2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. ST AN Y/ ON ∗ : See page 27. /C LO D/ US M EN M EN DV-610AV-S...
• Soldering time: Within 3 seconds • Soldering combination: Sn-3.0Ag-0.5Cu • When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to prevent the Flux smoke from it. Short circuit using a soldering iron. Pick Up PCB Fig. 1 DV-610AV-S...
• Place the unit on a workstation equipped to protect against static electricity, such as conductive mat. • Soldering iron with ground wire or ceramic type is used. • A worker needs to use a ground conductive wrist strap for body. DV-610AV-S...
•DRM (Digital Rights Management) compatible: No (DRM- protected audio files will not play in this player •File extensions: .mp3, .wma, .m4a (these must be used for the Super VCD player to recognize MP3, WMA and MPEG-4 AAC files–do not use for other file types) DV-610AV-S...
Page 10
Discs recorded in packet write mode (UDF format) are not order. compatible with this player. Check the DVD-R/-RW or CD-R/-RW software disc boxes for additional compatibility information. • DivX, DivX Ultra Certified, and associated logos are trademarks of DivX, Inc. and are used under license. DV-610AV-S...
Press to pause playback. Press again to restart. Press to stop the disc (you can resume play- back by pressing (play)). Skips to the start of the current track, title or chapter, then to previous tracks/titles/chapters. Skips to the next track, title or chapter. DV-610AV-S...
Page 12
Press to display information about the disc ENTER menus. Press to select an option or playing. execute a command. 24 ZOOM HOME MENU Press to change the zoom level. Display/exit the on-screen display. Use for reverse slow motion playback, frame reverse and reverse scanning. DV-610AV-S...
• Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Position to be cleaned Position to be cleaned Cleaning tools Cleaning tools Cleaning tools Remark Remark Remark Pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 DV-610AV-S...
Lubricants and Glues No. Lubricants and Glues No. Lubricants and Glues No. Remark Remark Remark Daifree GEM1036 (ZLX-ME413A) Refer to "9.3 DVD MECHA SECTION" Grease GYA1001 (ZLB-PN397B) Refer to "9.3 DVD MECHA SECTION" Grease GEM1018 Refer to "9.3 DVD MECHA SECTION" DV-610AV-S...
CP604 POWER POWER CAUTION ATTENTION :SINCE THESE PARTS MARKED BY :LES PIECES REPAREES PAR UN CRITICAL FOR SAFETY,USE ONES DANGEREUSES AN POINT DE VUE SEC DESCRIBED IN PARTS LIST ONLY. N'UTILISER QUE CELLS DECRITES DANS LA NOMENCLATURE DES PIECES DV-610AV-S...
Page 17
REPAREES PAR UN ETANT NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER SES AN POINT DE VUE SECURITE OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DURING PLAYBACK. QUE CELLS DECRITES MENCLATURE DES PIECES. DV-610AV-S...
Is the voltage at Check P.CON 6V line of pin 8 and 19 of IC2301 POWER BLOCK. about DC 6 V ? Check CD2302 Is the lose connection connection to DECK. at CD2302 to DECK ? Change DVD LOADER. DV-610AV-S...
Page 22
NO PLAYBACK PICTURE OF AV JACK Is there Check IC4002 and a signal at pin 187 of peripheral circuit. IC4002 ? Y es Is there Check J7302 and peripheral video signal at pin 33 circuit. of IC7301 ? Change IC7301. DV-610AV-S...
Page 23
AUDIO signal at pins 7 and 8 circuit. of IC8003 ? Is there waveform at Is there voltage at Check AT+5V pins 1,2 and 3 of pin 6 of IC8003 about 5 V ? IC8003 ? Change IC4002. Change IC 8003 DV-610AV-S...
Page 24
Is there voltage at pin Check P.CON +D5V line. 2 of OS8101 about 5 V? REFER TO "NO DIGITAL Is the waveform at pin 1 of OS8101 about 2.5 V ? AUDIO ON PLAYBACK OF COXIAL JACK" Change OS8101. DV-610AV-S...
