MAULE MXT-7-180 Airplane Flight Manual
  1. Manuals
  2. Brands
  3. MAULE Manuals
  4. Aircrafts
  5. MXT-7-180
  6. Airplane flight manual

MAULE MXT-7-180 Airplane Flight Manual

Hide thumbs Also See for MXT-7-180:
Table of Contents

Advertisement

Quick Links

FAA APPROVED
FOR
MAULE
MXT-7-180
Airplane Serial No.__________________
Registration No.____________________
THIS DOCUMENT MUST BE KEPT IN THE AIRPLANE AT ALL TIMES.
FAA APPROVED:
DATE:
Performance That Counts!
2099 Georgia Highway 133 South • Moultrie, GA 31788
(229) 985-2045 • Fax: (229) 985-2048 or (229) 890-2402 •
www.mauleairinc.com

Advertisement

Table of Contents
loading

Related Manuals for MAULE MXT-7-180

Summary of Contents for MAULE MXT-7-180

  • Page 1 FAA APPROVED MAULE MXT-7-180 Airplane Serial No.__________________ Registration No.____________________ THIS DOCUMENT MUST BE KEPT IN THE AIRPLANE AT ALL TIMES. FAA APPROVED: DATE: Performance That Counts! 2099 Georgia Highway 133 South • Moultrie, GA 31788 (229) 985-2045 • Fax: (229) 985-2048 or (229) 890-2402 •...

  • Page 3: Log Of Supplements

    07/01/91 Installation of Century IIB Autopilot per Maule Installation Manual AK513. 07/01/91 Inst. of S-TEC System 50 Two Axis Autopilot Model ST-418-50 (14v) - Maule 01/05/00 Drawing 9193A, Rev. B or later. English to Metric Conversion Charts - required in aircraft when registered in 09/03/99 Canada.

  • Page 4: Table Of Contents

    MAULE AEROSPACE TECHNOLOGY, INC. AIRPLANE FLIGHT MANUAL MAULE MXT-7-180 Page iii TABLE OF CONTENTS ITEM COVER PAGE LOG OF REVISIONS……………………………….…………………….. i LOG OF SUPPLEMENTS………………………….…………………..… ii TABLE OF CONTENTS…………………………….…………………..iii & iiii GENERAL SECTION I Plan View……………………………………………..…………….. 1 Maximum Weight……………………………..……………. 2 Center of Gravity Limits………………………..………….

  • Page 5: Table Of Contents

    MAULE AEROSPACE TECHNOLOGY, INC. AIRPLANE FLIGHT MANUAL MAULE MXT-7-180 Page iiii TABLE OF CONTENTS WEIGHT AND BALANCE AND EQUIPMENT LIST SECTION V Weight and Balance Data…………………………….….. 17 Required Equipment List ………Provided for each Airplane AIRCRAFT SERVICING, HANDLING AND MAINTENANCE SECTION VI Introduction…………………………………………………...

  • Page 6: Plan View

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION I AIRPLANE FLIGHT MANUAL GENERAL MAULE MXT-7-180 PAGE 1...

  • Page 7: Section I

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION I AIRPLANE FLIGHT MANUAL GENERAL MAULE MXT-7-180 SECTION I GENERAL: NORMAL CATEGORY OPERATION MAXIMUM WEIGHT: 2500 Pounds CENTER OF GRAVITY LIMITS: +15.9 to +20.5 @ 2500 lbs. +12.4 to +20.5 @ 1740 lbs. or less...

  • Page 8: Limitations

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION II AIRPLANE FLIGHT MANUAL LIMIATIONS MAULE MXT-7-180 SECTION II LIMITATIONS AIRSPEED LIMITS: All airspeeds are Indicated Airspeeds (IAS). A. AIRSPEED INDICATOR MARKINGS: Red Radial, (V ) - 158K (182 mph) Yellow Arc, Caution Range - 128 - 158K (147 - 182 mph)

  • Page 9: Power Plant Limits

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION II AIRPLANE FLIGHT MANUAL LIMITATIONS MAULE MXT-7-180 POWER PLANT LIMITS: Engine: Lycoming O-360-C1F Engine Limits: 180 hp @ 2700 rpm, Full Throttle Continuous Propeller: Hartzell Constant Speed HC-C2YR-1BF/F7666A (76" Dia.) Fuel: 100/100LL Minimum Grade Aviation Gasoline...

  • Page 10: Flight Load Factors

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION II AIRPLANE FLIGHT MANUAL LIMIATIONS MAULE MXT-7-180 FLIGHT LOAD FACTORS: Flaps Fully Retracted: 3.8g Positive to 1.5g Negative Flaps Extended: 1.9g Positive to 0g Negative NOTE: DESIGN MANEUVERING SPEED: The maximum safe airspeed at which full aerodynamic controls can be applied (VA) is 109K (125 mph).

