Summary of Contents for Samsung HABANA-C NT-R45 Series
Page 1
SAMSUNG HABANA-C NT-R45xxxx/xxx SERVICE Manual FEATURES SAMSUNG R45 1. Reliable Note PC -. ATI Platform Technology PCI-Express Graphics -. 15” XGA LCD 2. Excellent Easy Functions - USB 2.0, - PC card - VGA,TV-Out If there are the Contents not included in this book, please refer to K-zone Service Manual...
- This Document can not be used without Samsung's authorization - - Contents - 1. Precautions 1) General After-Sales Service Precautions 2) Safety Precautions 3) Ground 4) Static Electricity Precautions 2. Introduction and Specification 1) Introduction 2) Specification 3) Specification comparison between R45 and P29...
- This Document cannot be used without the authorization of Samsung - Precautions 1) General After-Sales Service Precautions (1) Do not let customers repair the product themselves. ☞ There is a danger of injury and the product life time may be shortened.
Page 4
- This Document cannot be used without the authorization of Samsung - Precautions 2) Safety Precautions (1) EMI This device has been registered regarding EMI for residential use. It can be used in all areas. (2) Circuit Test (Logic Test) Precautions The LSI and MSI used in this product are semiconductor integrated circuits based on MOS-FET or CMOS.
Page 5
- This Document cannot be used without the authorization of Samsung - Precautions 3) Ground The product must be grounded to protect it from static electricity and other dangers. When using a multitap, please use a multitap with a ground terminal only.
Page 6
- This Document can not be used without Samsung's authorization - 11. References 1) Safety Notice (1) An electric leakage related safety Electric leakage is the flow of electricity to the ground through electrical wires due to ripped coating or bad insulation.
Page 7
- This Document can not be used without Samsung's authorization - 11. References 2) Model Numbering Rule 1. CTO ( Computer Model Numbering System) 11-2...
Page 8
- This Document can not be used without Samsung's authorization - 11. References 11-3...
Page 9
- This Document can not be used without Samsung's authorization - 11. References 2. Non - CTO ( Computer Model Numbering System) 11-4...
Page 10
- This Document can not be used without Samsung's authorization - 11. References 11-5...
Page 11
- This Document can not be used without Samsung's authorization - 11. References 3) CPU Code table Code name Samsung CODE L1 cache L2 cache clock speed 0902-001943 667MHz 32KB 1.66GHz T1300 0902-001916 667MHz 32KB 1.66GHz T2300 0902-001939 667MHz 32KB 1.83GHz...
Page 12
- This Document can not be used without Samsung's authorization - 11. References 4) Glossary Bad Sector An area on a hard disk or floppy disk that cannot be used to store data, because of a manufacturing defect or accidental damage. A floppy or hard disk saves data in units and the smallest unit of storage on a disk is a sector.
Page 13
- This Document can not be used without Samsung's authorization - 11. References Cache Memory High-speed memory with a copy of the most recently used memory data. When the CPU's request for instructions or data can be satisfied from the cache, the CPU can run at full rated speed. Using a part of the hard disk space as cache memory due to small main memory capacity is called disk cache.
Page 14
- This Document can not be used without Samsung's authorization - 11. References Device Driver A program stored on the hard drive that tells the operating system how to communicate with an input/output device such as a printer. You may think of it as dedicated software that controls a device such as a printer.
Page 15
- This Document can not be used without Samsung's authorization - 11. References EPROM Abbreviation for ‘Erasable Programmable Read Only Memory’. An EPROM differs from a PROM in that a PROM can be written to only once and cannot be erased. IF an EPROM is exposed to ultraviolet light, the data is erased.
Page 16
- This Document can not be used without Samsung's authorization - 11. References ALU (Arithmetic-Logic Unit) Abbreviation for ‘Arithmetic Logic Unit’. A part of the CPU. ALU carries out additions, subtractions, multiplications and divisions, as well as logical operations within instructions.
Page 17
- This Document can not be used without Samsung's authorization - 11. References Firmware Low-level software that controls the hardware. Firmware is a combination of software and hardware. The name, 'Firmware', is used because it is partly hardware and it is partly software that controls the underlying hardware of the system.
Page 18
- This Document can not be used without Samsung's authorization - 11. References Audio Frequency An audio frequency normally audible to humans. Although the audio frequencies may differ depending on individuals and the volume and type of the sound, audio frequencies range roughly from 20 Hz to 20 kHz.
