Summary of Contents for IHC Hytech CO2
- Page 1 USER MANUAL CO2 SCRUBBER VERSION DS-2019-09 IHC Hytech B.V. Ramgatseweg 27 4941 VN Raamsdonksveer The Netherlands T +31 88 015 36 00 hytech@royalihc.com www.ihchytech.com www.royalihc.com ROYALIHC.COM...
- Page 2 IHC Hytech B.V. This publication remains the property of IHC Hytech B.V. and may not be passed, loaned or given to any third party.
- Page 3 PREFACE ABOUT THIS USER MANUAL This user manual provides instructions for installing and operating the IHC Hytech CO scrubber. The manual consists of: Chapter 1 - Introduction Chapter 2 - Safety precautions Chapter 3 - Installation Chapter 4 - Operation...
- Page 4 IHCHYTECH.COM...
-
Page 5: Table Of Contents
5.1 GENERAL ..... . 19 5.2 SPARE PARTS AND ACCESSORIES ... .19 INDEX USER MANUAL CO2 SCRUBBER CS-2019-09... - Page 6 IHCHYTECH.COM...
-
Page 7: General
The scrubber has an induced flow fan that pulls breathing gas through a canister filled with soda lime to adsorb CO The fan motor is designed by IHC Hytech and has completely potted stator electronics. This protects the motor from environmental impacts such as raised oxygen levels, humidity and pressure. -
Page 8: Specifications
SPECIFICATIONS Specifications Dimensions L 422 mm (16.6 inch) x W 226 mm (8.9 inch) x H 245 mm (9.7 inch) Weight complete unit (empty) 8.3 kg (18.3 lbs) Weight complete unit (full) 16 kg (35.3 lbs) Weight canister (empty) 2.3 kg (5.1 lbs) Weight canister (full) 10 kg (22) Power supply... -
Page 9: Optional Equipment
OPTIONAL EQUIPMENT 1.3.1 CONTAMINATION CANISTER The scrubber fan unit can be installed with a contamination canister (2.80.3963). The IHC Hytech contamination canister removes contamination from breathing gas in enclosed environments. The special fill of the canister removes all kind of contamination in enclosed environments such as vomit, urine, feces and sweat. - Page 10 Chapter 1 IHCHYTECH.COM...
-
Page 11: General
SAFETY PRECAUTIONS GENERAL The manufacturer does not accept any responsibility for damage or injuries caused by misuse of the scrubber. WARNING SIGNS In this manual three types of warning signs can be found on the left of the page. These warnings indicate possible dangers. The warning signs are: NOTE This indicates a situation that requires extra attention. - Page 12 USER MANUAL CO2 SCRUBBER VERSION CS-2019-09 Chapter 2...
-
Page 13: Mechanical
See table and pictures for pre-set speed and external speed configuration. Figure 3.1 Electrical connections USER MANUAL CO2 SCRUBBER VERSION CS-2019-09 Chapter 3... - Page 14 Description Description Black wire (24 VDC) Jumper White wire (0 VDC) Jumper in position for external speed control Red wire (0 - 10 VDC speed control Jumper in position for pre-set speed signal referenced to pin 2, optional) Green wire (rpm signal referenced to pin 2, optional) Chapter 3 IHCHYTECH.COM...
-
Page 15: General
If the CO level starts rising, the canister should be refilled or replaced. If the oxygen level inside the chamber drops, oxygen must be added to the chamber atmosphere. USER MANUAL CO2 SCRUBBER VERSION CS-2019-09 Chapter 4... -
Page 16: Performance Diagrams
4.2.1 PERFORMANCE DIAGRAMS 4.2.1.1 PERFORMANCE AT 50 MSW 4.2.1.2 PERFORMANCE AT 18 MSW Chapter 4 IHCHYTECH.COM... -
Page 17: Replacing Or Refilling The Canister
Place the canister on the bayonet with the cover plate facing upwards (B). Remove the cover plate by turning it counter-clockwise (B). Replace the adsorbent. Mount the cover plate. Mount the canister on the scrubber motor. The scrubber motor is now ready for use. USER MANUAL CO2 SCRUBBER VERSION CS-2019-09 Chapter 4... - Page 18 Chapter 4 IHCHYTECH.COM...
-
Page 19: General
Scrubber motor, external speed control 3.80.1018-2E Canister assembly (including canister O-ring) 3.80.973 Canister O-ring 105.00 x 6.00 H.70.00310 Canister Cover plate 3.80.2343 Sofnolime (Sodalime) CO2 absorbent T.99.02896 Contamination canister 2.80.3963 Refill Contamination canister T.98.00552 Motor Housing O-ring 75.00 x 6.00 H.70.00292 Motor Housing O-ring 72.00 x 2.50... - Page 20 USER MANUAL CO2 SCRUBBER VERSION CS-2019-09 Chapter 5...
- Page 21 . . . ELECTRICAL ELECTRICAL CONNEC- TIONS ..13 FAN MOTOR ..7 MAINTENANCE MAINTENANCE MAINTENANCE AND RE- PAIR ..USER MANUAL CO2 SCRUBBER CS-2019-09...