Subscribe to Our Youtube Channel
Related Manuals for Westinghouse WGen5300c
Summary of Contents for Westinghouse WGen5300c
- Page 1 USER MANUAL WGen5300 Portable Generator Gasoline: 5300 Running Watts | 6600 Peak Watts DO NOT RETURN THIS PRODUCT TO THE STORE If you have questions or need assistance, please call customer service at 855-944-3571.
-
Page 2: Table Of Contents
The illustrations used in this manual are intended as representative reference views only. We reserve the right to make any specification or design change without notice. 2 | Westinghouse Outdoor Power Equipment, LLC... -
Page 3: Introduction
Model Number: Or scan the following QR code with your smartphone camera to be directed to the link. Serial Number: Place of Purchase: IMPORTANT: Keep your purchase receipt for trouble-free warranty coverage. Westinghouse Outdoor Power Equipment, LLC | 3... -
Page 4: Safety
Ground. Consult with electrician to improperly. determine grounding requirements before operation. Note: Indicates a procedure, practice or condition that should be followed for the generator to function in the manner intended. 4 | Westinghouse Outdoor Power Equipment, LLC... -
Page 5: Safety Instructions
The connection must isolate the generator power from utility power and must comply with all applicable laws and electrical codes. Westinghouse Outdoor Power Equipment, LLC | 5... - Page 6 • Shut down the engine and allow it to cool for two When storing the generator: minutes before adding gasoline or oil to the generator. • Store away from sparks, open flames, pilot lights, heat, and other sources of ignition. 6 | Westinghouse Outdoor Power Equipment, LLC...
-
Page 7: Safety Labels
SAFETY SAFETY LABELS Westinghouse Outdoor Power Equipment, LLC | 7... -
Page 8: Co Sensor
A CO sensor air immediately. Call emergency services. You may have fault can only be diagnosed and repaired carbon monoxide poisoning. by an authorized Westinghouse service ACTION LABEL center. 8 | Westinghouse Outdoor Power Equipment, LLC... -
Page 9: Components
4. Main Circuit Breaker: The main circuit breaker 12. Smart Switch Outlet: Connects the Westinghouse controls total output of all outlets to protect the generator from overload or short circuit. -
Page 10: Generator Components
Fuel cap Fuel gauge Spark plug Serial number Carburetor Alternator cover Muffler/spark arrestor Carbon canister Fuel tank valve Control panel Choke lever Air filter Battery Oil dipstick/ filler neck Oil drain Recoil bolt Starter 10 | Westinghouse Outdoor Power Equipment, LLC... -
Page 11: Assembly
Note: The wheels are only intended for hand transport. If any parts are missing, contact our service team at The wheels are not suitable for towing the generator service@wpowereq.com or call 1-855-944-3571. either on or off-road. Westinghouse Outdoor Power Equipment, LLC | 11... -
Page 12: Initial Oil Fill
• DO NOT create a spark or flame while fueling. bottle to prevent overfilling the engine. See Engine Oil Level Check in the Maintenance section. 3. Wipe the oil dipstick clean. Replace the oil dipstick and hand-tighten. 12 | Westinghouse Outdoor Power Equipment, LLC... -
Page 13: Connect The Battery
Damage caused by spilled fuel is not covered under warranty. NOTICE Clean the fuel screen filter of debris before and after each fueling. Remove the fuel screen filter by slightly compressing it while removing it from the fuel tank. Westinghouse Outdoor Power Equipment, LLC | 13... -
Page 14: Operation
High Altitude Carburetor Kit: Part# 518965 stairs, next to walls or buildings, or in any other location that will not allow for adequate cooling of the generator and/or the muffler. DO NOT contain generators during operation. 14 | Westinghouse Outdoor Power Equipment, LLC... -
Page 15: Voltage Selector Switch
AC circuit breaker ON. 4. Turn the fuel tank valve to the ON position. Westinghouse Outdoor Power Equipment, LLC | 15... -
Page 16: Generator Capacity