Page 19
- This Document can not be used without Samsung's authorization - 11. References Dual Core This refers to a CPU that has dual processing cores within and has been developed by technology that incorporates two or more Intel Pentium-based processing cores within a single processor.
Page 20
- This Document can not be used without Samsung's authorization - 11. References 5) Hardware Upgrade All reassembly is done in the reverse order of disassembly. (1) Upgrading the ODD 1. Remove the screws at the bottom of the system.
Page 21
- This Document can not be used without Samsung's authorization - 11. References 4. Remove the ODD. 5. ODD Types ODDs that can be used for the R65/P50 include DVD-Combo, CD-ROM, DVD-ROM and Super Multi Drive (Dual Layer). - DVD-Combo Drive...
Page 22
- This Document can not be used without Samsung's authorization - 11. References (2) Upgrading the HDD. 1. Remove the HDD compartment cover. 2. Separate the HDD-FPC from the HDD connector on the main board. 3. Separate the HDD from the BRKT-HDD and replace the HDD. (The HDD type is PATA)
Page 23
- This Document can not be used without Samsung's authorization - 11. References (3) Replacing the WLAN 1. Remove the screws at the bottom of the system. 2. Press the keyboard hooks downwards and lift the keyboard up. 3. Remove the screws fixing the BRK-KBD.
Page 24
- This Document can not be used without Samsung's authorization - 11. References 4. Remove the WLAN Cable-Antenna. 5. Remove the WLAN (Sliding the WlAN hooks on both side slightly, then lift the WLAN up.) 11-19...
Page 25
- This Document can not be used without Samsung's authorization - 11. References (5) Upgrading Memory 11-20...
Page 26
- This Document can not be used without Samsung's authorization - 11. References 11-21...
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 1) Introduction (1) Reliable Note PC - Intel Celeron M/Pentium M Processor and DDR II Memory - PCI-Express Graphics( Option ) - Wireless LAN( Option ), Bluetooth ( Option )
Page 28
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 구분 Feature Form Factor (LCD) 15" XGA None Glare LCD Platform (Chipset) Dothan + RC410MD/RC410MB + SB450 Memory Single channel 533/400MHz 802.11bg(option),BT(option) Wireless Graphics Internal ATI Graphic...
Page 29
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 2) Specification Processor and Motherboard Intel Celeron M[Dothan](1.30GHz) ~ T2700(2.13GHz) Intel Celeron M :ATI RC410MB 400MHz FSB Support Intel® Pentium M[Dothan] at Q1'06~Q4'06 ...
Page 31
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification Average Access Time DVD 130ms Typ., CD 130ms Typ. Weight 190g or less S/W supplied Power DVD Player (5.0), Nero Burning or equivalent S/W Security...
Page 32
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification Audio Jacks HeadPhone-out , MIC-in Modem / LAN RJ11, RJ45 Power 1(5pie) Input Devices Key board 88KEY(KR/US), 89KEY(UK/FR/GM/SP) Travel length 2.6mm/ Key Pitch 19.05mm...
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 3) Specification comparison between R45 and P29. Dothan or Celeron M Dothan or Celeron M 칩셋 ATI RC410MD + SB450 ATI RC300MD + SB150 Memory...
Page 34
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 4) Wireless LAN Specification (1) Wireless LAN Standard (802.11G card ) Intel(R) PRO/Wireless LAN 3945G Network Connection Device 2- 8...
Page 35
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification 2- 9...
Page 36
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification BA59-01469A HDD;40G,HTS541040G9AT00,S63,H16,C16383,9 Hitachi BA59-01470A HDD;60G,HTS541060G9AT00,S63,H16,C16383,9 Hitachi BA59-01471A HDD;80G,HTS541080G9AT00,S63,H16,C16383,9 Hitachi BA59-01702A HDD;80G,HTS421280H9AT00,S63,H16,C16383,H Hitachi BA59-01703A HDD;100G,HTS421210H9AT00,S63,H16,C16383, Hitachi BA59-01725A HDD;100G,HTS541010G9AT00,S63,H16,C16383, Hitachi BA59-01746A HDD;60G,HTS421260H9AT00,S63,H16,C16383,H Hitachi BA59-01649A HDD;40GB,MHV2040AH,S63,H16,C16383,H9.5,W Fujitsu BA59-01650A HDD;60GB,MHV2060AH,S63,H16,C16383,H9.5,W...
