Sony Trinitron KV-32FQ85B Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. TV
  5. Trinitron KV-32FQ85B
  6. Service manual
Sony Trinitron KV-32FQ85B Service Manual

Sony Trinitron KV-32FQ85B Service Manual

Ae-6bad/y chassis
Hide thumbs Also See for Trinitron KV-32FQ85B:
Table of Contents

Advertisement

Quick Links

Download this manual
SERVICE MANUAL
MODEL
KV-32FQ85B
COMMANDER
DEST
CHASSIS NO.
RM-942
FR
SCC-Q83R-A
AE-6BAD/Y
MODEL
KV-32FQ85E
KV-32FQ85
- 1 -
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-942
ESP
SCC-Q81U-A
RM-942

Advertisement

Table of Contents
loading

Related Manuals for Sony Trinitron KV-32FQ85B

Summary of Contents for Sony Trinitron KV-32FQ85B

  • Page 1 AE-6BAD/Y SERVICE MANUAL CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KV-32FQ85B KV-32FQ85E RM-942 SCC-Q83R-A RM-942 SCC-Q81U-A KV-32FQ85 RM-942 - 1 -...

  • Page 2: Table Of Contents

    PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE TANCE CRITIQUE POUR LA SÈCURITÈ DU FONCTIONNEMENT, NE LES REMPLACER QUE PAR DES COMPSANTS SONY DONT THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN LE NUMÈRO DE PIÈCE EST INDIQUÈ...
  • Page 3 Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
  • Page 4 l l a . s l . s l . s l . s l . s l e i l . s l t c i n i l i n i y t i - 4 -...
  • Page 5 21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left) Output impedence : Less than 1kohm*...
  • Page 6 AE-6BAD/Y SELF DIAGNOSTIC SOFTWARE The identification of errors within the AE-6BAD/Y chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.

  • Page 7: General

    SECTION 1 GENERAL - 7 -...
  • Page 8 - 8 -...
  • Page 9 - 9 -...
  • Page 10 - 10 -...
  • Page 11 - 11 -...
  • Page 12 - 12 -...

  • Page 13: Disassembly

    SECTION 2 DISASSEMBLY 2-1. Rear Cover Removal 2-2. Speaker Connector Disconnection => => => => Remove the rear cover fixing screws indicated and pull the Before completely removing the rear cover disconnect the rear cover backwards away from the set. Take care when speaker connector which is located on the inside of the set.

  • Page 14: Service Position

    2-4. Service Position 2-5. G Board Removal Clips To remove the G Board remove the two screws from the To place the chassis in the service position, insert the main middle of the board, release the clips circled and ease the bracket firmly into the T-slot located on the left corner of the board gently away from the support bracket.

  • Page 15: Picture Tube Removal

    2-8. Picture Tube Removal WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap.
  • Page 16 - 16 -...

  • Page 17: Set-Up Adjustments

    SECTION 3 SET-UP ADJUSTMENTS • When complete readjustment is necessary or a new picture tube Carry out the adjustments in the following order : is installed, carry out the following adjustments. 3-1. Beam Landing. • Unless there are specific instructions to the contrary, carry out 3-2.

  • Page 18: Convergence

    Fig.3-4 Align both Purity Purity magnets Purity control magnets magnets to the vertical position Align pips on each magnet 3-2. Convergence (1) Screen centre convergence [Static convergence] Input a dot pattern signal from the pattern generator. Normalize the picture setting. [Moving vertically], adjust the V.STAT magnet so that the vertical red, green and blue dots coincide at the centre of the screen.
  • Page 19 Correction for HMC [Horizontal mis-convergence] and VMC HTIL correction can be performed by adding a THL correction [Vertical mis-convergence] by using the BMC [Hexapole] assembly to the Deflection yoke. magnet. a). HMC correction by BMC [Hexapole] magnet and movement of the electron beam.

  • Page 20: Focus Adjustment

    Layout of each control 3-3. Focus Adjustment Receive a television broadcast signal. Normalize the picture setting. Purity magnet Adjust the focus control located on the flyback transformer to BMC (Hexaploe) magnet obtain the best focus at the centre of the screen. V STAT convergence magnet Bring only the centre area of the screen into focus, the magenta- Y-splitting axis correction magnet...

