Page 1
Please use this service manual with referring to the ● 修理の際は、必ず取扱説明書を参照の上、作業を行っ ● operating instructions without fail. てください。 Some illustrations using in this service manual are ● 本文中に使用しているイラストは、説明の都合上現物 ● slightly different from the actual set. と多少異なる場合があります。 Denon Brand Company, D&M Holdings lnc. X0381 V.02 DE/CDM 0805...
If wire bundles are untied or moved to perform adjustment 調整や部品の交換等により、ワイヤー類の結束をはずし or parts replacement etc.,be sure to rearrange them neatly たり移動させた場合には、それらの作業が完了した時点 as they were originally bundled or placed afterward. でワイヤーの整形をおこなってください。正しく整形さ Otherwise, incorrect arrangement can be a cause of noise れていないとノイズ発生の原因となることがあります。 generation. Wire arrangement viewed from the top 上面からみたワイヤー整形 DVP-602CI...
Page 6
Note:・If step 3 does not work, start over from step 1. からやり直してください。 ・ All user settings will be lost and this factory setting ・初期化を行うとお客様が設定した内容が工場出 will be recovered when this initialization mode. 荷状態に戻りますので、あらかじめ設定内容を So make sure to memorize your setting for restor- 控えておき初期化後再設定してください。 ing after the initialization. DVP-602CI...
CPU SUPPLY UNIT Refer to "DISASSEMBLY 5.CPU SUPPLY UNIT ASSY" The viewpoint of each photograph (photography direction) Picture J Picture G 各図の視点(撮影方向) Front side Top view Picture D Picture E Picture B Picture F Picture H Picture A Picture C DVP-602CI...
Page 8
(3) Remove the FRONT PANEL SUB ASSY.(フロントパネル SUB ASSY をはずす。 ) Picture J Please refer to "EXPLODED VIEW " for the disassembly method of each P.W.B included in FRNOT PANEL SUB ASSY. FRONT PANEL SUB ASSY の各基板のはずしかたは "EXPLODED VIEW " を参照してください。 DVP-602CI...
BACK PANEL SUB ASSY の各基板のはずしかたは "EXPLODED VIEW" を参照してください。 3. DSP/SCPU UNIT proceeding ( 手順 ) : TOP COVER DSP/SCPU UNIT → (1) Disconnect the connector wires and remove the screws.( コネクタワイヤーとねじをはずす。 ) DSP/SCPU UNIT Picture H CY803 CX713 Board to Board Board to Board CX131 DVP-602CI...
(1) Remove the screws.(ねじをはずす。 ) TOP VIEW ETHERNET UNIT ASSY (2) Disconnect the Board to Board connector.(ボード間コネクター をはずす。 ) ETHERNET UNIT Picture B Board to Board CONNECT UNIT D. VIDEO UNIT Picture B Board to Board CONNECT UNIT D. VIDEO UNIT DVP-602CI...
Page 11
Wire clamp band : Cut Picture E Cord holder : Loose Style pin : Loose Wire clamp band : Cut CPU SUPPLY UNIT CX021 Cord holder : Loose Picture G CX022 CPU SUPPLY UNIT Picture F CPU SUPPLY UNIT Picture D DVP-602CI...
Page 12
6. OPT UNIT proceeding ( 手順 ) : TOP COVER OPT UNIT → (1) Disconnect the connector wire and remove the screws.(コネクタワイヤーとねじをはずす。 ) Style pin : Loose CY131 OPT UNIT Picture J Picture A DVP-602CI...
Page 13
No change to BUSY port "L" before issuing DSP special read command. " □ DSP □□ ERROR □12□ " No change to BUSY port "L" before DSP version read. " □ DSP □□ ERROR □13□ " Both SUB/DSP (No error display, version display only) DVP-602CI...
及び回路の短絡を確認し、 認し、不良部品を交換して の不良部品を交換して下さ parts connected to SW side rectifying circuits circuitry of the secondary 不良部品を交換して下さ 下さい。 い。 TRANS, and replace any connected to SW TRANS, side, and replace any い。 defective parts. and replace any defective defective parts. parts. DVP-602CI...