Page 37
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification BA59-01565A DVD-COMBO;TS-L462C,8X,190ms,EIDE,2M,8W,5 TS-L462 BA59-01624A DVD-SUPERMULTI;DV-W28EA,8X,130ms,EIDE,2M DV-W28E BA59-01687A DVD-COMBO;DW-224E-C,24X,110ms,EIDE,2M,6W DW-224E BA59-01778A CD ROM;CD-224E-N,256KB,W128*L126.1mm,EID CD-224E MEMORY 1105-001609 IC-DRAM MODULE;M470T3354BG0,32Mx64Bit,SO 256M_D5(SEC) 1105-001610 IC-DRAM MODULE;M470T6554BG0,64Mx64Bit,SO 512M_D5(SEC) 1105-001611 IC-DRAM MODULE;M470T2953BS0,128Mx64Bit,SO...
Page 38
- This Document can not be used without Samsung's authorization - 2. Introduction and Specification LCD PENEL BA59-01811A LCD PANEL-15XGA;LTN150XG-L05-V,15XGA,N/G SAMSUNG BA59-01750A LCD PANEL-15XGA;N150X3-L09,15XGA,200n,N/ CHIMEI BATTERY Sanyo Battery 6cell(4000MAH) BA43-00155A WLAN BA59-01664A 802.11g WM3B3945AGKOR 2- 12...
- This Document can not be used without Samsung's authorization - 3. Function 1) Construction of System 3- 1...
Page 40
- This Document can not be used without Samsung's authorization - 3. Function 3- 2...
Page 41
- This Document can not be used without Samsung's authorization - 3. Function 3- 3...
Page 42
- This Document can not be used without Samsung's authorization - 3. Function 3- 4...
Page 43
- This Document can not be used without Samsung's authorization - 3. Function 2) Keyboard 3- 5...
Page 44
- This Document can not be used without Samsung's authorization - 3. Function 3- 6...
Page 45
- This Document can not be used without Samsung's authorization - 3. Function 4) PC Card Slot 3- 7...
Page 46
- This Document can not be used without Samsung's authorization - 3. Function 7) Description of Main board (1) TOP Item Item 14 USB Cable RC410 15 Touchpad Connector SB450 16 SVHS Connector MiniCard for Wireless LAN 17 DC Jack PCMCIA &...
Page 47
- This Document can not be used without Samsung's authorization - 3. Function (2) BOTTOM Item Micom Azalia Modem RTC Battery Modem Cable Clock Generator DDR2 SODIMM Memory Connector LAN Controller BIOS HDD Connector 10 LAN Transformmer 3- 9...
- This document cannot be used without Samsung's authorization - 4. Disassembly and Reassembly 4-1. Disassembly and Reassembly of R45 Part Figure Description 1. Make sure to separate the AC adapter and battery before disassembling the system. 2. Slide the knob all the way to the end in the direction of the arrows (1) and push the battery in the direction of the arrows (2).
Page 49
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 7. When removing the HDD compartment cover, you will find the HDD. Separate the HDD cable and lift up the HDD at an angle of 70º as shown in the figure.
Page 50
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 11. Lift up the keyboard, then the Connector Lock and separate the FPC. 12. Remove the 2 screws fixing the Bracket- Support_KBD, then remove the Bracket.
Page 51
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 16. Remove the 2 screws fixing the Hinge and the Top. 17. Lift up the Assy LCD slightly and separate it by pulling it in the direction of the arrow.
Page 52
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 20. (1) Separate the Ontop cable from the Main board. (2) Separate the Speaker cable from the Main board. (3) Separate the Touchpad cable from the Main board.
Page 53
- This document cannot be used without the authorization of Samsung- 4. Disassembly and Reassembly Part Figure Description 23. (1) Remove the screw fixing the USB board and the Bottom. (2) Remove the screw fixing the 1394 board and the Bottom.
Page 54
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 26. Remove the screw fixing the Fan, separate the cable and the Fan. * You need disassemble the another screw, (in...
Page 55
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 30. Lift up the PCMCIA socket to separate it from PCB. Main System 31. The figure shows a picture of PCB when the parts are removed.
Page 56
- This document cannot be used without the authorization of Samsung - 4. Disassembly and Reassembly Part Figure Description 3. Slide the latch with your finger to prevent intervention with the LCD Front and insert your finger between the LCD Panel and LCD Front to separate the upper part of the LCD Front.