  • Page 21: Circuit Adjustments

    SECTION 4 CIRCUIT ADJUSTMENTS 4-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-942. Programming the Remote Commander for Operation in Service Mode Press and hold the left Mode Select button until the VCR and DVD LED’s flash. Press 99999.
  • Page 22 Sub Brightness Adjustment Input a Monoscope pattern. Program the Remote Commander for operation in Service Mode. [ See Page 21 ]. Press ‘AUX/VIDEO’ ‘AUX/VIDEO’ 13 on the Remote Commander. Adjust the ‘Sub-Brightness’ data so that there is barely a difference between the 0 IRE and 10 IRE signal levels. Sub Contrast Adjustment Input a video signal that contains a small 100% white area on a black background.

  • Page 23: Test Mode

    Sub Colour Adjustment 4-2. TEST MODE 2: Receive a PAL colour bar signal. Test Mode 2 is available by programming the Remote Commander for Connect an oscilloscope to Pin 5 of CN7331 [C Board]. operation in Service Mode [ As shown on Page 21 ] then pressing the Program the Remote Commander for operation in Service Mode.

  • Page 24: Block Diagrams

    5-1. BLOCK DIAGRAMS (1) PCI_AD(16) PCI CBE(0) MM_A(0) MM_A(9) PCI AD(0) MM_A09 PCI AD00 PCI_AD(15) PCI CBE(1) CN3601 IC3600 MM_A(1) MM_A(7) PCI AD(1) MM_A07 PCI AD01 RIGHT OUT AUDIO/VIDEO SWITCH PCI_AD(14) PCI_AD(17) BUFFER MM_A(2) MM_A(4) PCI AD(2) V-OUT-35 V-OUT-3B MM_A04 PCI AD02 RIGHT IN V-OUT-15...

  • Page 25: Block Diagrams

    5-1. BLOCK DIAGRAMS (2) CN3100 KEY 2 B 1/2 ( BACKEND,SCANRATE, IR-DATA LVDS,A_INTERFACE LUMISPONDER EPG MODE OCP-OVP OCP-FLAG MAIN-SW DG SW KEY 1 IC3400 BACKEND VIDEO SIRCS CN3400 H TRAP R OUT BUFFER BUFFER AMP HV PROT PWM3 Q5503 Q3400, Q3403 IC0001 B 2/2 ( G OUT...
  • Page 26 5-1. BLOCK DIAGRAMS (3) CN8203 DQP-DRV TO A BOARD CN8206 Q8508 CN3008 Q8512 DQP-V-COMP TO VM BOARD CN9401 IC8527 IC8103 COMPARATOR Q8118, Q8201, Q8202, Q8127 CN8805 DY ASSY MP PARA CN8211 CN2912 V- DY+ HP R H LIN PARA V- DY- J2901 V DY HP R...

  • Page 27: Block Diagrams

    5-1. BLOCK DIAGRAMS (4) TUNER 5-2. CIRCUIT BOARD LOCATION Reference Information TU1100 IC2000 AGC DEFEAT SWITCH SOUND IC2200 FROM B BOARD Q1100 PROCESSOR AUDIO AMP J2200 CONNECTOR REAR-R SPEAKERS RESISTOR : METAL FILM REAR-L IC2400 FM/AM C Board AUDIO AMP WOOFER : SOLID CN2400 WOOFER SP...
  • Page 28 ~ A Board Waveforms ~ 20us/div 5ms/div 700 mVp-p (V) 56 Vp-p (V) ~ A Board Location Table (A Side) ~ ~ A Board Location Table (B Side) ~ - 28 -...
  • Page 29 ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ ~ A Board Difference Table ~ - 29 -...

