Table Of Contents - State Water Heaters SBN 71-120NE Service Handbook

SBN TANK TYPE COMMERCIAL GAS WATER HEATER
SBN Service Handbook Introduction ................................................ 2-3
Installation Considerations ................................................................... 4
Clearances ....................................................................................... 4
Exterior Clearance ............................................................................ 5
Air Supply ......................................................................................... 6
Contaminated Air .............................................................................. 9
Flammable Items .............................................................................. 9
Gas Valve ....................................................................................... 10
Outlet View ..................................................................................... 11
Venting ........................................................................................... 12
Technical Data Venting .............................................................. 13-14
Sequence of Operation ........................................................................ 15
Top View ......................................................................................... 15
Front View ....................................................................................... 16
White Rogers Control ..................................................................... 17
HSI Board ....................................................................................... 18
Wiring Diagram ............................................................................... 20
Electrical Sequence ....................................................................... 21
Pre-Service Checklist........................................................................... 22
Control Board Diagnostic LED Interpretation and Troubleshooting
120 VAC Check to Heater ............................................................... 23
Polarity Check ................................................................................ 24
Continuity Check of High Limit ....................................................... 25
Upper Temperature Probe Check ................................................... 26
Inducer Check ................................................................................ 27
Blower Prover/Low Gas Pressure Circuit Check ............................ 28
HSI Voltage and Continuity Check ................................................. 29
Igniter and Gas Valve Circuit Check ............................................... 30
Gas Valve Coil Continuity Check .................................................... 31
Flame Prover Check ....................................................................... 32
Water Temperature Circuit Check ................................................... 33
Technical Training Department
Ashland City, Tennessee
SERVICE HANDBOOK

TABLE OF CONTENTS

1
©2003