VOGT ICE TUBE-ICE P-24A Service Manual page 3

Machine Model No. ________________________________
Installed at: ____________________________________________________________(
Company Name
_______________________________________________________________________________________________________
Address
______________________________________________________________________________________________________
Installed by: ___________________________________________________________(
Company Name
_______________________________________________________________________________________________________
Address
Describe any damage to machine/repairs made: _____________________________________________________________________________
__________________________________________________________________________________________________________________
__________________________________________________________________________________________________________________
Start up by: ___________________________________________________________(
Company Name
_______________________________________________________________________________________________________
Address
Name of person starting up machine: ____________________________________________________________________________________
CHECK
Service Manual on hand
Machine room suitable 50°F minimum, 110°F maximum
Proper power supply, actual voltage _______________, _________________, _________________ (machine not running)
Compressor crankcase heater on 12 hour minimum
Necessary hand valves opened as required
Solenoid valve stems in auto position
System leak checked/tight
Auxiliary equipment overloads wired into control circuit
Compressor oil level _______ (1/4 glass min.)
All water distributors in place (visually inspected)
Water supply and drain lines installed and connected properly
Compressor, pump, cutter and other motor direction of rotation correct
Make-up water float valve adjusted properly
Hour meter in control panel connected
Machine charged with refrigerant lbs.______________ Actual voltage ____________ , _______________, ________________(machine running)
Ambient temp. _____ °F Fan cycles On _____ Off _____ Tower water in _____°F out ______ °F
Comp motor RLA _____________, _____________, _____________, Actual _____________, _____________, _____________,
Pump RLA _____________, _____________, _____________, Actual _____________, _____________, _____________
Cutter motor RLA _____________, _____________, _____________, Actual _____________, _____________, _____________
Suction pressure end of freezing _______, end of harvest _______ Discharge pressure end of freezing ___________, end of harvest __________
Evaporator/suction line frost _____________________________ Receiver liquid level operating ___________________
Test Water
Cycle Temp
#1
#2
#3
#4
Note: Ice lb. per day can be found by:
The machine operated satisfactorily for ___ continuous hours. Date _______________________________________
Comments__________________________________________________________________________________________________________
__________________________________________________________________________________________________________________
Installer signature ____________________________________________ End user signature _________________________________
Please return to: Vogt Ice LLC, 1000 W. Ormsby, Suite #19, Louisville, KY 40210
12/20/12
Vogt
MID & LARGE MACHINE WARRANTY REGISTRATION/START-UP REPORT
MUST COMPLETE AND RETURN TO INITIATE WARRANTY
PRE START-UP CHECK
OPERATION CHECK
FreezeTime Harvest Time
Min/Sec Min/Sec
ice lb. per harvest
(freeze time + harvest time)
® ®
Tube-Ice Machine
Serial No. ____________________________________________
)_______________________________________
Phone
City
)________________________/____/________
Phone
City
)________________________/____/_________
Phone
First Ice Out All Ice Out Avg. Hole
Min/Sec Min/Sec
x 1440
State Zip
Date
State Zip
Date
Ice Lb. Per Ice Lb. Per
Size Harvest Day