  • Page 30: A Board Schematic

    AUDIO AMPLIFIER 10000PF 0.47 0.47 TO J BOARD CN3604 AV LINK CONVERTER ~ A Board Schematic Diagram [ Audio, Deflection J Interface ] Page 1/3 ~ - 30 -...
  • Page 31 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL F1101 10UH TAB(CONTACT) 1.8 VOLT REGULATOR 150K ~ A Board Schematic Diagram [ Tuner, Regulators ] Page 2/3 ~ - 31 -...
  • Page 32 SCL CONVERTER SCL CONVERTER ~ A Board Schematic Diagram [ B Interface ] Page 3/3 ~ - 32 -...
  • Page 33 ~ A Printed Wiring Board Conductor side A ~ - 33 -...
  • Page 34 ~ A Printed Wiring Board Conductor side B ~ - 34 -...

  • Page 35: B Board Schematic

    B-#SSAE6B<...>-B..-32FQ85 COMB FILTER MEMORY 3D COMB FILTER CHROMA DECODER ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 1/3 ~ - 35 -...
  • Page 36 SCAN CONVERTER VIDEO PROCESSING BACKEND 150K ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 2/3 ~ - 36 -...
  • Page 37 RESET 3.3K AC ON/OFF RESET SDRAM MICRO M27V160-100K1-6BA001 ~ B Board Schematic Diagram [ Backend,Scanrate,LVDS,A_Interface ] Page 3/3 ~ - 37 -...
  • Page 38 ~ B Printed Wiring Board Conductor side A ~ ~ B Printed Wiring Board Conductor side B ~ - 38 -...

  • Page 39: F1 Board Schematic

    ~ F1 Board Schematic Diagram [ Power Switch, Fuse, SIRCS and Stand-By LED ] ~ ~ H1 Board Schematic Diagram [ Front AV Input, Headphone and Control Switches ] ~ F1.-32FQ85 TO J BOARD TO A BOARD CN3600 CN2300 POWER SWITCH, FUSE, SIRCS &...
  • Page 40 ~ G Board Semiconductor Location Table ~ ~ G Printed Wiring Board Conductor side ~ ~ H1 Printed Wiring Board Conductor side ~ Note : Portions of the circuit contained within the marked areas as shown have high voltages present. Use care to prevent electric shock during inspection or repair.

  • Page 41: G Board Schematic

    OVER CURRENT PROTECTION CONTROL IC SW MOSFET SW MOSFET SWITCH ~ G Board Schematic Diagram [ Power Supply ] ~ - 41 -...

  • Page 42: C Board Schematic

    C..-32FQ85 R7337 IC7300 CN7333 1/2W R7309 TDA6118JF RED VIDEO OUT FV FOCUS C7334 R7334 250V 1/4W C7305 R7301 C7306 1/10W 1000p D7300 1SS83TA R7340 R7306 J7330 C7303 2.7k R7305 R7308 1/10W Q7301 R7307 MSD601-RST1 1/2W Q7300 BUFFER BF550 D7302 D7301 D7303 1SS133 1SS83TA...
  • Page 43 ~ C Board Waveforms ~ ~ C Printed Wiring Board Conductor side ~ 10us/div 10us/div ~ J Printed Wiring Board Conductor side A ~ 3.0 Vp-p (H) 3.0 Vp-p (H) 10us/div 10us/div 100 Vp-p (H) 3.0 Vp-p (H) 10us/div 10us/div 95 Vp-p (H) 95 Vp-p (H) 20us/div...

  • Page 44: J Board Schematic

    J..-32FQ85 C2610 L3614 R3653 C3642 AUDIO R OUT SC1-OUT-R 1/10W C3645 R2608 R3654 R2600 C2604 R2604 D2600 470k C2608 Q3656 0.022 UDZS-TE17-9.1B 1/10W 1/10W MSD601-RST1 1/10W 1/10W AUDIO R IN BUFFER SC1-IN-R R3652 C2601 R2601 C2605 R2605 R2609 C2611 D2601 1/10W 470k 1000p...

