Table of Contents
Advertisement
CONTENTS
FIG. 1
38ASB/CCARS240~600
(036~060) Export
SAFETY CONSIDERATIONS
Installation and s ervicing of air conditioning equipment can
be hazardous due to system pressure and electrical
components. Only trained and qualified service personnel
should install, repair or service air conditioning equipment.
Observe precautions in the literature, tags and labels
attached to the unit and other safety codes. Wear safety
glasses and gloves. Use quenching cloth and have fire
extinguisher available for all brazing operations.
RECEIVING
38ASB/CCARS240~600 condensing units (Fig. 1) are
shipped individually packed in carton boxes. When cartons
are individually off loaded from truck, do not roll, nor throw,
or drop the carton, to avoid damages to the content. Store
boxes upright as the symbols or the boxes indicate. Do not
stack units more than 2 high.
Concepcion
Carrier
Air conditioning
Company
Philippines
1
2
2
3
4
4
5
INSTALLATION, START-UP AND
SERVICE INSTRUCTIONS
38ASB/CCARS240~600 (036~060)
AIR-COOLED CONDENSING UNIT
INSPECTION
Check the shipment against shipping list and remove unit
from the carton and take off protective covering. If the unit
has been damaged, file claim with Transportation Company
and notify Carrier immediately.
PROTECTION
Protect unit from damage caused by job site debris. Do
not allow dust, debris and water get into the unit.
These will damage unit's component and unit's
performance will be affected.
WARNING
Before installing or servicing system always turn off main
power supply. There may be more than one disconnect
switch. Electrical shock can cause personal injury.
5
5
5 - 6
6 - 7
7 - 13
14
1
Advertisement
Table of Contents
Related Manuals for Carrier 38ASB Series
Summary of Contents for Carrier 38ASB Series
-
Page 1: Table Of Contents
Only trained and qualified service personnel has been damaged, file claim with Transportation Company should install, repair or service air conditioning equipment. and notify Carrier immediately. Observe precautions in the literature, tags and labels attached to the unit and other safety codes. Wear safety PROTECTION glasses and gloves. -
Page 2: Dimensional Drawing
FIG. 2 38ASB/CCARS024~060 DIMENSIONAL DRAWING TABLE 1 – MODEL IDENTIFICATION SERIES (EXPORT) (EXPORT) 38ASB600DB * OLD MODEL NUMBER 38ASB 38ASB240BA 38ASB360BA 38ASB036BA 38ASB060BA 38ASB600DC ** NEW MODEL NUMBER CCAR CCARS024EA CCARS036EA CCARS060KA Single phase supply REMARKS volatge Legend: * - Model used for 40KMC/GKX, 42GX/AR, 40LX ** - Model used for SlimPack ASBFE600BA... -
Page 3: Specifications
TABLE 2 SPECIFICATIONS 38ASB / CCARS MODEL 240BA 360BA 036BA (Export) 060BA (Export) 600DA/DB 600DC OPERATING WEIGHT (kg) 80.5 80.5 GROSS WEIGHT (kg) 69.5 97.5 87.5 87.5 REFRIGERANT Type R-22 Factory charged (kg) 2.52 2.52 2.55 2.27 2.50 COMPRESSORS Type Hermetic Oil Charged (l) 0.90... -
Page 4: Installation
INSTALLATION Run refrigerant tubes as directly as possible, avoiding SELECTION OF MOUNTING POSITION unnecessary turns and bends. Condensing unit may be The unit should be installed outdoors. connected to evaporator sections using field-supplied A place where air will not be stagnant. tubing of refrigerant grade, correct size and condition. -
Page 5: Piping Connections
PIPING CONNECTIONS Note: - Operation of unit on improper line voltage constitutes abuse and could affect Carrier Warranty. Do not install Complete all installation and piping work required for indoor and unit in system where voltage may fluctuate above or below outdoor units. -
Page 6: Service And Maintenance
R E F R I G E R A N T C H A R G I N G ( c o n t ) If unit has higher suction line temperature than charted temperature add refrigerant until charted temperature is reached. -
Page 7: Wiring Diagram
PE740132 FIG. 12 38ASB600DC WIRING DIAGRAM PE740133 FIG. 13 38ASB600DB WIRING DIAGRAM NOTE: FOR OTHER 38ASB WIRING DIAGRAM NOT SHOWN HERE, PLEASE REQUEST COPIES FROM CCAC ENGINEERING DEPARTMENT. - Page 8 TABLE 5 Superheat Charging Table Superheat Charging Table (Superheat Entering Suction Service Valve) (Superheat Entering Suction Service Valve) OUTDOOR OUTDOOR INDOOR COIL ENTERING AIR ( C) WET-BULB INDOOR COIL ENTERING AIR ( F) WET-BULB TEMP ( TEMP ( 11.1 12.2 13.3 14.4 15.6 16.7...
- Page 9 38ASB240BA MATCHED WITH 42PGA026 38ASB240BA MATCHED WITH 42AR024 / 42GX024 38ASB360BA MATCHED WITH 42AR036 / 42GX040 FIG. 14 SCHEMATIC SYSTEM WIRING DIAGRAM...
- Page 10 38ASB240BA MATCHED WITH 40GKX / KMC024 38ASB360BA MATCHED WITH ASBFM360BA 38ASB360BA MATCHED WITH 40GKX / KMC036 FIG. 15 SCHEMATIC SYSTEM WIRING DIAGRAM...
- Page 11 38ASB360BA MATCHED WITH 40LX040 38ASB600DC MATCHED WITH 42AR / 42GX060 FIG. 16 SCHEMATIC SYSTEM WIRING DIAGRAM...
- Page 12 38ASB600DB MATCHED WITH 40LX060 38ASB600DC MATCHED WITH 40GKX / KMC060...
- Page 13 38ASB600DC MATCHED WITH ASBFE600BA...
-
Page 14: Trouble-Shooting Guide
TROUBLE-SHOOTING CHART – COOLING CYCLE NO COOLING OR IN-SUFFICIENT COOLING COMPRESSOR RUNS COMPRESSOR RUNS COMPRESSOR BUT CYCLES ON BUT INSUFFICIENT WILL NOT RUN INTERNAL OVERLOAD COOLING OUTDOOR FAN LOW SUCTION HIGH SUCTION HIGH SUCTION LOOSE LEAD AT CONTACTOR STOPPED OR CYLING CONTACTOR OPEN PRESSURE LOW HEAD... - Page 15 Concepcion Carrier Air conditioning Company Philippines Concepcion Carrier Air Conditioning Company Km. 20 East Service Road, South Superhighway, Alabang, Muntinlupa City Tel. No. (63)2 850 1367 Fax No. (63)2 809 9979 www.carrier.com.ph Website: Manufacturer reserve the right to discontinue, or charge at any time, specifications or designs without notice and without incurring obligations...