Warning - Chad Valley 792/0987 Assembly & User Instructions

Warning

Important –Please read these instructions fully before assembly or use.
WARNING
Observing the following statements and warnings reduces
the likelihood of serious injury.
● Warning! DO NOT allow use by children under the age of
36 months as small part(s) and long cord(s) may be
choking and entanglement stangulation hazards.
● This unit is designed to be used by up to 5 children
between the age of 3 to 8, with a maximum weight of
45kg per seat. Combined weight not exceed of 180kg.
● Provide on-site adult supervision for children of all ages
at all times.
● It is recommended that the playground equipment be
located on level ground and anchored. Be certain that all
anchoring devices (including concrete) are placed below
the level of the playing surface and covered with
protective soft material to prevent tripping.
● Teach children to sit in the centre of the swing play items,
with their full weight in the centre of the seats. DO NOT
allow children to lean to the side when on play items or to
collide with other playmates. DO NOT allow children to
stand on the swing seat.
● Dress children appropriately while on and around this
equipment. DO NOT allow children to wear ponchos,
scarves, jewelry,loose shoes, jackets or clothing with
loose strings and/or clothing that might be potentially
hazardous whilst using this equipment.
● DO NOT let children use this equipment in any manner
other than intended.
● Anchor all play equipment. DO NOT install over concrete,
asphalt, gravel or any other hard surface which may
cause injury should a fall occur. Swing set shall be
placed over protective soft material such as sand bed,
soft woodbark, grass lawn. The depth of sand and soft
woodbark shall be a minimum of 183cm. The anchor
shall be placed level with or under the ground in order to
reduce tipping hazards.
● DO NOT let children use this equipment until it has been
properly assembled and anchored. Place equipment on
level ground not less than 2M from any structures or
obstacles such as fences, overhanging branches, laundry
or electrical lines, garages, sheds or houses.
● Instruct children not to swing empty play items. They may
strike other children, or the play equipment may come
back and strike you.
● Instruct children not to walk closely in front of, behind or in
between moving play equipment. Instruct children to keep a
safe distance away to avoid being struck by the items in use.
● Instruct children not to twist chains or ropes, or loop them
over the support bar. This adds stress, reduces strength
and may result in failure and cause injury.
● Instruct children not to get off play equipment whilst in
motion. DO NOT allow children to jump from moving play
equipment.
2
● DO NOT allow children to climb or play on the equipment
whilst wet (slips or falls may occur).
● DO NOT allow children to climb on or swing from
structural members (eg legs or top bar and chin bars).
These are structural components ONLY and NOT play
features.
● DO NOT allow children to swing play equipment more
than 60 degrees.
● After completion of assembly, ensure all the nuts and
bolts are tightened and in the correct position.
● Not suitable for hiring or commercial use.
● Never use the equipment in any manner other than
intended.
● Please retain these instructions for future reference.
● Warning! only for dometic use.
Maintenance Instructions
● Check all nuts and bolts twice monthly during the
season and tighten as required. We recommend you
check the swing beam and hardware every two weeks.
It is particularly important that this procedure be
followed at the beginning of each season.
● Oil all metallic moving parts monthly during the usage
period.
● Check all nuts and bolts twice monthly during the
season to be certain they are in place. Replace when
necessary. It is especially important to do this at the
beginning of each new season.
● Check swing seats, ropes, cables and chains monthly
during usage season for evidence of deterioration.
Replacement should be made of any swing seat that
has developed cracks in the plastic seat or has
exposed metal in the edges of the swing seat. If there
are already exposed metal inserts on the edge of the
seat, immediately remove the seats and chains to
prevent serious injury. Ropes, cables and chains
should be removed and replaced if excessive wear is
found. Contact OUR SERVICE CENTER for
replacement parts.
● Maintaining the Play set on a level location is very
important. As your children play, your Play set will
slowly dig its way into soil, and it is very important that
is settled evenly. Make sure the play set is level and
true once each year or at the beginning of each play
season.
● Toys shall be accompanied by maintenance
instructions drawing attention to the need of carrying
out checks and maintenance of the main parts at
regular intervals , if these checks are not carried out
the toy could overturn and otherwise become a hazard.
Whenever practical, the instructions shall also be
affixed to the toy.