  • Page 45: Ms Board Schematic

    MS.-32FQ85 +3V3_TM PCI_AD[0-21,23-31] VO_DATA[0-7] 9 RB21 +3V3 +3V3 +AC_DROP PCI_CBE[0-1] PCI_CBE[0-1] TRIMEDIA MEMORY STICK R489 100uH 1/10W IC12 FL002 SN74LV00APWR ADRESS DECODER MM_A[0-13] PCI_INTA MM_A[0-13] C112 ADR23 +3V3 D029 VO_IO19 6.3V UDZS-TE17-9.1B R400 +2V5_TM D028 PCI_INTB +2V5 100uH C111 MM_DQ[0-15] 1/10W MM_DQ[0-15] UDZS-TE17-9.1B...
  • Page 46 MS.-32FQ85 TM1300:VSSQ AND VDDQ +3V3 +2V5_TM COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL +3V3 10uH 0.01 R173 R176 R494 1/10W 1/10W R148 10uH MM_WE R493 33.333MHz MM_CAS STANDBY MM_RAS R175 TMCLK 3 IC140 R149 C141 1/10W R231 +3V3 1/10W 32MByte Default...
  • Page 47 MS.-32FQ85 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL 120p UDZSTE-173.9B V_R_CVBS 2.7uH R104 R124 R125 R106 2.7uH 560p 390p R131 R132 R133 R134 CHIP 1/10W R135 R130 R115 1/10W R177 R178 120p R103 VIDEO OUTPUT R179 1/10W 2.7uH UDZSTE-173.9B R102...
  • Page 48 ~ MS Printed Wiring Board Conductor side A ~ ~ MS Printed Wiring Board Conductor side B ~ ~ D2 Printed Wiring Board Conductor side ~ - 48 -...

  • Page 49: D2 Board Schematic

    B-#SSAE6B<...>-D2.-32FQ85 DYNAMIC FOCUS DRIVER 0.33 SWITCH DTZ-5.1B PROTECTION IC ~ D2 Board Schematic Diagram [ Smart Mode Deflection ] ~ - 49 -...
  • Page 50 ~ D Printed Wiring Board Conductor side ~ ~ D Board Waveforms ~ ~ D Board IC Voltage Table ~ ~ D Board Semiconductor Voltage Table ~ 10us/div 10us/div 10us/div 10us/div 10us/div 1.5 Vp-p (H) 130 Vp-p (H) 1.4 Vp-p (H) 140 Vp-p (H) 455 Vp-p (H) TP10...

  • Page 51: D Board Schematic

    PIN OUT 250V H OUT HLINERAITY MIDPIN OUT TP10 470K ~ D Board Schematic Diagram [ Deflection ] ~ - 51 -...

  • Page 52: Semiconductors

    5-4. SEMICONDUCTORS RD15ES-B2 BYV98-200-RAS 15/12 L7809CV/LSY CATHODE 1SS133T-77 RD39ES-B2 STP5NK40Z(033Y) 1SS83 RD3.6ES-B2 ST2310DHI D1NL20U RD5.6ESB2 D1NL20U-TR RK14V1 ANODE D1NL40-TA2 EL1Z CATHODE ERA22-08 CA0005AD GP08D LA6393DLL FUF4005 LA6500-FA HZS9.1NB2 MTZJ-33B ANODE MTZJ-4.7C 1PS184-115 CXA2019AQ-TL MM3Z4V7T1 CXA2149AQ-TL MM3Z6V8T1 MM3Z9V1ST1 MM3Z15VT1 MMDL914T1 ANODE UDZSTE-1713B LM393DT UDZSTE-1718B...
  • Page 53 UPC1093J-1-T PQ1CG2032FZ CATHODE ANODE VSP9417BC3G PST9143NL 1 2 3 4 5 SE135N-LF4 (TOP VIEW) SENSE 2 COLLECTOR 3 GND STV9379 TDA7482 TDA7269 TLHK5190 CATHODE ANODE TL1431CZ-AP - 53 -...
  • Page 54 5-5. IC BLOCK DIAGRAMS A BOARD IC5400 STV9379A FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION G BOARD IC6001 MCZ3001D Remote DVLD Internal Driver Sel=34v ref 5v Reg. 10v 15v/8v Level Shift Vsense Control Logic Latch Centre Timer A BOARD IC6210 BA033T REFERENCE VOLTAGE - 54 -...
  • Page 55 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC6003 SE135N-LF4 - 55 -...

  • Page 56: Exploded Views

    SECTION 6 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these items.

  • Page 57: Picture Tube

    6-2. PICTURE TUBE REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK - 57 -...

