Inspection And Maintenance Before Riding; Routine Inspection; Engine Oil Inspection And Change - Sym Joyride S 125i Owner's Manual

10. Inspection and Maintenance Before Riding

(Please refer to the components location diagram for the following components.)

ROUTINE INSPECTION

Check Items
Engine Oil
Fuel
Front
Brake
Rear
Front
tires
Rear
Steering Handle
Speedometer, lights,
and back view mirror
Tightness of Main Components
Abnormal Points
CAUTION:
• If any problem founded during routine inspection, correct the problem before using the scooter again,
have your scooter checked and repaired by the "SANYANG dealer or authorized service personnel" if
necessary.

ENGINE OIL INSPECTION AND CHANGE

INSPECTION:
1. Use the main parking stand to support the scooter on a level ground, remove the dipstick after engine
stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do not
rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase...etc for leakage.)
OIL CHANGE:
• Change engine oil after the first 1,000km, and change
the engine oil every 5,000km thereafter. Clean oil
filter after the first 1,000km, and clean oil filter every
10,000km.
• In order to maintain the engine's maximum
performance, check whether the engine oil is enough
every1,000km. Add oil to upper limit if the engine oil
has been found to be inadequate.
• Engine Oil : Use API SH, SAE 10w-30/40 or better
engine oil. Otherwise, damage will not be covered by
warranty.
※ Recommended Oil: SYM Genuine "SYMOIL"
Engine Oils .
• Oil Capacity : 1.0 Liter (0.8 liters for routine change),
oil filter change: 0.8 liters.
Is there enough engine oil?
Is it enough? Is it Octane 90 or above
Braking condition?
(Brake lever free play: 20~30mm)
Braking condition?
(Brake lever free play: 20~30mm)
Is tire pressure normal?
(Standard: 1.8kgf/cm
Is tire pressure normal?
(Standard: 2.5kgf/cm
Does the steering handle vibrate abnormally or is difficult to turn?
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Are screws, nuts loosen?
Do the previous troubles still exist?
15
10.Inspection and Maintenance Before Riding
Check Key Points
2
)
2
)
Upper
Lower