KTM 990 Super Duke FR Setup Instructions page 11

3 WORK
3.7 Installing the front spoiler
1 0 0 0 1
2 2
3.8 Opening the filler cap
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
Warning
Environmental hazard Improper handling of fuel is a danger to the environment.
–
Do not allow fuel to get into the ground water, the ground, or the sewage system.
–
Position the front spoiler.
–
Mount and tighten screws
Guideline
Screw, front spoiler
1 1
–
Fully tighten screws
B00245-10
–
Lift the cover
Note
Danger of damage Ignition key breakage.
–
To take pressure off of the ignition key, push down on the filler cap. Damaged
ignition keys must be replaced.
–
Turn the ignition key clockwise.
–
Open the filler cap.
B00162-10
with the washer.
1
M6
.
2
of the filler cap and insert the ignition key in the lock.
1
10 Nm Loctite ® 243™
(7.4 lbf ft)
9