Suzuki VZ1600K4 Setup Manual page 22

A. Shift Pedal
B. Align the Punched Marks.
C. Bolt
•
Reinstall the footpeg assembly with two bolts
and tighten the bolts to the specified torque.
Torque: 30 N·m (3.1 kgf·m, 22 ft·lb)
Fuel
WARNING
Fill the tank in a well-ventilated area, and
take ample care that there are no sparks
or open flames anywhere near the work
area.
•
Open the fuel tank cap, and check for debris
in the fuel tank.
•
Fill the fuel tank with one gallon or four liters
of unleaded gasoline. Use a gasoline with a
minimum Antiknock Index rating according to
the recommendation of your country. Refer to
the following table.
The antiknock index is an average of the Re-
search Octane Number (RON) and the Motor
Octane Number (MON), as shown in the table.
Octane Rating Method
Antiknock (RON + MON)
Index
Research Octane Number
(RON)
•
Close the fuel tank cap, and check for any
leaks.
Minimum
Rating
90
2
95
Throttle Grip and Cable
Throttle Grip Free Play Inspection
•
Inspect the throttle grip free play. If the free
play is incorrect, adjust the throttle cables.
Throttle Grip Free Play:
2 ~ 3 mm (0.08 ~ 0.12 in.)
•
Check that the throttle grip moves smoothly
from full open to close, and the throttle closes
quickly and completely in all steering posi-
tions by the return spring. If the throttle grip
does not return properly, check the throttle ca-
ble routing, grip free play, and for possible ca-
ble damage. Then lubricate the throttle ca-
bles.
A. Throttle Grip
B. 2 ~ 3 mm (0.08 ~ 0.12 in.)
•
Run the engine at idle speed, and turn the
handlebar all the way to the right and left to
ensure that the idle speed does not change.
If the idle speed increases, check the throttle
grip free play.
Operation with an improperly adjusted,
incorrectly routed, or damaged cable
could result in an unsafe riding condi-
tion.
Throttle Grip Free Play Adjustment
•
Slide the cable adjuster dust cover out of
place.
•
Loosen both locknuts of the throttle cables
and turn both adjusters in completely to give
the throttle grip plenty of play.
•
Turn out the decelerator cable adjuster until
there is no play when the throttle grip is com-
pletely closed. Tighten the locknut.
- 20 -
WARNING