Page 16
Poor in connector connection between UNIT. between UNIT. D.VIDEO UNITの不具合 D.VIDEO UNIT flaw. 本体-MONITOR 間のケーブル ケーブルまたは Check cable between Cable or MONITOR is または MONITOR確認 MONITORの不良 main unit and monitor defective. or Check monitor. HDMI異常時の To Troubleshooting トラブルシューティングへ 3. HDMI/DVI. DVP-602CI...
Page 17
DENON の DVD プレーヤーを使用している場合、FL 管の "HDMI" インジ ケータが点灯していますか? When using a DENON DVD player, is the fluorescent display tube's 他社の DVD プレーヤーを使用している場合は "YES" に進んでください。 "HDMI" indicator lit? If using a non-DENON DVD player, proceed to "YES". DVD プレーヤーの出力解像度を、TV DVD プレーヤーの解像度を変えて画...
Page 18
DVD player and the set is disconnected? (IC333/IC363/IC301 S-VIDEO out or Component out)? surrounding circuitry) DVD プレーヤーが本機との接続を認 識していません DENON の DVD プレーヤー 1U-3833 の HDMI コ ネ クタ ー を使用している場合、FL 管 When using The DVD player does not recognize the...
Page 19
Checking the settings ネットワーク設定の確認 Set the IP address and other parameters properly. For a fixed IP setting, IP アドレス等を正しく設定して下さい。 Are the DVP-602CI's network settings correct? check whether the IP address overlaps with other devices, and check 本機のネットワークの設定は正しいですか? 固定 IP 設定の場合、IP アドレスが他の機器と重複していないか、サブ...
Page 20
Connection to network could not be performed when 上段 Update retry Update の自動リカバリ実行後に Network へ接続した Check the network connection. → → Network の接続を確認してください。 connecting to network after automatic update recovery. Lower Connection fail 際に Network への接続がおこなえなかった。 下段 Connection fail DVP-602CI...
Page 21
DVP-602CI BLOCK DIAGRAM 1U-3833P DIGITAL VIDEO UNIT Input Output Select / GUI control / HDMI Input IP & Scaler SECTION IN-1 HDMI 1 HDMI Output IC101 HDMI SW 1 IC333 SiI9185 HDMI HDMI 1 IC151 IC301 HDMI Receiver Transmitter 1...
Page 22
DVP-602CI POWER SUPPLY BLOCK DIAGRAM DVP-602CI...
Page 23
BYTE − − − − − − − GND (Ext. data bus bit width switching, 16bit : L) Single-chip / Micro-processor mode switching CNVSS CNVSS − − − (Normal single-chip : L,Rewrite boot program start : H input set) DVP-602CI...
Page 25
= Becomes High impedance mode at reset STBY : State of port when STANDBY mode. “O/L” = Output port and “L” “I” = Input port Stop : State of port when Stop mode. “O/L” = Output port and “L” “I” = Input port DVP-602CI...
Page 26
: L,Rewrite boot program start : H input set) Not used VDRST Video decoder reset(ADV7403) RESET SUBRESET Reset input XOUT Oscillator connection Oscillator connection +3.3V P85/NMI _NMI Not used (Fixed to H) P84/INT2 CEC_IN E ↓ &L CEC-D signal input pin(SII9185) DVP-602CI...
Page 27
CVBSRL Not used (Fixed to L) P.SAVE COMPONENT1or2 : H,Ohter : L(mute) P17/INT5 Not used (Fixed to L) P16/INT4 COMPSIGDET L:No signal、H:Signal P15/INT3 VSIGDET L:No signal、H:Signal P14/D12 SSIGDET L:No signal、H:Signal P13/D11 SUBnCE FPGA rewrite control(MAIN FPGA&GUI FPGA combined use) DVP-602CI...
Page 28
= Becomes High impedance mode at reset STBY : State of port when STANDBY mode. “O/L” = Output port and “L” “I” = Input port Stop : State of port when Stop mode. “O/L” = Output port and “L” “I” = Input port DVP-602CI...
Page 29
HIN202EIBNZ-T (FRONT : IC406) 0.1 F +5V TO 10V 0.1 F VOLTAGE INVERTER +10V TO -10V 0.1 F VOLTAGE INVERTER 0.1 F 400k 400k NJM2561M-TE1 (FRONT : IC404) DVP-602CI...