2000 2000 Totals 2590 1600 *Wattages listed are approximate. Verify actual wattage. Total Running Watts* 2590 Highest Starting Watts* + 1600 Total Starting Watts Needed 4190 *Wattages listed are approximate. Verify actual wattage. 16 | Westinghouse Outdoor Power Equipment, LLC... -
Page 17: Extension Cords
• Keep the unit level during transport to minimize the possibility of fuel leakage or, if possible, drain the fuel or run the engine until the fuel tank is empty before transport. Westinghouse Outdoor Power Equipment, LLC | 17... -
Page 18: Maintenance
Maintenance reminder codes will be shown on the Data Display based on unit Lifetime Hours. The maintenance codes will be displayed until the unit is turned off. Refer to the Maintenance section for specific procedures. Rubber cap 18 | Westinghouse Outdoor Power Equipment, LLC... -
Page 19: Engine Oil Level Check
L and H marks on the dipstick. Stop frequently to check the oil level. DO NOT overfill. Maximum oil capacity: 0.74 Quart (0.7 Liter) 7. Install the oil dipstick and hand-tighten. Westinghouse Outdoor Power Equipment, LLC | 19... -
Page 20: Spark Plug Maintenance
NOTICE 1. Place the generator on a level surface. ALWAYS use the Westinghouse OEM or compatible 2. Slide in screwdriver into side slot and remove screw non-resistor-type spark plug. Use of resistor-type spark holding clamp (A) on spark arrestor. -
Page 21: Battery Replacement
Full-time use of fuel stabilizer is recommended. Follow the manufacturer’s instructions for use. STORAGE TIME RECOMMENDED PROCEDURE 3. Place an appropriate gasoline container under the drain Less than 1 month No service required. screw to catch the drained fuel. Westinghouse Outdoor Power Equipment, LLC | 21... -
Page 22: Fuel Valve Maintenance
Torque: 106 inch-pound (12 N•m) 8. Perform this procedure for the other valve. 4. Wash the sediment cup, o-ring, and screen in a 9. Install the gasket, rocker arm cover, and spark plug. nonflammable solvent. Dry thoroughly. 22 | Westinghouse Outdoor Power Equipment, LLC... -
Page 23: Troubleshooting
Replace or repair tool or appliance. Stop and Faulty power tool or appliance. No power at AC receptacles restart the engine. Contact Westinghouse customer service toll- Faulty generator. free at 1 (855) 944-3571. Westinghouse Outdoor Power Equipment, LLC | 23... -
Page 24: Exploded Views And Parts List Engine Exploded View
EXPLODED VIEWS EXPLODED VIEWS AND PARTS LIST ENGINE EXPLODED VIEW 24 | Westinghouse Outdoor Power Equipment, LLC... -
Page 25: Engine Parts List
90016 NUT M6 407501 WIND-LEAD-COVER 13.3 402901 AIR FILTER ASSEMBLY 91325 BOLT M6*16 13.3.1 5941 AIR FILTER ELEMENT 97108 SPARK PLUG IGNITOR ASSEMBLY CYLINDER HEAD COVER ASSEMBLY 14.1 97514 IGNITOR 91329 BOLT M6*16 Westinghouse Outdoor Power Equipment, LLC | 25... - Page 26 16.2.2 5942-221 START PULLER 16.3 260801 CABLE CLIP STARTER MOTOR ASSEMBLY 17.1 97459 STARTING MOTOR 17.2 240910 LOCATING PIN 91816 BOLT M6*16 GB/T5787-1986 94007 OIL DRAIN BOLT WASHER 96224 GASKET 94229 AIR FILTER GASKET 26 | Westinghouse Outdoor Power Equipment, LLC...
-
Page 27: Generator Exploded View
EXPLODED VIEWS GENERATOR EXPLODED VIEW Westinghouse Outdoor Power Equipment, LLC | 27... -
Page 28: Generator Parts List
FUEL LINE CLAMP 11.3 6560 TERMINAL ASSEMBLY CONTROL PANEL ASSEMBLY 11.4 532306 ALTERNATOR TAIL BRACKET 91327 BOLT M6X12 11.5 96813 GASKET 714385 CONTROL PANEL 11.6 91721 BOLT M10X1.25X225 7.2.1 536002 SWITCH 11.7 91619 BOLT M6X140 28 | Westinghouse Outdoor Power Equipment, LLC... - Page 29 TAIL BRACKET FIXING PLATE 11.15 94204 SPRING WASHER CO MODULE ASSEMBLY 12.1 599064 CO MODULE 12.2 92270 CROSS SLOTTED HEAD SCREW M4*16 99010 SPARK PLUG WRENCH 500942 FUNNEL 99025 WRENCH 511076 BATTERY CHARGER Westinghouse Outdoor Power Equipment, LLC | 29...
-
Page 30: Schematics
SCHEMATICS SCHEMATICS SCHEMATICS 30 | Westinghouse Outdoor Power Equipment, LLC...
Need help?
Do you have a question about the WGen5300c and is the answer not in the manual?
Questions and answers