Page 25
Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be (DVD MT PCB Assy : IC4002) generated, because the DVD processing is performed by a single chip. 64M SDRAM No power. (DVD MT PCB Assy : IC4005) Block noise is generated during playback. DV-610AV-S...
• After going into service mode, if you play back the disc, "DISC-NON" is displayed. • The video signal and the audio signal are outputted during the servicemode. • The SKIP key and the SCAN key are effective during the service mode. SERVICE MODE: OFF POWER GGF1381 Service mode remote control unit DV-610AV-S...
LD ON DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650n). : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780n). DV-610AV-S...
NTSC system : [NTSC] PAL system : [PAL] Automatic setting : [AUTO] Scart terminal output [SK − ∗ ∗] (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] S-VIDEO : [01] DV-610AV-S...
Region confirmation mode (ESC + A.MON [Service mode remote control unit] + "1"-"8" [Service mode remote control unit] keys) After you press the A.MON key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. DV-610AV-S...
-2 : NG 7.0e -4 : NG 3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors) Note: ∗ Error of AV1 is not supported in this player. Indication plan contents Character in bold : Item name : Information display DV-610AV-S...
Remove the Power PCB in the direction of arrow. Remove the 5 screws (1). Remove the 4 screws (2). Remove the DVD MT PCB in the direction of arrow. Power PCB DVD MT PCB (1) (1) Fig. 1-2 Fig. 1-4 DV-610AV-S...
Page 34
3 supports between A and B. Fig. 2-3-D 2. Remove the Plate Clamper, Magnet Clamper and Clamper. Check Hook Check Hook Plate Clamper Magnet Clamper Main Frame Loading Motor PCB Ass’y Check Hook Clamper Fig. 2-3-E Fig. 2-5-A DV-610AV-S...
Page 35
6. Remove the Switch PCB Ass'y. 7. Remove the screw Feed Motor 8. Remove the Gear Feed. 9. Remove the 2 screws 10. Remove the Feed Motor. Safety surface for pressing 11. Remove the Gear Motor. of the insert. Fig. 2-7-C DV-610AV-S...
Page 36
Fig. 2-8. NOTE 1. Do not make the folding lines except the specified positions for the FFC. [ 24 pin FFC ] Fold Printing Surface 79 ± 1 mm Reinforcement Plate To Pick Up PCB Fig. 2-8 DV-610AV-S...
While the screen shown at left is being displayed, updating is in progress. DO NOT TURN OFF THE POWER DURING UPDATING. 4 Updating of the firmware is completed. When the screen with the Pioneer logo is displayed, updating is completed. The time required for updating is about 2 minutes. DV-610AV-S...
Page 38
If updating of the firmware using the disc for updating failed • Was the disc for updating recognized properly? Check if the volume label of the disc is PIONEER. • Is playback of a disc other than the disc for updating possible? If playback of a test CD is also impossible, a reading section, such as PU, may be defective.
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING WVXZT5 Only WSXZT5 Only Except WVXZT5 WVXZT5 Only DV-610AV-S...
Page 41
See Contrast table (2) Operating Instructions (E/I) See Contrast table (2) Operating Instructions (G/F) See Contrast table (2) (2) CONTRAST TABLE DV-610AV-S/WYXZT5, /WVXZT5, /WSXZT5, DV-610AV-K/WYXZT5 and WSXZT5 types are constructed the same except for the following: DV-610AV-S/ DV-610AV-S/ DV-610AV-S/ DV-610AV-K/ DV-610AV-K/ Mark No.
Page 43
8965TS0610 ..Spring Earth 753WUAA013 Screw,Tap Tite(B)-R (3x5.5) 815223055U (2) CONTRAST TABLE DV-610AV-S/WYXZT5, /WVXZT5, /WSXZT5, DV-610AV-K/WYXZT5 and WSXZT5 types are constructed the same except for the following: DV-610AV-S/ DV-610AV-S/ DV-610AV-S/ DV-610AV-K/ DV-610AV-K/ Mark No.
Note : (SW PCB ASS'Y) CD2301 NOTE: Applying positions AA, AB and AC for the CLASS PART NO. MARK grease are displayed for this section. GREASE GEM1018 Check if the correct grease is applied for each GYA1001 position. GEM1036 DV-610AV-S...
