Table of Contents
Advertisement
Quick Links
1101 Myers Parkway
Ashland, OH 44805
Phone: 1-419-289-1144
Fax: 1-419-289-6658
Web Site: http://www.myerspump.com
© 2005
DE and DS Series
Installation/Operation/Parts
For further operating, installation,
or maintenance assistance:
Call 1-419-289-1144
OWNER'S MANUAL
Stainless Steel
Submersible Effluent
and Sewage Pumps
4935 0405
253P7090 (3/21/05)
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Pentair Pool Products Myers DE Series
Summary of Contents for Pentair Pool Products Myers DE Series
- Page 1 OWNER’S MANUAL Stainless Steel Submersible Effluent and Sewage Pumps 1101 Myers Parkway Ashland, OH 44805 Phone: 1-419-289-1144 Fax: 1-419-289-6658 Web Site: http://www.myerspump.com DE and DS Series 4935 0405 Installation/Operation/Parts For further operating, installation, or maintenance assistance: Call 1-419-289-1144 253P7090 (3/21/05) ©...
-
Page 2: General Information
General Information DESCRIPTION GENERAL SAFETY INFORMATION Myers submersible effluent pumps and submersible READ AND FOLLOW SAFETY INSTRUCTIONS! sewage pumps are used for effluent, sewage, and waste- This is the safety alert symbol. When you see this water removal, and for sump drainage in residential symbol on your pump or in this manual, look for sewage systems. -
Page 3: Installation
Installation Vent sewage or septic tank according to local codes. INSTALLATION In the United States, do not install pump in any location Risk of electrical shock. Can burn or kill. Do classified as hazardous by National Electrical Code, not lift pump by power cord. See “Lifting Pump” and ANSI/NFPA 70-1984. -
Page 4: Operation
Installation / Operation Piping For automatic operation, plug or wire pump into an auto- matic float switch or pump controller. For continuous Piping must not be smaller than pump discharge. operation, plug directly into an electrical outlet or wire The rate of flow in the discharge pipe must keep any directly into switch box. -
Page 5: Maintenance
Maintenance MAINTENANCE 10. Slide the lower bearing holder off of the shaft and pop the oil seal out of the lower bearing holder. Hazardous voltage. Can shock, burn, or 11. Reverse steps 1 through 10 to reassemble the pump. cause death. Before removing pump from basin for ser- Use 40 grams (1.6 ounces) of U197-8A oil to refill the vice, always disconnect electrical power to pump and oil chamber. -
Page 6: Repair Parts
Repair Parts... -
Page 7: Repair Parts List
Repair Parts REPAIR PARTS LIST Part Description Qty. DE40PC1 DE50PC1 Float switch with cord clamp PW217-107B PW217-107B Single phase power cable with grommet 751S5100 751S5100 Nut M4 SS Washer M4 SS Motor cover § § Capacitor box cover 101P1560 101P1560 †7 O-Ring and gasket kit ZBR02560... - Page 8 Repair Parts...
- Page 9 Repair Parts REPAIR PARTS LIST Part Description Qty. DSW40P1 DSW50P1 DSW50M2 Float switch with cord clamp PW217-107B PW217-107B Power cable with grommet 751S5120 751S5120 751S5150 Nut M4 SS Washer M4 SS Motor cover § § § Capacitor box cover 101P1560 101P1560 101P1560 †7...
- Page 10 Repair Parts...
- Page 11 Repair Parts REPAIR PARTS LIST Part Description Qty. DSW100M2 DSW100M4 Float switch with cord clamp – Power cable with grommet 751S5150 751S5130 Nut M4 SS Washer M4 SS Motor cover § § Capacitor box cover 101P1560 101P1560 †7 O-Ring and gasket kit ZBR05800 ZBR05800 (Incl.
-
Page 12: Troubleshooting
Troubleshooting Read and understand safety and operating Risk of electrical shock. Disconnect power instructions in this manual before doing any work on to outlet before handling pump or motor. Sudden Starts. If pump! power is on to pump when thermal overload resets, pump may start without warning. -
Page 13: Warranty Period
Warranty MYERS LIMITED WARRANTY During the time periods and subject to the conditions hereinafter set forth, F.E. Myers will repair or replace to the original user or consumer any portion of your new MYERS product which proves defective due to defective materials or workmanship of MYERS.
Need help?
Do you have a question about the Myers DE Series and is the answer not in the manual?
Questions and answers