  • Page 58: Electrical Parts List

    SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page G BOARD COMPLETE Parts List : ....................59 D BOARD COMPLETE Parts List : ....................60 B BOARD COMPLETE Parts List : ....................63 D2 BOARD COMPLETE Parts List : ....................
  • Page 59 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK *A-1302-334-A G Board, Complete CN6006 *1-564-510-11 PLUG, CONNECTOR 7P CN6007 1-817-917-11 HEADER ASSEMBLY FOR PCB 4-382-854-01 SCREW (M3X8), P, SW (+) CN6008 *1-816-977-51 PLUG, CONNECTOR 6P CN6012 *1-564-510-11 PLUG, CONNECTOR 7P < CAPACITOR > <...
  • Page 60 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q6005 8-729-901-06 TRANSISTOR DTA144EK < RELAY > Q6006 6-550-698-01 TRANSISTOR SPA08N50C3-E8152 Q6007 6-550-698-01 TRANSISTOR SPA08N50C3-E8152 RY6001 £ 1-755-388-11 RELAY (AC POWER) Q6010 8-729-010-29 TRANSISTOR MSD601-RST1 RY6002 £ 1-755-388-11 RELAY (AC POWER) Q6102 8-729-010-29 TRANSISTOR MSD601-RST1 <...
  • Page 61 D1 D REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8134 1-102-935-00 CERAMIC 0.25PF 50V < DIODE > C8135 1-126-947-11 ELECT 47UF 20.00% 35V C8136 1-126-964-11 ELECT 10UF 20.00% 50V D8101 8-719-110-41 DIODE RD15ESB2 C8138 1-102-030-00 CERAMIC 330PF 10.00% 500V D8102 8-719-081-97 DIODE MMDL914T1...
  • Page 62 F4 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q8102 8-729-010-29 TRANSISTOR MSD601-RST1 R8111 1-216-825-11 METAL CHIP 2.2K 5% 1/10W Q8103 8-729-010-29 TRANSISTOR MSD601-RST1 R8112 1-216-825-11 METAL CHIP 2.2K 5% 1/10W Q8104 8-729-010-29 TRANSISTOR MSD601-RST1 R8113 1-216-833-11 METAL CHIP 1/10W Q8105 8-729-010-29...
  • Page 63 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8162 1-216-821-11 METAL CHIP 1/10W R8541 1-218-863-11 METAL CHIP 4.7K 0.5% 1/10W R8163 1-216-833-11 METAL CHIP 1/10W R8542 1-216-841-11 METAL CHIP 1/10W R8165 1-218-889-11 METAL CHIP 0.5% 1/10W R8543 1-216-833-11 METAL CHIP 1/10W R8166 1-247-807-31...
  • Page 64 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C0026 1-126-947-11 ELECT 47UF 20.00% 35V C3138 1-164-156-11 CERAMIC CHIP 0.1UF C0028 1-164-156-11 CERAMIC CHIP 0.1UF C3139 1-164-156-11 CERAMIC CHIP 0.1UF C0029 1-164-156-11 CERAMIC CHIP 0.1UF C3140 1-164-156-11 CERAMIC CHIP 0.1UF C0032 1-164-156-11 CERAMIC CHIP 0.1UF C3141...
  • Page 65 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3431 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3845 1-126-947-11 ELECT 47UF 20.00% 35V C3432 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3846 1-126-959-11 ELECT 0.47UF 20.00% 50V C3433 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3847 1-164-156-11 CERAMIC CHIP 0.1UF...
  • Page 66 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D0071 8-719-081-97 DIODE MMDL914T1 L3802 1-414-928-21 INDUCTOR D5500 8-719-069-55 DIODE UDZSTE-175.6B L3803 1-414-928-21 INDUCTOR D5501 8-719-083-57 DIODE UDZSTE-173.6B L3805 1-414-928-21 INDUCTOR D5502 6-500-028-01 DIODE MM3Z9V1ST1 L3806 1-414-928-21 INDUCTOR D5504 8-719-081-97 DIODE MMDL914T1 L3807 1-414-928-21 INDUCTOR...
  • Page 67 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK JR0008 1-216-864-11 SHORT CHIP R0046 1-216-833-11 METAL CHIP 1/10W JR0010 1-216-864-11 SHORT CHIP R0047 1-216-809-11 METAL CHIP 1/10W JR0011 1-216-864-11 SHORT CHIP R0048 1-216-809-11 METAL CHIP 1/10W JR3400 1-216-864-11 SHORT CHIP R0049 1-216-809-11 METAL CHIP 1/10W...