Indicates number of zeros after effective number. 2-digit effective number. Units: pF. 220pF (0 or 1) Indicates number of zeros after effective number. 2-digit effective number. Units: pF. When the dielectric strength is indicated in AC, "AC" is included after the dieelectric strength value. DVP-602CI...
EXPLODED VIEWS WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. z印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。 101 107 107 101 DVP-602CI...
DSP_SUB CPU UNIT CONNECT UNIT OPT UNIT FRONT UNIT CPU_SUPPLY UNIT FLD UNIT STANDBY LED UNIT TACT UNIT FILTER UNIT 00D1443036106 FRONT PANEL 00D1310169038 DENON BADGE 00D1431313103 WINDOW 00D1462523205 INNER PANEL 00D1431255009 LENS (POWER) 00D1131992109 P.KNOB ASSY(SUB) PWB BRACKET 00D1040334007 FOOT...
INST.MANUAL(E3) for E3,E2 00D5114751004 INST.MANUAL(E2) for E2 S.S.LIST(EX) WARRANTY (HOME) for E3 BATTERY(R03X2) 00D3991128001 RC-1093 00D2062219002 AC CORD SET (E3) for E3 00D2062215006 AC CORD-E1/10A/INLET for E2 POLY COVER CONT.CARD(L)SUB ASSY BAR CODE LABEL ASSY MAC ADDRESS SUB ASSY DVP-602CI...
(1) ALL RESISTANCE VALUES IN OHM(Ω/ohm). k=1,000 OHM(kΩ/kohm), M=1,000,000 OHM(MΩ/Mohm) (2) ALL CAPACITANCE VALUES IN MICRO FARAD(µF). p=MICRO-MICRO FARAD(pF) (3) EACH VOLTAGE AND CURRENT ARE MEASURED AT NO SIGNAL INPUT CONDITION. (4) CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE. DVP-602CI...
Page 65
HMDI/TMDS SIGNAL LINE SCHEMATIC DIAGRAMS (3/25) 1U-3833 DIGITAL VIDEO UNIT (1/12) HDMI IN SECTION(1/3) DVP-602CI...
Page 66
SCHEMATIC DIAGRAMS (4/25) 1U-3833 DIGITAL VIDEO UNIT (2/12) HDMI IN SECTION(2/3) DVP-602CI...
Page 67
HMDI/TMDS SIGNAL LINE Digital Audio SIGNAL LINE Digital Video SIGNAL LINE SCHEMATIC DIAGRAMS (5/25) 1U-3833 DIGITAL VIDEO UNIT (3/12) HDMI IN SECTION(3/3) DVP-602CI...
Page 68
Digital Video SIGNAL LINE SCHEMATIC DIAGRAMS (6/25) 1U-3833 DIGITAL VIDEO UNIT (4/12) V. CONVERT SECTION DVP-602CI...
Page 69
Digital Audio SIGNAL LINE Digital Video SIGNAL LINE SCHEMATIC DIAGRAMS (7/25) 1U-3833 DIGITAL VIDEO UNIT (5/12) HDMI TX PLD SECTION DVP-602CI...
Page 70
HMDI/TMDS SIGNAL LINE Digital Audio SIGNAL LINE Digital Video SIGNAL LINE SCHEMATIC DIAGRAMS (8/25) 1U-3833 DIGITAL VIDEO UNIT (6/12) HDMI OUT-1 SECTION DVP-602CI...
Page 71
SCHEMATIC DIAGRAMS (9/25) 1U-3833 DIGITAL VIDEO UNIT (7/12) HDMI OUT-2 SECTION DVP-602CI...
SCHEMATIC DIAGRAMS (10/25) 1U-3833 DIGITAL VIDEO UNIT (8/12) Video SIGNAL LINE ZONE1 V.CONVERT SECTION S-Video-Y SIGNAL LINE Compunet-Y SIGNAL LINE Digital Video SIGNAL LINE DVP-602CI...
Page 73
SCHEMATIC DIAGRAMS (11/25) 1U-3833 DIGITAL VIDEO UNIT (9/12) ZONE2 V. CONVERT SECTION DVP-602CI...