Page 57
- This document cannot be used without the authorization of Samsung- 4. Disassembly and Reassembly Part Figure Description 8. Remove the screws indicated by the arrows in the figure and remove the antenna wire. * Caution Remove the wire keeping an eye on the hook on the LCD Back.
Page 58
- This document cannot be used without the authorization the Samsung - 4. Disassembly and Reassembly Part Figure Description 13. Separate the Invertor board connector. 14. Remove the silver tapes in circles 1 and 2. 15. Pull out the LCD cable in circle 1 in the direction of the arrow.
Page 59
- This document cannot be used without the authorization of Samsung- 4. Disassembly and Reassembly Part Figure Description 1. To release the TOP, separate the materials in the yellow circles in the figure. 2. Remove the 2 screws fixing the Speaker-R and Top.
Page 60
- This document cannot be used without the authorization of Samsung- 4. Disassembly and Reassembly Part Figure Description 5. Remove the 3 screws fixing the Bracket- Touchpad and the Top. 6. (1) Separate the Touchpad cable from the hook. (2) Separate the FFC cable from the connector.
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 1) General (1) Tools used for repairing the product System Diagnostics Disk MS-DOS Booting Disk System Diagnostics Card Screwdrivers ( ┼ , ━ ) Tweezers Multi-meter...
Page 62
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 2) Debugging Flow Chart Start Power on No problem No problem No problem Check there is Check Adapter Check Ontop Change Mainboard Power on? any short in the and Battery.
Page 63
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting No problem No problem Check speaker Change Mainboard Speaker's sound Check driver status. connection and and check it. is OK? speaker cable problem. problem. Solution : Replace the defected part or revise the connectivity.
Page 64
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 3) System Diagnosis (1) System Diagnostics Card The Diagnostics Card shows the system operations during the POST (Power On Self Test) in a 2 digit hexadecimal number by connecting the cable to the 10 pin connector below the PCMCIA slot after separating the Top part.
Page 65
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting Test the CPU bus-clock frequency Initialize Phoenix Dispatch Manager Warm start shutdown Shadow system BIOS ROM Auto size cache Advanced configuration of chipset registers Load alternate registers with CMOS values...
Page 66
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting Re-initialize onboard I/O ports. Configure Mothe board Configurable Devices Initialize BIOS Data Area Enable Non-Maskable Interrupts (NMIs) Initialize Extended BIOS Data Area Test and initialize PS/2 mouse...
Page 67
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting (3) Use of Debug card 5- 7...
Page 68
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 4) Hardware Troubleshooting For the procedures to disassemble each part, refer to the descriptions of Chapter 4, “Disassembly and Reassembly”. ◆ LCD Related Troubles 1. The screen is dark or the colors of the screen are distorted.
Page 69
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting ◆ Main System Troubles 5. The system is not turned off. → Check if the AC adapter LED is lit and if the adapter is properly connected to the system.
Page 70
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 6. Although system power is supplied, the system does not boot or immediately turns off after being turned on. → Since this may be a short circuit in the system, disconnect the power immediately, disassemble the system and check if there are any conducting alien objects such as a screw inside.
Page 71
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 9. I cannot hear sound through the headphones. → Check if the sound is muted in Windows. → Turn the volume up. → Replace the main board 10.
Page 72
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting → Check the connection status of the Touch Pad module. → If there is no problem with the connections, replace any suspicious parts and check if they are out of order.
Page 73
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 15. The LAN function does not work. → Check if the LAN cable is properly connected. → Check if the LAN driver is properly installed. → If the driver is properly installed, check if the LAN cable jack is out of order.
Page 74
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting according to your system environment. 20. Windows boots up in safe mode. → This may happen when Windows was not shut down normally. Therefore, shut down the system by selecting Start >...
Page 75
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting ◆ Power-Saving Mode Related Troubles 26. Connecting a USB device to the computer in standby mode. → If a USB device is connected to the computer in standby mode, the screen may be abnormally displayed.
Page 76
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 5) Device Settings Related Software Diagnosis (1) Check if the drivers of each of the devices are properly installed. That is, check if there are any yellow exclamation marks in the Device Manager.
Page 77
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting (2) Check if the program is properly installed. 5- 17...