  • Page 68 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3113 1-216-809-11 METAL CHIP 1/10W R3438 1-216-864-11 SHORT CHIP R3114 1-216-864-11 SHORT CHIP R3442 1-216-864-11 SHORT CHIP R3115 1-216-864-11 SHORT CHIP R3443 1-218-847-11 METAL CHIP 0.5% 1/10W R3117 1-216-864-11 SHORT CHIP R3444 1-216-809-11 METAL CHIP 1/10W...
  • Page 69 H5 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3854 1-216-821-11 METAL CHIP 1/10W R5532 1-216-821-11 METAL CHIP 1/10W R3855 1-218-839-11 METAL CHIP 0.5% 1/10W R5539 1-218-879-11 METAL CHIP 0.5% 1/10W R3856 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5541 1-216-864-11 SHORT CHIP R3857...
  • Page 70 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK RB3803 1-239-621-11 NETWORK RESISTOR (CHIP) 22 C6832 1-162-966-11 CERAMIC CHIP 0.0022UF 10.00% 50V C6833 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V RB3804 1-239-621-11 NETWORK RESISTOR (CHIP) 22 RB3805 1-239-621-11 NETWORK RESISTOR (CHIP) 22 C6834 1-126-964-11 ELECT...
  • Page 71 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < IC > R6817 1-249-393-11 CARBON 1/4W R6818 1-216-803-11 METAL CHIP 1/10W IC6800 8-759-586-17 IC TL1431CZ-AP R6819 1-218-823-11 METAL CHIP 0.5% 1/10W IC6801 8-759-700-07 IC NJM2903M R6820 1-216-833-11 METAL CHIP 1/10W IC6802 6-703-355-01 IC MCZ3001DA R6821...
  • Page 72 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6879 1-215-447-00 METAL 1/4W C2002 1-126-947-11 ELECT 47UF 20.00% 35V R6880 1-215-447-00 METAL 1/4W C2004 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V R6881 1-215-447-00 METAL 1/4W C2005 1-127-715-91 CERAMIC CHIP 0.22UF R6883 1-218-847-11 METAL CHIP 0.5% 1/10W C2006...
  • Page 73 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2407 1-164-505-11 CERAMIC CHIP 2.2UF C5217 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C2408 1-126-963-11 ELECT 4.7UF 20.00% 50V C5218 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C2409 1-115-339-11 CERAMIC CHIP 0.1UF 10.00% 50V C5219 1-126-964-11 ELECT...
  • Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > D6207 8-719-081-97 DIODE MMDL914T1 D6208 8-719-081-97 DIODE MMDL914T1 CN0002 *1-564-507-11 PLUG, CONNECTOR 4P D6209 8-719-081-97 DIODE MMDL914T1 CN2300 *1-564-510-11 PLUG, CONNECTOR 7P D6210 8-719-110-41 DIODE RD15ESB2 CN2301 *1-564-509-11 PLUG, CONNECTOR 6P D6211 8-719-080-59 DIODE EK19-V0...
  • Page 75 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < PROTECTOR MODULE > < RESISTOR > PS2000 £ 1-801-549-21 IC LINK JR3001 1-216-864-11 SHORT CHIP PS2001 £ 1-801-549-21 IC LINK JR3003 1-216-864-11 SHORT CHIP JR3004 1-216-864-11 SHORT CHIP < TRANSISTOR > JR3006 1-216-864-11 SHORT CHIP...
  • Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2006 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2406 1-216-841-11 METAL CHIP 1/10W R2007 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2407 1-216-833-11 METAL CHIP 1/10W R2008 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R2409 1-216-864-11 SHORT CHIP R2022...
  • Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5152 1-249-413-11 CARBON 1/4W R5248 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5153 1-249-393-11 CARBON 1/4W R5249 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R5154 1-216-853-11 METAL CHIP 470K 5% 1/10W R5250 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R5155...
