Illustrated Description - stayer GAV2800 Operating Instructions Manual

gb
Be sure that all appliances are in good working
order before connecting them to the generator. If an
appliance begins to operate abnormally, becomes
sluggish, or stops suddenly, turn off the generator
engine switch immediately. Then disconnect the
appliance, and examine it for signs of malfunction.
2.3 GENERATOR START
Start engine according to "Operating instructions".
Confirm that the equipment to be used is disconnected,
and insert the male plug in the AC outlet.
Check that the equipment to be connected is
switch off. When the equipment to be used is
switched on, it will operate suddenly, and injuries
or accidents may be caused.
2.4 OUTPUT INDICATORS AND OVERLOAD
The output indicator 9 will remain 230 V during normal
operating conditions.
Before connecting an appliance to the
generator, check that it is in good order, and
that its electrical rating does not exceed
that of the generator. Then connect the
power cord of the appliance, and start the engine.
Connect the ground terminal according to the
regulations in force.
2.5 BATTERY CHARGING
When charging batteries, person must be
present to monitor the voltage.
Stop charging when the voltage of the batteries is
above 14.4V. Or it may cause battery explosion,
resulting in serious injury or death.
To prevent the possibility of creating a spark near the
battery, connect charging cable first to the generator,
then to the battery. Disconnect cable first at the battery.
Before connecting charging cables to a battery that
is installed in a vehicle, disconnect the vehicles
grounded battery cable.
Reconnect the vehicle's grounded battery cable after
the charging cables are removed. This procedure will
prevent the possibility of a short circuit and sparks
if you make accidental contact between a battery
terminal and the vehicle's frame or body.
Do not attempt to start an automobile engine while the
generator still connected to the battery. The generator
may be damaged.
Connect the positive battery terminal to the positive
charging cord. Do not re-verse the charging cables,
or serious damage to the generator and/or the battery
may occur.
The battery gives off explosive gases; keep spark,
flames and cigarettes away. Provide adequate
ventilation when charging.
The battery contains sulphuric acid (electrolyte).
Contact with skin or eyes may cause severe burns.
Wear protective clothing and a face shield.
If electrolyte gets on your skin, flush with water.
If electrolyte gets in your eyes, flush with water for at
least 15 minutes and call a physician. Electrolyte is
poisonous.
If swallowed, drink large quantities of water or milk and
follow with milk or magnesia or vegetable oil and call
a physician.
Keep out of the reach of children, pets and
untrained people.

2.6 ILLUSTRATED DESCRIPTION

1 Fuel cap
2 Fuel level indicator
3 Remote starter
4 Control panel
5 Starting grip
6 Command the fuel shutoff valve
7 Maintenance cover
8 Electrical output socket 230V 50Hz
9 Output voltage indicator
10 ON/OFF/START Switch
11 Electrical Grounding
12 Out of 12 Vdc
13 Output overload protector
14 Oil drain plug
15 Oil filler cap
2.7 LIMITATIONS OF ENVIRONMENTAL
CONDITIONS
Apply regard contained in Chapter 1 "specific
safety instructions."
3_OPERATING INSTRUCTIONS
3.1 PLACEMENT AND TESTING
Be sure to check the generator on a level
surface with the engine stopped.
3.2 START 4T
Before starting the engine, disconnect any
load from the receptacle.
Set the fuel valve in the "ON"-position.
To start a cold motor shove the choke lever all the way
to the left. To restart a hot motor set the choke lever
half-way.
- 20 -