Page 78
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting (3) HDD and ODD Related Problems For an HDD, check if the HDD operates in Ultra DMA Mode 5 by selecting the Primary IDE Channel in the Control Panel as follows. If it does not, check the BIOS SETUP, reinstall the operating system or replace the HDD-FPC or HDD, if necessary.
Page 79
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting Check if the HDD and ODD models are properly displayed. If not, check the BIOS SETUP or replace the FPC or drive, if necessary. 5- 19...
Page 80
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting (5) Other Problems Press each corresponding button and check its operation. The following figure illustrates the operation of the volume control button. The drivers and application software are listed in the following table.
Page 81
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting Ricoh R5C841 MS, SD XPMCE/XPPRO/XPHOME/WIN2K- Driver KOR/ENG/FRE/GER/CHS/CHT/TAI/JPN/UK/SPN/RUS/POR/SIN-MS_SD_MMC_xD XPPRO/XPHOME/WIN2K-KOR/ENG/FRE/CHS/CHT/JPN/UK/SPN/GER/RUS/POR- TPM Driver v.1.70.0154.00 Application ITEM Revision XPMCE/XPPRO/XPHOME-KOR/ENG/FRE/GER/CHS/CHT/TAI/UK/SPN/RUS/POR- Samsung Command Center 1.0.24.0N NoAD XPMCE/XPPRO/XPHOME-KOR-6.0.0.34(6.34.2.11) XPMCE/XPPRO/XPTabletPCEd/XPHOME/WIN2K/WIN98/WIN98SE/WINME- VirusDefinition KOR/ENG/FRE/GER/CHS/CHT/TAI/JPN/UK/SPN/RUS/POR/SIN-05.07.18 Napster XPMCE/XPPRO/XPHOME/WIN2K-UK/ENG-2.5.1.8...
Page 82
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting Norton AntiVirus 2005 XPMCE/XPPRO/XPHOME/WIN2K-CHT-11.0.2 Norton AntiVirus 2005 XPMCE/XPPRO/XPHOME/WIN2K-SPN-11.0.1 Acrobat Reader XPHOME/XPPRO/WIN2K/XPMCE-KOR-6.0.1[S] Acrobat Reader XPHOME/XPMCE/XPPRO/WIN2K-ENG/UK/RUS-6.0.1[S] Acrobat Reader XPMCE/XPPRO/XPHOME/WIN2K-FRE-6.0.1[S]+ Acrobat Reader XPHOME/XPMCE/XPPRO/WIN2K-GER-6.0.1[S] Acrobat Reader XPHOME/XPMCE/XPPRO/WIN2K-CHS-6.0.1[S] Acrobat Reader XPHOME/XPMCE/XPPRO/WIN2K-CHT-6.0.1[S] Acrobat Reader XPHOME/XPMCE/XPPRO/WIN2K-SPN-6.0.1[S]...
Page 83
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 6) CPU Fan Control Problems Item Mode Design Guideline DC 2.5V Middle1 DC 3.0V FAN Operating Voltage Middle2 DC 3.5V High1 DC 4.0V High2 DC 4.5V >...
Page 84
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 7) Battery Use Time Check the following check lists for systems where the battery use time is too short to diagnose problems. (1) Check the battery Check if the battery is out of order referring to the Battery check program distributed to Service Centers and the 'Battery Check Manual' included in the 'Note-PC A/S Guide'.
Page 85
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 5- 25...
Page 86
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 5- 26...
Page 87
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting 3. Battery Capacity Table 4. Battery Check Program 5- 27...
Page 88
- This document cannot be used without the authorization of Samsung - 5. Troubleshooting (2) Check the battery use environment 1. Generally, the battery usage time in advertisements by notebook manufacturers refers to the maximum battery use time. Since the system specifications and the usage environment may differ, the user's battery usage time may differ from the advertisement even if there is no problem with the system.
Page 89
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST System Overall Exploded View SAMSUNG R45...
Page 90
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST System Parlist NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA97-02521A ASSY MECHA-LCD;HABANA-C,HOME,-,-,ASSY ME BA75-01768A UNIT-HOUSING_BOTTOM;HABANA-C,DOMESTIC,PC BA92-04149A ASSY MOTHER BD-TOP;HABANA-C,1.73Ghz,DDR2 6001-001570 SCREW-MACHINE;CH,+,-,M2,L4,ZPC(BLK),SWRC 0902-001864 IC-MICROPROCESSOR;SL86J,1.5GHz,64Bit,uFC...
