Related Manuals for BLAUBERG Ventilatoren KOMFORT EC SKE270-1.5
Summary of Contents for BLAUBERG Ventilatoren KOMFORT EC SKE270-1.5
- Page 1 KITCHEN HEAT RECOVERY AIR HANDLING UNIT KOMFORT EC SKE270-1.5 OPERATION MANUAL KOMFORT_EC_SKE270_v2(4)_EN.indd 1 07.08.2015 14:25:40...
-
Page 2: Table Of Contents
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de CONTENTS Introduction General Safety rules Transportation and storage rules Manufacturer's warranty Design Operating logic Delivery set Technical data Mounting Condensate drainage Connection to power mains Unit control Maintenance Troubleshooting and fault handling Acceptance certificate Connection certificate Warranty card KOMFORT_EC_SKE270_v2(4)_EN.indd 2... -
Page 3: Introduction
BLAUBERG Ventilatoren GmbH Company is happy to offer your attention equipment to prevent back drafting. The maximum permitted pressure a new heat recovery air handling unit KOMFORT EC SKE270-1.5 with difference per living units is 4 Pa. integrated kitchen hood. -
Page 4: Design
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de DESIGN The double-skinned unit casing is made of polymer-coated steel plates, fan is turned on and the unit reverts to the normal operation mode. If air internally heat- and sound insulated with a 15 mm polypropylene foam layer. -
Page 5: Delivery Set
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de DELIVERY SET Air handling unit - 1 item; Operation manual - 1 item; WARNING Wall-mounted control panel - 1 item; Make sure the unit has no visible transport damages Remote controller - 1 item;... -
Page 6: Mounting
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de MOUNTING WARNING Safety precautions: The unit must be mounted to a rigid and stable structure. Before starting mounting check that the mounting structure has sufficient loading capacity for the unit weight. The unit mounting is allowed only after power cut-off and full stop of the rotating parts. - Page 7 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de CONDENSATE DRAIN The drain pan is equipped with a drain pipe for condensate removal U-trap always filled with water. Provide free drainage for the condensed outside the unit. water, otherwise it is accumulated inside the unit which may result in the Connect the drain pipe, the U-trap (not included into the delivery set) and equipment damage and condensate outflow to the room.
-
Page 8: Connection To Power Mains
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de CONNECTION TO POWER MAINS WARNING Read the operation manual prior to any electric installations. Connection of the unit to power mains is allowed by a qualified electrician only. The rated electrical parameter are stated on the rating plate. No modifications of internal connections are allowed and will result in void warranty. -
Page 9: Unit Control
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de UNIT CONTROL The unit is controlled from the wall-mounted control panel and the remote control, fig. 8. Wall-mounted control panel Remote controller Unit ON/OFF Fan speed UP Heater OFF Heater ON Fan speed DOWN Medium speed ON... - Page 10 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Table 3. Unit control and setup. Function Button/Button combination Indication Unit activation/deactivation Using the remote controller. Fig. 9 Fig. 10 Using the wall-mounted control panel. Speed selection Low speed - 40 m /h, medium speed - 90 m /h, high speed - 270 m Speed setting up from the wall-mounted control panel (low-medium-high).
- Page 11 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Table 3. Unit control and parameter setting (continued) Function Button/Button combination Indication ATTENTION! Changing the unit parameters results in loss of factory settings for the fan power! ATTENTION! The fan power adjustment is possible from the wall-mounted control panel only! Fan speed adjustment The fan power is adjusted during the fan speed setup mode.
- Page 12 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Table 3. Unit control and parameter setting (continued) Function Button/Button combination Indication ATTENTION! The duct temperature sensor may be adjusted from the wall-mounted control panel only when the unit is OFF! Duct temperature sensor set-up. Enter the duct temperature sensor setup mode to edit the supply air temperature downstream of the heater.
- Page 13 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Table 3. Unit control and parameter setting (continued) Function Button/Button combination Indication Scheduled operation. Each week day has four entries that determine the time for switching the unit to a set fan speed as well as the time for the heater activation or deactivation.
-
Page 14: Maintenance
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de TECHNICAL MAINTENANCE WARNING! Cut power supply to the unit off by turning the automatic electric switch QF to OFF position prior to any maintenance operations. Take steps to prevent re-activation of the automatic switch. WARNING! Consider the unit sharp edges! Fulfil maintenance Regular technical supervision and maintenance of the unit are required to ensure the product long service life and non-stop operation. - Page 15 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de 3. Heat exchanger maintenance (once per year). soft cloth or a brush. Cleaning with water, abrasive detergents, sharp object or chemicals is not allowed. The heat exchanger must be regularly cleaned to maintain high heat recovery efficiency even in case of the regular filter cleaning.
-
Page 16: Troubleshooting And Fault Handling
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Remove the four screws and take off the protecting cover. Support the control unit swivel panel with hand while removing the screws that fix the swivel panel of the control unit. Pull the band to remove the heat exchanger from the unit. - Page 17 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de Table 6. Alarm list and troubleshooting Fault Possible reason Troubleshooting Connect the unit to power mains. Troubleshoot the connection No power supply or wrong connection to power mains. error. The fan does not start when the unit is on Jammed motor, soiled impeller blades.
-
Page 18: Acceptance Certificate
KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de ACCEPTANCE CERTIFICATE Kitchen heat recovery air handling unit KOMFORT EC SKE270-1.5 is recognizes as serviceable. The unit complies with the requirements according to the EU norms and directives, to the relevant EU-Low Voltage Equipment Directives, EU-Directives on Electromagnetic Compatibility. - Page 19 KOMFORT EC SKE270-1.5 www.blaubergventilatoren.de NOTES _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________...
- Page 20 KOMFORT EC SKE270-1.5 v.2(4) / EN KOMFORT_EC_SKE270_v2(4)_EN.indd 20 07.08.2015 14:26:07...
Need help?
Do you have a question about the KOMFORT EC SKE270-1.5 and is the answer not in the manual?
Questions and answers