Sealey SSA2 Instructions

thank you for purchasing a sealey product. Manufactured to a high standard this product will, if used according to these instructions
and properly maintained, give you years of trouble free performance.
IMPORTANT: BEFORE USING THIS PROdUCT, PLEASE REAd THE INSTRUCTIONS CAREFULLY. MAKE CAREFUL NOTE OF SAFETY
INSTRUCTIONS, WARNINGS ANd CAUTIONS. THIS PROdUCT SHOULd ONLY BE USEd FOR ITS INTENdEd PURPOSE. FAILURE TO dO
SO MAY CAUSE dAMAGE ANd/OR PERSONAL INJURY ANd WILL INVALIdATE THE WARRANTY. RETAIN THESE INSTRUCTIONS FOR
FUTURE USE.
1. SAFETY INSTRUCTIONS
1.1 GENERAL SAFETY
only use the sprayer for its intended purpose.

Familiarise yourself with the applications, limitations, and

potential hazards of this product.
use original sealey spare parts only. unauthorised parts may

be dangerous and will invalidate the warranty.
Ensure containers cannot easily be knocked over during

filling.
Always ensure good contact on the 12V battery.

Mark fluid containers with hazard labels to show their

contents.
Keep any fluid containers in a well ventilated, lockable store,

preferably outside the working area.
Keep children and unauthorised persons away from the

working area, especially when the sprayer is in operation.
Keep the work area childproof by using padlocks and master

switches.
Maintain the sprayer in top condition. Keep it clean for best

and safest performance.
Follow the same precautions when transferring fluid from the

sprayer back into other containers.
Ensure the sprayer is securely fixed to the AtV.

Always inspect and prepare the sprayer before use according

to the directions provided in this manual.
Keep the sprayer turned off. Do not turn on power to the

sprayer until ready to spray in order to avoid unintentional
spray release.
never spray when wind speed exceeds 4mph in order to

minimize spray drift.
dO NOT over apply pesticide. Apply at a rate

recommended by agents manufacturer. Excess pesticide
can be dangerous to humans, damage desirable plants, and
contaminate soil and water sources.
never point the spray gun at people or animals.

dO NOT eat, drink, rub your eyes, or touch any part of your

bare skin while handling agents and spraying.
dO NOT spray near open flames or sources of heat.

Always clean up spills immediately per instructions

on the agents label.
turn off vehicle and set brake or block wheels, turn

off power to sprayer, and relieve system pressure before
leaving sprayer unattended.
dO NOT use an open flame or smoke anywhere near the

sprayer or around stored fluid.
dO NOT spray fluid into dedicated workshop oil spray

equipment.
dO NOT use any electrical equipment on or near the vehicle

while fluid spraying is in progress. this includes the use of
inspection lights, mobile phones or pagers.
dO NOT use the sprayer if the pump is damaged in any way.

dO NOT use whilst under the influence of drugs, alcohol or

other intoxicating medication, or if you are fatigued.
1.2 ELECTRICAL CONNECTION SAFETY
If the battery terminals are corroded or dirty, clean them

before using the tester.
Disconnect the power after every use to avoid accidental

starting.
dO NOT disassemble the remote switch for any reason. the

tester must only be checked by qualified service personnel.
WARNING! To prevent the risk of sparking, short circuit and

possible explosion DO NOT drop metal tools in the battery
area, or allow them to touch the battery terminals.
dO NOT cross-connect remote switch clamps. Ensure

positive (rED) clamp is to positive terminal and negative
(bLAcK) clamp is to negative terminal.
1.3 CHEMICAL SAFETY
1.3.1 First and foremost ensure you read the safety data sheet
of the substance you are going to spray.
1.3.2 the sprayer is intended for use in spraying agricultural
pesticides and other non-flammable liquids.
1.3.3 spraying pesticides - Pesticides are hazardous agents that
must be handled with caution as directed throughout this
manual and on the pesticide label. the sprayer is intended
for use in spraying pesticides in liquid form only. the sprayer
is not intended for use in spraying pesticides in dry or in
aerosol form, or for use with fumigants.
sprayers ss60 and ss98 come equipped with a spot spray
gun and a tank-mounted broadcast spraying system. use the
spot spray gun if you desire to apply pesticide only on
selected plants. use the broadcast spraying system if you
wish to spray large ground areas
1.3.4 spraying other Liquids - In addition to spraying pesticides,
this sprayer may be used to spray other non-flammable
liquids. Example uses include: watering plants/trees or
spraying water for dust control, applying ice control
agents, applying water-based, non-flammable sealant
or stain to outdoor wood surfaces.
1.3.5 However, WE rEcoMMEnD tHAt tHE sPrAYEr not bE
usED For otHEr PurPosEs oncE It HAs ALrEADY
bEEn usED For sPrAYInG PEstIcIDEs. Any agents
will leave some residual in the tank liner or sprayer
components, even after the sprayer has been properly
cleaned. these residual agents can have unexpected
effects on future uses. For example, spraying water or
other liquids that are contaminated with residual pesticide
may result in unforeseen hazards to plant or animal life.
2. INTROdUCTION
single broadcast lance provides a wide 4.3mtr spray pattern.
suitable for use with sealey Model no. ss37. supplied with polyvinyl
hose and all mounting equipment. Also suitable as replacement
broadcast nozzle for sealey Model no's. ss60 and ss98.
NOTE! When used with SS37, this broadcast lance replaces the
spot spraying function.
Original Language Version
InstructIons For:
BROAdCAST LANCE
SSA2
MoDEL n :
o
.
ssA2 Issue:2(P)- 18/07/13