Gas Motor Safety - Wallenstein BXC34 Operator's Manual

2�9

GAS MOTOR SAFETY

BEFORE STARTING ENGINE, READ
AND UNDERSTAND THE OPERATING
AND MAINTENANCE INSTRUCTIONS
THAT CAME WITH YOUR ENGINE�
WARNING: DO NOT
1. DO NOT run engine in an enclosed area.
Exhaust gases contain carbon monoxide, an
odourless and deadly poison.
2. DO NOT place hands or feet near moving or
rotating parts.
3. DO NOT store, spill, or use gasoline near an
open flame, or devices such as a stove, fur-
nace, or water heater which use a pilot light or
devices which can create a spark.
4. DO NOT refuel indoors where area is not well
ventilated. Outdoor refuelling is preferred.
5. DO NOT refuel while engine is running. Allow
engine to cool for 5 minutes before refuelling.
Store fuel in approved safety containers.
6. DO NOT remove fuel tank cap while engine
is running.
7. DO NOT operate engine if gasoline is spilled.
Move machine away from the spill and avoid
creating any ignition until gasoline has evapo-
rated.
8. DO NOT smoke while filling fuel tank.
9. DO NOT choke carburettor to stop engine.
Whenever possible, gradually reduce engine
speed before stopping.
10. DO NOT run engine above rated speeds. This
may result in injury.
11. DO NOT tamper with governor springs, gov-
ernor links or other parts which may increase
the governed speed.
12. DO NOT tamper with the engine speed se-
lected by the original equipment manufacturer.
13. DO NOT check for spark with spark plug or
spark plug wire removed.
14. DO NOT crank engine with spark plug re-
moved. If engine is flooded, crank until engine
starts.
15. DO NOT strike flywheel with a hard object or
metal tool as this may cause flywheel to shatter
in operation. Use proper tools to service engine.
16. DO NOT operate engine without a muffler.
Inspect periodically and replace, if necessary.
If engine is equipped with a muffler deflector,
inspect periodically and replace, if necessary
with correct deflector.
17. DO NOT operate engine with an accumulation
of grass, leaves, dirt or other combustible ma-
terials in the muffler area.
18. DO NOT use this engine on any forest covered,
brush covered, or grass covered unimproved
land unless a spark arrester is installed on the
muffler. The arrester must be maintained in
effective working order by the operator. In the
state of California the above is required by law
(Section 4442 of the California Public Resourc-
es Code). Other states may have similar laws.
Federal laws apply on federal land.
19. DO NOT touch hot muffler, cylinder or fins be-
cause contact may cause burns.
20. DO NOT run engine with air cleaner or air
cleaner cover removed.
WARNING: DO
1. ALWAYS DO remove the wire from the spark
plug when servicing the engine or equipment
to prevent accidental starting.
2. DO keep cylinder fins and governor parts free of
grass and other debris which can affect engine
speed.
3. DO examine muffler periodically to be sure it is
functioning effectively. A worn or leaking muffler
should be repaired or replaced as necessary.
4. DO use fresh gasoline. Stale fuel can gum car-
burettor and cause leakage.
5. DO check fuel lines and fittings frequently for
cracks or leaks. Replace if necessary.
6. DO turn off the fuel valve for transport or storage.
13