Bowers & Wilkins 96002 Manual page 20

B&W bike bag
36
3.1
Initially release the front screws on the
handlebar stem by one or two rotations
and turn the handlebars down until the
smallest possible construction width is
achieved.
3.2
If this is not sufficient, the handlebars
need to be fully removed.
Protect the handlebars with air cushion
film.
3.3
Only turn the four screws with little force
so that the handlebars are only just held
in the stem or the clamp collars are lightly
fixed.
3.4
Before removing the seat and seat post,
mark the insert depth of the seat post
with sticky tapes. Stick a second piece of
sticky tape to the same point on the frame
and draw a vertical line. This makes a big
difference when setting the seat height
and aligning the seat at the destination.
3.5
Open the seat post clip on the clamp or
on the frame by one or two turns. Pull the
seat post out. This should be possible
without too much force and without
strongly turning it back and forth.
Never apply force. If necessary, read your
general instruction manual or ask your
bike retailer.
3.6
Turn the seat post clip using little force on
the tool and only as far as required so that
it just securely holds the seat post.
Turning the screw connector on the seat
A
post clip too tightly can damage the
actual clip or the frame.
Clean the support and protect it with
insulation tubing. Store the seat and seat
post on the base of the bike bag so that
they cannot cause any damage.
3.7
Wrap the
•
pedals,
•
tool used (pedal and Allen wrench)
•
torque key with bits (for proper assembly)
•
carbon lubricant if necessary
•
chain and penetrating oil for care (no
spray cans!)
•
air pump and
•
saddle bags
individually in cotton cloths.
3.8
Store all of this together with this manual
and your general bike instruction manual,
if possible, in the pockets sewn into the
bike bag and the rest in a little box at the
bottom of the bike bag.
If there is any space left in the bike bag,
i
you can slide a well packed helmet and
even packed cycling shoes into the cavity.
bike bag B&W
37