Advertisement
E Schaudt GmbH, Elektrotechnik und Apparatebau, Planckstraße 8, 88677 Markdorf, Germany, Tel. +49 7544 9577-0, Fax +49 7544 9577-29, www.schaudt- -gmbh.de
811.573 BA / EN
Instruction Manual
Electrobloc EBL 226 C +OVP
Table of contents
1
1.1
1.2
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3.1
3.2
3.3
3.4
4
4.1
4.2
5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
R
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2
2
2
3
3
3
4
5
7
8
9
10
10
11
Date: 30.09.2009
Advertisement
Table of Contents
Related Manuals for Schaudt EBL 226 C +OVP
Summary of Contents for Schaudt EBL 226 C +OVP
-
Page 1: Table Of Contents
..........E Schaudt GmbH, Elektrotechnik und Apparatebau, Planckstraße 8, 88677 Markdorf, Germany, Tel. +49 7544 9577-0, Fax +49 7544 9577-29, www.schaudt- -gmbh.de 811.573 BA / EN... -
Page 2: Safety Information
Instruction Manual Electrobloc EBL 226 C +OVP Safety Information Meaning of safety symbols DANGER! Failure to heed this warning may result in death or serious injury. WARNING! Failure to heed this warning may result in personal injuries. ATTENTION! Failure to heed this warning may result in damage to the device or connec- ted consumers. -
Page 3: Introduction
The electronic block is operated exclusively through the connected control and switching board IT ... / LT ..Operation of the Electrobloc EBL 226 C +OVP is not required for daily use. Settings only have to be configured once if the battery type is changed (lead acid or lead gel), during initial start-up or when retrofitting accessories (see chapt. -
Page 4: Changing The Battery
Instruction Manual Electrobloc EBL 226 C +OVP Refrigerator control Wastewater tank heating Awning light For further information, see the instruction manual of the DT/LT ... control and switch panel . Step switch The supply to the step is protected by a self-resetting fuse. This is why the step switch may only be activated briefly. -
Page 5: System Faults
If this is not possible, e.g. if you are abroad, you can have the electronic bloc repaired at a specialist workshop. Please note that the warranty will become void if incorrect repair work is carried out. Schaudt GmbH shall not accept liability for any damages resulting from such repairs. - Page 6 Instruction Manual Electrobloc EBL 226 C +OVP Fault Possible cause Remedy Living area battery is not No mains voltage Switch on the automatic charged during 230 V fuse in the vehicle operation (battery voltage (b tt Have the mains voltage...
-
Page 7: Closing Down The System
ATTENTION! Permitted input voltages exceeded. Damage to connected consumers: Do not operate any connected Schaudt solar charge regulator without battery. If the battery is going to be changed or removed, first remove ”+ solar cell” connector on the solar charge regulator. -
Page 8: Application And Functions In Detail
Application and Functions in Detail This device is intended solely for installation in a vehicle. The EBL 226 C +OVP Electroblock is the central energy supply device for all 12 V consumers in the electrical system on board the motorhome/caravan. It is normally located inside a cupboard or storage area and is accessible from the front for fuse changes. -
Page 9: Battery Functions
Instruction Manual Electrobloc EBL 226 C +OVP Flat vehicle fuses protect the various circuits. Exceptions here are the step and the frost protection valve. Protective circuits Excess temperature Overload Short circuit Mains connection 230 V AC ± 10 %, 47 to 63 Hz sinusoidal, protection class I Current-carrying 12 V outputs may be loaded with max. -
Page 10: Additional Functions
Instruction Manual Electrobloc EBL 226 C +OVP If an overload or an insufficiently charged living area battery causes the vol- tage to fall so low that the automatic disconnector is triggered, any non-es- sential consumers should be switched off. If need be, the 12 V supply can begin operation for a short time. To do this, switch on the 12 V main switch on the DT/LT ... -
Page 11: Appendix
Instruction Manual Electrobloc EBL 226 C +OVP Appendix EC Declaration of Conformity Schaudt GmbH hereby confirms that the design of electronic block EBL 226 C +OVP complies with the following relevant regulations: EC-Low Voltage Directive 73/23/EEC as amended on 22.07.93... - Page 12 Instruction Manual Electrobloc EBL 226 C +OVP Fault report In the event of damage, please return the defective device together with the completed fault report to the manufacturer. Device type: _______________________ Article no.: _______________________ Vehicle: Manufacturer: _______________________ Model: _______________________ Own installation?
- Page 13 16 h with lead gel Time Fig. 3 Example of the charge voltage curve with Electroblock EBL 226 C +OVP Main charge with maximum 18 A charging current, electronically limi- ted, up to final charging voltage. Start of charge also for totally dischar- ged batteries.
- Page 14 17 Assembly flaps Connector, DT .../LT ... control and switch panel Starter Living area Battery Negative Battery Fig. 5 Design, electronic block EBL 226 C +OVP (rear) Connection, living area battery Connection, starter battery Connection, earth Date: 30.09.2009 811.573 BA / EN...
- Page 15 Instruction Manual Electrobloc EBL 226 C +OVP Block diagram/connection diagram Molex Minifit SR 2 x Block 1 LAS 1218--- --- 5 Switch between + Auxiliary charging unit 14,3V--- --- 18A lead gel/lead Negative auxiliary charging acid battery S 1218--- --- 2...
- Page 16 Instruction Manual Electrobloc EBL 226 C +OVP (blank page) Date: 30.09.2009 811.573 BA / EN...