  • Page 78 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6248 1-216-841-11 METAL CHIP 1/10W < RESISTOR > R6249 1-216-841-11 METAL CHIP 1/10W R6250 1-216-841-11 METAL CHIP 1/10W R0901 1-216-864-11 SHORT CHIP R8005 1-216-809-11 METAL CHIP 1/10W R0902 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R8007 1-216-809-11...
  • Page 79 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > JR7313 1-216-864-11 SHORT CHIP JR7323 1-216-864-11 SHORT CHIP CN7330 *1-564-508-11 PLUG, CONNECTOR 5P CN7331 *1-564-512-11 PLUG, CONNECTOR 9P R7300 1-216-821-11 METAL CHIP 1/10W CN7332 1-695-915-11 TAB (CONTACT) R7301 1-216-813-11 METAL CHIP 1/10W CN7333...
  • Page 80 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > C2625 1-165-908-11 CERAMIC CHIP 1UF C2626 1-126-947-11 ELECT 47UF 20.00% 35V CN0981 *1-564-507-11 PLUG, CONNECTOR 4P C2627 1-126-947-11 ELECT 47UF 20.00% 35V CN6400 £ *1-580-843-11 PIN, CONNECTOR (POWER) C2628 1-216-864-11 SHORT CHIP CN6401 £...
  • Page 81 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK CN3603 1-695-549-11 SOCKET, PIN 21P Q2603 8-729-010-29 TRANSISTOR MSD601-RST1 CN3604 1-817-114-11 CONNECTOR, BOARD TO BOARD 35P Q2604 8-729-010-29 TRANSISTOR MSD601-RST1 Q3656 8-729-010-29 TRANSISTOR MSD601-RST1 < DIODE > Q3657 8-729-010-29 TRANSISTOR MSD601-RST1 Q3658 8-729-010-29 TRANSISTOR MSD601-RST1 D0600...
  • Page 82 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2638 1-216-815-11 METAL CHIP 1/10W R3647 1-216-864-11 SHORT CHIP R2639 1-216-049-11 RES-CHIP 1/10W R3652 1-216-821-11 METAL CHIP 1/10W R2640 1-216-813-11 METAL CHIP 1/10W R3653 1-216-841-11 METAL CHIP 1/10W R2642 1-216-813-11 METAL CHIP 1/10W R3654 1-216-837-11...
  • Page 83 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V < CONNECTOR > 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V *1-794-959-21 PIN, CONNECTOR (PWB, PRINT)20P 1-162-928-11 CERAMIC CHIP 120PF 5.00% 50V *1-816-402-12 CONNECTOR, MEMORY STICK 1-164-392-11...
  • Page 84 B1 MS REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < COIL > 1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP 1-469-525-91 INDUCTOR 10UH 1-216-809-11 METAL CHIP 1/10W 1-469-528-91 INDUCTOR 100UH 1-216-809-11 METAL CHIP 1/10W 1-469-525-91 INDUCTOR 10UH R100 1-216-801-11 METAL CHIP 1/10W 1-469-525-91 INDUCTOR...
  • Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R403 1-216-864-11 SHORT CHIP C9402 1-164-156-11 CERAMIC CHIP 0.1UF R405 1-216-864-11 SHORT CHIP C9403 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V R459 1-216-864-11 SHORT CHIP C9404 1-107-636-11 ELECT 10UF 20.00% 160V R460 1-216-805-11 METAL CHIP 1/10W C9406...
  • Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R9412 1-249-393-11 CARBON 1/4W MISCELLANEOUS R9413 1-249-393-11 CARBON 1/4W R9414 1-249-393-11 CARBON 1/4W £ 1-571-433-21 SWITCH, PUSH (AC POWER) R9415 1-249-393-11 CARBON 1/4W £ 1-783-083-11 CORD, POWER (WITH FILTER) R9416 1-249-393-11 CARBON 1/4W 1-424-855-11 COIL, CHOKE 29MMH 8-598-535-20 FRONT END BTF-EF411 (KV-32FQ85B)
  • Page 87 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

This manual is also suitable for:

Trinitron kv-32fq85e

Table of Contents