Related Manuals for Ropox 4Single Battery
Summary of Contents for Ropox 4Single Battery
-
Page 1: Table Of Contents
4Single Battery User manual Installation instructions This manual must always accompany the product PDF 6277 / Rev 003... -
Page 2: Table Of Contents
Table of Contents Table of Contents ........................... 1 Introduction ........................... 3 Technical data ..........................4 List of components .......................... 6 Mounting instructions ........................7 Instructions ............................ 8 Function test .............................. 8 Safety ............................. 9 Maintenance ..........................11 Service forms, operation and maintenance ....................12 Fault finding ..............................13 Waste disposal ............................13 PACKAGING AND TRANSPORT ........................13... -
Page 3: Introduction
Ropox, DK-4700 Næstved, Tel. +45 55 75 05 00 Area of application: The 4Single Battery Pack is an extra pack for the 4Single electric multifunction table. This replacement kit allows the table to be made even more flexible and easy to transport. -
Page 4: Technical Data
Technical data Product number 4Single Battery Pack (rapid) 50-47025 4Single Battery Pack (heavy load) 50-47026 Materials Steel and misc. plastic parts Surface treatment Powder coating: st. CWS 81283 RAL 7021 mat Power supply 220-240V AC / 2A / 50-60Hz Battery Output voltage: 25.2V DC;... - Page 5 Battery status: Battery status button is pressed. LED bar lights up for 3 seconds: • 100 - 76%: 4 LEDs on • 75 - 51%: 3 LEDs on Battery status button • 50 - 26%: 2 LEDs on • 25 - 11%: 1 LED on •...
-
Page 6: List Of Components
List of components 96000545 Control box 1 pc. 96000591 Battery 1 pc. 96000820 Charger 1 pc. 97701-850 Mount for control box and 1 set battery 95091012 Screw ø4.8 x 13 6 pcs 30-67840 Control, small surface (6 x 3 cm) 1 pc. -
Page 7: Mounting Instructions
Mounting instructions Installation must always be carried out by competent personnel. Attach the cables supplied and the existing cables (to motors, anti-crushing strips and control) as shown in the diagram below. Page... -
Page 8: Instructions
Control Motor cable Controlbox Motor cable BATTERY Safety strip Battery Anti-crushing CONTROL BOX strip Proceed as follows to insert the LOGICcell into the Docking Bay: Press the Battery Status Button to switch on the LOGICcell - The buzzer will sound once for 0.5 sec. -
Page 9: Safety
For optimal use of the battery pack’s functions and to avoid accidents, it is important to act in accordance with these basic recommendations. • The 4Single Battery Pack may only be used by people who have read and understood these instructions. - Page 10 • Only Ropox’s original spare parts may be used when replacing parts. If other spare parts are used, any right to make a claim under warranty may be revoked.
-
Page 11: Maintenance
• Check that all leads are correctly fitted and are undamaged. Fill in the service form after each inspection. See section 7.1. Only Ropox’s original spare parts may be used when replacing parts. If other spare parts are used, any right to make a claim under warranty may be lost. -
Page 12: Service Forms, Operation And Maintenance
Service forms, operation and maintenance Service and maintenance Serial no. Service and maintenance Serial no. Date: Date: Signature: Signature: Comments: Comments: Service and maintenance Serial no. Service and maintenance Serial no. Date: Date: Signature: Signature: Comments: Comments: Service and maintenance Serial no. Service and maintenance Serial no. -
Page 13: Fault Finding
Fault finding Faults Possible solutions • Check that the battery is charged. If the battery The height of the frame cannot be adjusted (feels level is so low that it is recommended that you difficult to adjust) recharge it, a warning sound will beep for 3 seconds. -
Page 14: Transport
7.4.2 Transport Regulations for transporting lithium-ion batteries are set for road transport (ADR), air transport (IATA) and sea transport (IMDG). The Battery Pack must be handled with care to minimize the risk of malfunction, damage and injuries. IATA rules as of April 2016 states that lithium batteries may only be charged to a max. -
Page 15: Complaints
Complaints All inquiries concerning complaints must be directed to the distributor representing Ropox on the market in question. Cf. Ropox General Terms of Sale and Delivery. Ropox A/S Ringstedgade 221 DK – 4700 Naestved Tel.: +45 55 75 05 00 Fax.: +45 55 78 05 50 E-mail: info@ropox.dk...
Need help?
Do you have a question about the 4Single Battery and is the answer not in the manual?
Questions and answers