 Shift Lever ... . 1-14 Shift Light .
Page 352 ......Specifications. Engine Speech Impaired. Customer Assistance ........Speedometer .
Page 353 Towing F k m i t h e b n t ....... From the Rear .
Page 354 1996...

Pontiac 1996 Sunfire Owner's Manual

Quick Links

Need help?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Pontiac 1996 Sunfire

Summary of Contents for Pontiac 1996 Sunfire