Harbor Freight Tools PacificHydrostar 68387 Manual

Harbor Freight Tools PacificHydrostar 68387 Manual

Shallow well pump

Advertisement

Shallow Well Pump
68387
1 HP Stainless Steel Shallow Well Pump
68388 3/4 HP Cast Iron Shallow Well Pump
Read this material before using this product.
Failure to do so can result in serious injury.
SAVE THIS MANUAL.
When unpacking, make sure that the product is intact and undamaged.
If any parts are missing or broken, please call 1-800-444-3353 as soon as possible.
©
Copyright
2011 by Harbor Freight Tools
or form without the express written consent of Harbor Freight Tools. Diagrams within this manual may not be drawn proportionally. Due to continuing
improvements, actual product may differ slightly from the product described herein. Tools required for assembly and service may not be included.
Brought to You by www.snapwhole.com
Visit our website at: http://www.harborfreight.com
®
. All rights reserved. No portion of this manual or any artwork contained herein may be reproduced in any shape

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the PacificHydrostar 68387 and is the answer not in the manual?

Questions and answers

Summary of Contents for Harbor Freight Tools PacificHydrostar 68387

  • Page 1 . All rights reserved. No portion of this manual or any artwork contained herein may be reproduced in any shape or form without the express written consent of Harbor Freight Tools. Diagrams within this manual may not be drawn proportionally. Due to continuing...
  • Page 2: Fluid Type

    5. Circulation of caustic fluids, as well as the circulation intact and undamaged. If any parts are missing of abrasive materials, must be avoided at all costs. or broken, please call Harbor Freight Tools at 1-800-444-3353 as soon as possible. 6. The pump must be protected from frost.
  • Page 3: Power Supply

    Brought to You by www.snapwhole.com Discharge Installation Priming Inlet Intake The well motor pump must be installed in a stationary Pressure position with a fixed pipeline and a steady water supply. Gauge Please note! 1. Do not install the pump by suspending it unsupported from its delivery pipe.
  • Page 4 Brought to You by www.snapwhole.com 1. The illustration below shows an example of a proper 3. Install a sterile Well Seal at the top of the suction shallow well pump installation. The total suction lift pipe to keep the well clean. Protect from (vertical well lift + length of off-set line) must rust inside a frost-proof enclosure.
  • Page 5 Brought to You by www.snapwhole.com 4. This is a self-starting pump that uses Operation a pressure switch. Once the power cord is connected, the pump can start at any time. Do not handle or perform maintenance on 1. Compression Tank has a rubber bladder inside. the pump if the power cord is plugged in.
  • Page 6: Troubleshooting

    Brought to You by www.snapwhole.com 2. Wipe the pump clean with a soft, damp cloth Maintenance with soapy water. Do not use solvents. Do not get the electrical components wet. 3. Drain water from pump before storage by disconnecting the water lines and turning the Pump TO PREVENT SERIOUS INJURY FROM upside down.
  • Page 7: Please Read The Following Carefully

    Brought to You by www.snapwhole.com Problem Cause Solution Water is full of 1. Pumping bubbles temporarily as 1. Temporary self-remedying issue. bubbles at outlet air is purged after initial setup. 2. Leak in suction side of pump system. 2. Check for and fix leaks. 3.
  • Page 8 Brought to You by www.snapwhole.com 68387 Wiring Diagram Motor Capacitor Pressure Switch GROUND LINE 68387 Parts List Part Description Qty. Part Description Qty. Flexible Hose Connection Box Base Power Cable Fixture Pressure Switch Screw 5-way Connector Screw Shipping Plug Connection Box Top Pressure Gauge Screw Pump Wire...
  • Page 9 Brought to You by www.snapwhole.com 68387 Assembly Diagram SKU 68387 & 68388 For technical questions, please call 1-800-444-3353. Page 9...
  • Page 10 Brought to You by www.snapwhole.com 68388 Wiring Diagram GROUND Capacitor LINE Pressure Switch Motor 68388 Parts List Part Description Qty. Part Description Qty. Pump Housing Screw Screw Spring Washer Flat Washer Flat Washer Spring Washer Connection Box Cover Priming Plug Screw Shipping Plug O-ring...
  • Page 11 Brought to You by www.snapwhole.com 68388 Assembly Diagram SKU 68387 & 68388 For technical questions, please call 1-800-444-3353. Page 11...
  • Page 12: Limited 90-Day Warranty

    Proof of purchase date and an explanation of the complaint must accompany the merchandise. Harbor Freight Tools Co. makes every effort to assure If our inspection verifies the defect, we will either repair that its products meet high quality and durability...

This manual is also suitable for:

Pacifichydrostar 68388

Table of Contents