Safety Tips - Thermos 461644304 Use And Care Manual

WARNING
For Safe Use Of Your Grill And To Avoid Serious
Injury:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in bottom or back of grill.
• Check burner flames regularly.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch, covered
patio, or under an overhead structure of any kind.
• Do not use charcoal or ceramic briquets in a gas grill.
( Unless briquets are supplied with your grill.)
• Use grill at least 3 ft. from any wall or surface.
10 ft. clearance to objects that can catch fire or sources of
ignition such as pilot lights on water heaters, live electrical
appliances, etc..
• Apartment Dwellers:
Check with management to learn the requirements and fire
codes for using an LP gas grill in your apartment complex. If
allowed, use outside on the ground floor with a three (3) foot
clearance from walls or rails. Do not use on or under
balconies.
• NEVER attempt to light burner with lid closed. A buildup
of non-ignited gas inside a closed grill is hazardous.
• Never operate grill with LP tank out of correct position
specified in assembly instructions.
• Always close LP tank valve and remove coupling nut
before moving LP tank from specified operation
position.

Safety Tips

s
Before opening LP tank valve, check the coupling nut for
tightness.
s
When grill is not in use, turn off all control knobs and LP tank
valve.
s
Never move grill while in operation or still hot.
s
Use long-handled barbecue utensils and oven mitts to avoid
burns and splatters.
s
Maximum load for side shelves is 10 lbs.
s
The grease cup
after each use. Do not remove grease cup until grill has
completely cooled.
s
If you notice grease or other hot material dripping from grill
onto valve, hose or regulator, turn off gas supply at once.
Maintain
Determine the cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a leak test.
s
Keep grill cart free and clear of debris.
s
The regulator may make a humming or whistling noise during
operation. This will not affect safety or use of grill.
s
If you have a grill problem see the
• Putting out grease fires by closing the lid is not
possible. Grills are well ventilated for safety reasons.
• Do not use water on a grease fire. Personal injury may
result. If a grease fire develops, turn knobs and LP tank
off.
• Do not leave grill unattended while preheating or
burning off food residue on HI. If grill has not been
regularly cleaned, a grease fire can occur that may
damage the product.
Ignitor Lighting
s
Do not lean over grill while lighting.
1. Open lid.
2. Turn LEFT knob to
3. Push ignitor button rapidly (up to 5 times) to light. Be sure
burner lights and stays lit.
4. If burner does not light, turn knob(s) to OFF, wait 5 minutes,
then try again.
5. Turn RIGHT knob to
6. If ignitor does not work, follow match lighting instructions.
must be attached to grease clip and emptied
"Troubleshooting Section"
CAUTION
Turn on gas at LP tank.
(Ignite).
(Ignite) to light right burner.
.
461644304 • 7