Page 3
4.4.4 Steckverbinder S140 Schirmung und Kabelverlegung Inbetriebnahme System in Betrieb nehmen Hinweise zum Betrieb Einstellverfahren Einstellvorrichtung (nicht bei BTL7-…-S140) Programmiereingänge (nicht bei BTL7-…-S135) Übersicht der Einstellverfahren 6.3.1 Teach-in 6.3.2 Justieren 6.3.3 Online-Setting 6.3.4 Reset Auswahl des Einstellverfahrens Hinweise zum Einstellvorgang www.balluff.com deutsch...
Page 34
Startup Starting up the system Operating notes Calibration procedure Calibration device (not for BTL7-…-S140) Programming inputs (not for BTL7-…-S135) Calibration procedure overview 6.3.1 Teach-in 6.3.2 Adjusting 6.3.3 Online setting 6.3.4 Reset Selecting the calibration procedure Calibration procedure notes www.balluff.com english...
Page 35
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Calibration using teach-in Calibration using adjustment Calibration using online setting Resetting all values (reset) Technical data 11.1 Accuracy 11.2 Ambient conditions 11.3 Supply voltage (external) 11.4 Output 11.5 Input 11.6 Dimensions, weights Accessories...
Page 36
The US patent was awarded in connection with this mandatory type-testing. product. Maximum length: – BTL7-…-A/B/Y/Z-…: 300 mm (500 mm when supported at the end of the rod using slide bush BAM PC-TL-001-D10,4-4 in bore with a diameter of max. 13 mm) Not for BTL7-...-S140 www.balluff.com english...
Page 37
The warnings used here contain various signal words and specifications in the technical data is ensured only when are structured as follows: using original BALLUFF accessories. Use of any other components will void the warranty. SIGNAL WORD Hazard type and source...
Page 38
The transducers with Ø 10.2 mm have an additional thread at the end of the rod to support larger nominal lengths. Calibration device: Additional device for calibrating the transducer (not for BTL7-….-S140). www.balluff.com english...
Page 39
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Construction and function (continued) Function LED display The Micropulse Transducer contains the waveguide which LED 1 LED 2 is protected by an outer stainless steel tube (rod). A magnet is moved along the waveguide. This magnet is connected to the system part whose position is to be determined.
Page 40
Mounting hole 3/4” 16UNF per SAE J475 O-ring 15.3x2.4 10.2 mm At least 13 mm 8 mm At least 11 mm Magnet: Various magnets are available for the BTL7 transducer (see Accessories on page 25). Tab. 4-1: Bore diameter if installed in a hydraulic cylinder www.balluff.com english...
Page 41
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Installation and connection (continued) The sliding element can be screwed on or bonded. Installing the transducer Secure the screws so they cannot be loosened or lost. Select a suitable adhesive. NOTICE! Slide surface Interference in function...
Page 42
BTL7-_1_ _-... BTL7-_5_ _-... 20 to 28 V 10 to 30 V Unassigned leads can be connected to the GND on the controller side but not to the shield. Reference potential for supply voltage and EMC-GND. Tab. 4-3: Connection assignment BTL7...-S115 www.balluff.com english...
Page 43
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Installation and connection (continued) 4.4.3 Connector type S135 S135 -A_10 -G_10 -C_00 -C_70 -E_00 -E_70 0 to 10 V 10 to 10 V 0 to 20 mA 20 to 0 mA 4 to 20 mA 20 to 4 mA 0 V (pin 1) Fig.
Page 44
The bending radius for a fixed cable must be at least five times the cable diameter. Cable length BTL7-A/G Max. 30 m BTL7-C/E Max. 100 m Tab. 4-6: Cable lengths BTL7 Prerequisite: Construction, shielding and routing preclude the effect of any external noise fields. www.balluff.com english...
Page 45
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Startup Starting up the system DANGER Uncontrolled system movement When starting up, if the position measuring system is part of a closed loop system whose parameters have not yet been set, the system may perform uncontrolled movements.
Page 46
New end point depressed (high active). Automatic deactivation! Before If no signals are sent over the programming inputs for approx. 10 min., programming mode After is automatically ended. New measuring length 100% Fig. 6-3: Reading new end point (changing the output gradient) www.balluff.com english...
Page 47
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Calibration procedure (continued) 6.3.2 Adjusting 6.3.3 Online setting The detailed procedure for adjustment is The detailed procedure for online setting is described on page 19 ff. described on page 21. A new start and/or end value is adjusted.
Page 49
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Calibration using teach-in NOTICE! Interference in function LED display Displayed values (example) Teach-in while the system is running may result in malfunctions. Stop the system before performing teach-in. LED1 LED2 At 0 to 10 V At 4 to 20 mA Initial situation: 5.39 V...
Page 50
1 mV or 1 A. If a button is held down longer than 1 s, the step LED green LED 1 and LED 2 flashing green-red in alternation interval is increased. LED flashing green LED 1 and LED 2 flashing red-red in alternation www.balluff.com english...
Page 51
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Calibration using adjustment (continued) Adjust start value LED display Displayed values (example) (see page 19) LED1 LED2 At 0 to 10 V At 4 to 20 mA 4.
Page 52
LED legend: LED not on LED 1 and LED 2 flashing green-red in alternation If a button is held down longer than 1 s, the step interval is increased. LED green LED 1 and LED 2 flashing red-green in alternation www.balluff.com english...
Page 53
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Resetting all values (reset) NOTICE! Interference in function Resetting the values while the system is running may result in malfunctions. Stop the system before performing the reset. The reset function can be used to restore all the settings to the factory settings.
Page 54
: Use in enclosed spaces and up to a height of 2000 m above sea (when installed in hydraulic level. cylinders) Individual specifications as per Balluff factory standard For Ø 8 mm < 250 bar : The transducer must be externally connected via a limitedenergy For Ø 10.2 mm...
Page 55
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Technical data (continued) 11.6 Dimensions, weights Diameter of rod 8 mm or 10.2 mm Nominal length For Ø 8 mm 25 to 1016 mm For Ø 10.2 mm 25 to 7620 mm Weight (depends on Approx.
Page 57
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Accessories (continued) 12.3 Connectors and cables 12.3.2 BKS-S232/S233-PU-_ _, preassembled BKS-S232-PU-_ _ Straight connector, molded, preassembled 12.3.1 BKS-S32/S33M-00, freely configurable M16, 8-pin BKS-S32M-00 Various cable lengths can be ordered, e.g. BKS-S232-PU-05: Cable length 5 m Straight connector, freely configurable M16 per IEC 130-9, 8-pin...
Page 58
Straight connector, freely configurable 10-pin Fig. 12-8: Connector type BKS-S116-PU_ _, outlet Color YE yellow GY grey PK pink Fig. 12-11: Connector type BKS-S140-23-00 RD red GN green BU blue BN brown WH white Tab. 12-1: BKS-S115/116-PU-_ _ pin assignment www.balluff.com english...
Page 59
BTL7-A/C/E/G_ _ _-M_ _ _ _-A/B/Y/Z(8)-S32/S115/S135/S140/KA_ _/FA_ _ Micropulse Transducer - Rod Style Accessories (continued) 12.3.6 Plug-in system, 8-pin The transducer is available with an 8-pin pigtail plug-in system. The plug-in system has two parts: – The M12 contact insert is preassembled to the trans- ducer’s cable –...
Need help?
Do you have a question about the BTL7 Series and is the answer not in the manual?
Questions and answers