Page 91
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA75-01725A UNIT-DOOR_MEMORY;HABANA,SEC,AL,W84*L124. BA59-01471A HDD;80G,HTS541080G9AT00,S63,H16,C16383,9 BA59-01865A HDD;80GB,MHV2080AH-PL,S63,H16,C16383,H9. BA59-01651A HDD;80GB,MHV2080AH,S63,H16,C16383,H9.5,W BA59-01745A HDD;80G,MP0804H,S63,H16,C77622,9.5mm,2.5 BA41-00568A FPC-HDD;Habana,Y00,gold,50P,T0.15mm,- BA41-00569A FPC-HDD;Habana,Y00,gold,50P,T0.15mm,PATA BA61-01043A BRACKET-HDD;SEDONA,STS304,T0.15mm,-,-,NT...
Page 92
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST LCD Exploded View SAMSUNG R45...
Page 93
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST LCD Partlist NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA75-01771A UNIT-HOUSING_BACK;HABANA-C,DOMESTIC,PC/G 6001-001570 SCREW-MACHINE;CH,+,-,M2,L4,ZPC(BLK),SWRC BA59-01811A LCD PANEL-15XGA;LTN150XG-L05-V,15XGA,N/G BA75-01757A UNIT-BRKT_LCD_L;HABANA,YIHSIN,SUS304,W15 BA75-01758A UNIT-BRKT_LCD_R;HABANA,YIHSIN,SUS304,W15 6001-001532 SCREW-MACHINE;CH,+,M2,L3,ZPC(BLK),SWRCH1...
Page 94
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST TOP Ass’y Exploded View(1) SAMSUNG R45...
Page 95
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST TOP Ass’y Exploded View(2) SAMSUNG R45...
Page 96
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST TOP Ass’y Partlist NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA81-02742A HOUSING-TOP;HABANA-C,DOMESTIC,PC/GF,W269 BA81-01782A TAPE-TOP_PLATE;FIRENZE,POLYESTER,W188.0* BA81-02313A BRACKET-TOP_PLATE;HABANA,SUS304,W37.85*L BA81-02308A LENS-INDICATOR_POWER;HABANA,PC,W13.7*L37 BA81-00773A KEYBOARD-LOCK;NEON,POM,W17.0*L18.6*H2.8, BA81-02310A KNOB-TOUCHPAD;HABANA,PC/ABS,W29.8*L74.0*...
Page 97
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST 6-7 BOTTOM Ass’y Exploded View SAMSUNG R45...
Page 98
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST 6-8 BOTTOM Ass’y Partlist NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA81-02295A HOUSING-BOTTOM;HABANA,PC/GF,W296.97*L325 BA81-02227A KNOB-BATTERY_L;SEDONA,PC+ABS,T1.0mm,BLAC BA81-02228A KNOB-BATTERY_R;SEDONA,PC+ABS,T1.0mm,BLAC BA81-02298A LINK-BATTERY_L;HABANA,POM,W8.5*L26.4*H3. BA81-02299A LINK-BATTERY_R;HABANA,POM,W8.5*H4.0*L26.
Page 99
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST 6-9 ODD Ass’y Exploded View SAMSUNG R45...
Page 100
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST 6-10 ODD Ass’y Partlist NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA59-01687A DVD-COMBO;DW-224E-C,24X,110ms,EIDE,2M,6W BA59-01565A DVD-COMBO;TS-L462C,8X,190ms,EIDE,2M,8W,5 BA81-02262A BRACKET-ODD;SEDONA,STS304 1/2H,W20*L8.7* 6001-001532 SCREW-MACHINE;CH,+,M2,L3,ZPC(BLK),SWRCH1 BA81-02253A UNIT-BEZEL_DVDCOMBO;SEDONA,PC+ABS,W15.2*...
Page 101
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note 0401-000132 DIODE-SWITCHING;BAV99,70V,50MA,SOT-23,TP 0401-000191 DIODE-SWITCHING;MMBD4148,75V,200MA,SOT-2 0402-001405 DIODE-RECTIFIER;B340A,40,3A,SMA,TP 0406-001141 DIODE-TVS;PGB1010603NR,-/-/1000V,0W,EIA- 0501-000465 TR-SMALL SIGNAL;MMBT3904,NPN,350mW,SOT-2 0505-001049 FET-GAAS;BSS84,-50V,20V,-130mA,360mW,SOT 0505-001341 FET-SILICON;SI2307DS,P,-30V,-3A,0.08/0.1...