Page 74
Digital Audio SIGNAL LINE SCHEMATIC DIAGRAMS (12/25) Digital Audio SIGNAL LINE 1U-3833 DIGITAL VIDEO UNIT (10/12) Video SIGNAL LINE D.VIDEO CONNECT SECTION S-Video-Y SIGNAL LINE Compunet-Y SIGNAL LINE DVP-602CI...
Page 75
Digital Video SIGNAL LINE SCHEMATIC DIAGRAMS (13/25) 1U-3833 DIGITAL VIDEO UNIT (11/12) DVP-602CI...
Page 76
SCHEMATIC DIAGRAMS (14/25) 1U-3833 DIGITAL VIDEO UNIT (12/12) DDR/FLASH ROM SECTION DVP-602CI...
Page 77
Digital Audio SIGNAL LINE Digital Audio SIGNAL LINE SCHEMATIC DIAGRAMS (15/25) 1U-3881 DSP SCPU UNIT (1/6) 1U-3881-1 DSP SUB CPU UNIT (1/5) CONNECT SECTION DVP-602CI...
Page 78
SCHEMATIC DIAGRAMS (16/25) 1U-3881 DSP SCPU UNIT (2/6) 1U-3881-1 DSP SUB CPU UNIT (2/5) SCPU SECTION DVP-602CI...
Page 79
Digital Audio SIGNAL LINE Opt. Audio SIGNAL LINE SCHEMATIC DIAGRAMS (17/25) 1U-3881 DSP SCPU UNIT (3/6) 1U-3881-1 DSP SUB CPU UNIT (3/5) PLD SECTION 1U-3881-3 OPT-UNIT DVP-602CI...
Page 80
SCHEMATIC DIAGRAMS (18/25) 1U-3881 DSP SCPU UNIT (4/6) 1U-3881-1 DSP SUB CPU UNIT (4/5) DSP1 SECTION DVP-602CI...
Page 81
SCHEMATIC DIAGRAMS (19/25) 1U-3881 DSP SCPU UNIT (5/6) 1U-3881-1 DSP SUB CPU UNIT (5/5) DSP2 SECTION DVP-602CI...
Page 82
SCHEMATIC DIAGRAMS (20/25) Digital Audio SIGNAL LINE Video SIGNAL LINE 1U-3881 DSP SCPU UNIT (6/6) 1U-3881-2 CONNECT UNIT Digital Audio SIGNAL LINE S-Video-Y SIGNAL LINE Compunet-Y SIGNAL LINE DVP-602CI...
Page 83
Video SIGNAL LINE S-Video-Y SIGNAL LINE Compunet SIGNAL LINE SCHEMATIC DIAGRAMS (21/25) 1U-3882 FRONT UNIT (1/5) 1U-3882-1 CPU/SUPPLY UNIT (1/4) CONNECT SECTION DVP-602CI...
Page 84
SCHEMATIC DIAGRAMS (22/25) 1U-3882 FRONT UNIT (2/5) 1U-3882-1 CPU SUPPLY UNIT (2/4) SUPPLY SECTION 1U-3882-1 REG/PRIMARY UNIT 1U-3882-5 DIODE UNIT 1U-3882-6 REG UNIT 1U-3882-7 TR-1 UNIT 1U-3882-8 TR-2 UNIT 1U-3882-9 FILTER UNIT DVP-602CI...
Page 85
Video SIGNAL LINE S-Video-Y SIGNAL LINE Compunet SIGNAL LINE SCHEMATIC DIAGRAMS (23/25) 1U-3882 FRONT UNIT (3/5) 1U-3882-1 CPU/SUPPLY UNIT (3/4) V.IN/232C SECTION DVP-602CI...
Page 86
SCHEMATIC DIAGRAMS (24/25) 1U-3882 FRONT UNIT (4/5) 1U-3882-1 CPU/SUPPLY UNIT (4/4) CPU SECTION DVP-602CI...
Page 87
SCHEMATIC DIAGRAMS (25/25) 1U-3882 FRONT UNIT (5/5) 1U-3882-2 FLD UNIT 1U-3882-3 STANDBY LED UNIT 1U-3882-4 TACT UNIT DVP-602CI...