  • Page 12: Normal Procedures

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES SECTION III NORMAL PROCEDURES: PREFLIGHT INSPECTION: A. INTERIOR: BAT Switch…………………………………..ON Fuel Gauges…………………………………… CHECK INDICATIONS All Electrical Switches………………………… OFF BAT Switch……………………………………. OFF Flaps…………………………………………… FULL DOWN (3RD NOTCH)

  • Page 13: Operating Check Lists

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES PREFLIGHT INSPECTION: (Cont'd) Right Landing Gear…………………………… CHECK TIRE INFLATION & BRAKE LINE SECURITY Right Wing & Controls……………………….. INSPECT SAME AS LEFT WING Wing Main & Aux Fuel Tank Drain…………. DRAIN (2) Right Fuselage, Side &...
  • Page 14 MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES OPERATING CHECK LISTS: (Cont'd) NOTE: FOR A HOT START, DO NOT PRIME. A HOT ENGINE MAY FLOOD ON A START ATTEMPT. TO CLEAR A FLOODED ENGINE, PULL MIXTURE FULL LEAN AND OPEN THROTTLE, CRANK WITH STARTER.
  • Page 15 MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES D. BEFORE TAKEOFF: Fuel Selector………………………………….. ON FULLEST TANK OR BOTH Flaps…………………………………………… AS DESIRED FOR T.O. (MAX. 24°) Trim Controls………………………………..SET FOR TAKEOFF Flight Controls………………………………… CHECK FOR FREEDOM & PROPER TRAVEL Mixture Control…………………………….….

  • Page 16: Normal Flight Operations

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES NORMAL FLIGHT OPERATIONS: A. NOTE: FLAP SETTINGS: The following Flap Settings are available: Flap Configuration Flap Handle Position Flap Position Cruise Handle Full Down -7° Flaps Up First Notch 0°...
  • Page 17 MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES D. RUDDER TRIM: NOTE: To assure full effectiveness of the Right Rudder Trim: Unlock "T" handle (1/2 turn left), depress right rudder as you pull "T" handle full out.

  • Page 18: Door-Off Operation

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION III AIRPLANE FLIGHT MANUAL NORMAL MAULE MXT-7-180 PROCEDURES DOOR-OFF OPERATION: This aircraft may be operated with either one (not both) of the front doors removed, or when both front doors are installed, with the rear passenger door or rear passenger and baggage doors off.

  • Page 19: Emergency Procedures

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION IV AIRPLANE FLIGHT MANUAL EMERGENCY MAULE MXT-7-180 PROCEDURES SECTION IV EMERGENCY PROCEDURES EMERGENCY BASIC RULES: To assist the pilot when an emergency occurs, three basic rules are established which apply to most emergencies occurring while airborne. Each aircrew member should remember them.

  • Page 20: Partial Power Failure During Flight Of After T.0

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION IV AIRPLANE FLIGHT MANUAL EMERGENCY MAULE MXT-7-180 PROCEDURES ENGINE FAILURE AFTER TAKEOFF OR FORCED LANDING: (Cont'd) Electric Fuel Pump - On Mixture Rich, Ignition On Alternate Air Control - Pull On If engine does not restart, accomplish EMERGENCY SHUT DOWN...

  • Page 21: Smoke And Fume Elimination

    MAULE AEROSPACE TECHNOLOGY, INC. SECTION IV AIRPLANE FLIGHT MANUAL EMERGENCY MAULE MXT-7-180 PROCEDURES 4.13 SMOKE AND FUME ELIMINATION: Cabin Heat Knob - In Cabin Air Knob - In Upper Air Vents - Open Pilot's Window - Open (below 104K (120 mph) 4.14 STRUCTURAL DAMAGE:...
  • Page 22 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 SECTION V WEIGHT AND BALANCE Serial Number______________________ Registration Number______________________ It is the responsibility of the airplane owner and the pilot to insure that the airplane is loaded properly.
  • Page 23 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 WEIGHT AND BALANCE: (Cont'd) DETAILED CALCULATIONS OF EMPTY WEIGHT AND EMPTY WEIGHT CENTER OF GRAVITY AS DELIVERED FROM FACTORY: PROCEDURE: Place each of the wheels on a scale with the airplane in approximate level flight attitude.
  • Page 24 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 WEIGHT AND BALANCE: (Cont'd) The above empty weight includes unusable fuel of ** lbs. at 24 inches and 8 quarts of oil at minus 36.5 inches, plus all items of equipment as marked on the accompanying Equipment Lists.
  • Page 25 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 FORM 52 PAGE 20...
  • Page 26 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 FORM 52 PAGE 22...
  • Page 27 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 FORM 52 PAGE 23...
  • Page 28 MAULE AEROSPACE TECHNOLOGY, INC. SECTION V AIRPLANE FLIGHT MANUAL WEIGHT AND BALANCE MAULE MXT-7-180 SERIAL NO._________________REG.NO.__________________MODEL__________________ EQUIPMENT CHANGE - WEIGHT AND BALANCE ITEM'S (MAKE & MODEL) WEIGHT MOMENTS Previous Aircraft Empty New Empty Weight ______________________lbs. New Empty Center of Gravity ______________ins.
  • Page 29 It is required that owner's email address, (name and address – optional) and aircraft serial number be sent to OwnerAlert@mauleairinc.com for notification of any Maule Service Letters, Service Bulletins and/or Manual updates available for downloading from our website at mauleairinc.com.

Table of Contents