Page 102
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note 2007-000972 R-CHIP;5.1ohm,5%,1/4W,TP,3216 2007-002910 R-CHIP;30.1Kohm,1%,1/10W,TP,1608 2007-007468 R-CHIP;121KOHM,1%,1/16W,TP,1005 2203-001201 C-CER,CHIP;0.0070nF,0.5pF,50V,NP0,1005 2203-006048 C-CER,CHIP;100nF,10%,10V,X7R,1005 2203-006090 C-CER,CHIP;10000nF,10%,6.3V,X5R,2012 2203-006093 C-CER,CHIP;1000nF,+80-20%,6.3V,Y5V,1005 2402-001122 C-POLYMER AL CHIP;100uF,0.2,6.3V,-,TP,7.
Page 103
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note BA39-00531A WIRE HARNESS-MDC;HABANA,wire,DA-1571,2PI BA39-00534A WIRE HARNESS;TC05D37,AWG28,UL 1061,2PIN, BA39-00537A WIRE HARNESS-MDC;HABANA,Wire,UL1571,2PIN BA44-00162A ADAPTOR;AD-6019(API1AD02),CORONA,-,90TO2 BA44-00205A ADAPTOR;0335C1960,AD-6019,AC/DC,90to264V BA46-04725A S/W CD;CDS/NERO EXP.,-,WIN2K/XP/MCE,1.0,...
Page 104
- This Document can not be used without Samsung's authorization - MECHANICAL EXPLODED VIEW AND PARTLIST NP-R45K003/CHN Part Code Part Name & Specification Q'ty SA/SNA Note 2203-005172 C-CER,CHIP;47nF,+80-20%,25V,Y5V,1005 2203-006000 C-CER,CHIP;1NF,10%,3KV,X7R,TP,4520 2203-006166 C-CER,CHIP;100nF,10%,25V,X5R,1005 2203-006382 C-CER,CHIP;10000nF,10%,25V,X7R,3225 2402-001120 C-POLYMER AL CHIP;330uF,0.2,6.3V,-,TP,7. BA61-00931A SUPPORT-DMB;NEON,Cu,T4.9,W3.5,L3.5,WHITE 3903-000131 CBF-POWER CORD;DT,CN,EP2,IEC320 C7,250/2...
Page 105
Main System Option SESC code Location Name Spec. Unit 0902-001841 D_740 IC-MICROPROCESSOR 740PGA,1.73GHz,64Bit,uFC- 1105-001609 512M_D5(256X2M-SEC) IC-DRAM MODULE M470T3354BG0,32Mx64Bit,SODIMM,200P,6 PC 3903-000055 POWER CORD(SEB) CBF-POWER CORD DT,EU,CP2/NO,E(IEC320 BA31-00025A FAN(TOSHIBA) MCF-908AM05,Sedona,Plastic,- BA31-00026A FAN(SEPA) HY60A-05A-007,Sedona,Plastic,- BA39-00527A LCD CABLE(WANSH) CABLE FORM CONN.COAX Habana,Twin BA39-00528A LCD CABLE(FOXCN) CABLE FORM CONN.COAX Habana,Twin BA39-00533A...
- This Document can not be used without Samsung's authorization - 8. System Block Diagram 8-1 Block Diagram...
Page 150
- This Document can not be used without Samsung's authorization - 8. System Block Diagram...
Page 151
- This Document can not be used without Samsung's authorization - 8. System Block Diagram...
Page 152
- This Document can not be used without Samsung's authorization - 8. System Block Diagram...
Page 153
- This Document can not be used without Samsung's authorization - 8. System Block Diagram...
Page 154
- This Document can not be used without Samsung's authorization - 9. System Wire Diagram 9-1. R45 Top Right Left speaker speaker Ontop board Touch-pad IF board Speaker cable Ontop cable Touchpad cable Touchpad FFC 9-2. R45 Bottom LCD conn...
Page 155
- This Document can not be used without Samsung's authorization - 9. System Wire Diagram 9-3. R45 Top Left Right speaker speaker Ontop board FingerPrint Touch-pad IF board board 9-4. R45 Bottom LCD conn (J603) To SIO cable (J607) To FAN...
Page 156
- This Document can not be used without Samsung's authorization - 9. System Wire Diagram 9-5. R45 LCD 9- 3...