Page 47
PCB130 DMG100 R4084 C4091 4.7K W846 R4051 RESET TP4110 NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DURING PLAYBACK. DV-610AV-S...
FROM/TO POWER PORT SH4001 FLDC- YQ-12 -28V FLDC+ V+3E D_GND V+5V_USB NOTE:THE DC VOLTAGE EACH P NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE D OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DURING PLAYBACK. DV-610AV-S...
Page 49
0.1 B GND(USB) D4003 L4001 DLP11SN201HL2L AVRL161A1R1NT USBN W805 USBP W806 D4002 TP4050 W810 (SCHOTTKY 3.0A) AVRL161A1R1NT D4005 W844 USB+5V EC31QS04 PCB130 DMG100 CAUTION: DIGITAL TRANSISTOR :THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-610AV-S...
:SINCE THESE PARTS MARKED BY ATTENTION :LES PIECES REPAREES PAR UN ETANT NOTE:THE DC CRITICAL FOR SAFETY,USE ONES DANGEREUSES AN POINT DE VUE SECURITE MEASU DESCRIBED IN PARTS LIST ONLY. N'UTILISER QUE CELLS DECRITES DURIN DANS LA NOMENCLATURE DES PIECES. DV-610AV-S...
Page 51
2.91 VOTK- VOFC- 2.82 2.77 VOTK+ VOFC+ PCB130 DMG100 NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE EACH PART WAS OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-610AV-S...
KTC3875S_Y_RTK VREF_F ABCK0 C8040 ASDAT0 YK_P ALRCK V+5A V+3A1 C8025 330P CH NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST A MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WIT DURING PLAYBACK. DV-610AV-S...
Page 53
10K +-1% 10K +-1% YK_P LS/RS/C/LFE R8091 MUTE SW J8002 Q8024 RCA-405A(CUSN)-06 J8001 2SD1306NE -0.7 RCA-207B(CUSN)-02 R8080 R8064 220 +-1% 18K +-1% PCB130 DMG100 CAUTION: DIGITAL TRANSISTOR DIAGRAM IS THE LATEST AT THE TIME D SUBJECT TO CHANGE WITHOUT NOTICE. DV-610AV-S...
C7312 P-H/I-L YK_P Q7302 DRIVE2 I/XP KRC103SRTK (1D=H,2D=L) C7313 0.1 B P-H/I-L TP7302 FROM POWER PORT W889 TP7303 D_GND V+6A NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC D MEASURED WITH THE DIGITAL TESTER OF PRINTING AND DURING PLAYBACK. DV-610AV-S...
Page 55
TP7301 CVBS 4CH BUS SW IC IC7302 SN74CBT3257PWR S-VIDEO OUT for HE CVBS/Y/U/V J7304 J7302 DIN-409A RCA-405A(CUSN)-08 PCB130 DMG100 CAUTION: DIGITAL TRANSISTOR NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-610AV-S...
FROM/TO MPEG/MICON/DSP V+3D V+5H TX2+ TX2- TX1+ TX1- TX0+ TX0- TXC+ TXC- HDMI_SCL HDMI_SDA D_GND W855 A_GND W856 W861 W863 W865 A_GND NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-610AV-S...
Page 57
5.06 4.89 4.82 C5907 10P CH HDMI_SCL HDMI_SDA C5901 POWER 0.01 B W840 4.82 4.89 5.07 HOTPLUG W853 Q5902 2SK3019_TL B5901 V+3D EBMS160808A102_RDC45 W864 NOTE:THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER PCB130 DURING PLAYBACK. DMG100 DV-610AV-S...
USB+5V CAUTION NOTE:THE :SINCE THESE PARTS MARKED BY ATTENTION :LES PIECES REPAREES PAR UN ETANT CRITICAL FOR SAFETY,USE ONES DANGEREUSES AN POINT DE VUE SECURITE DESCRIBED IN PARTS LIST ONLY. N'UTILISER QUE CELLS DECRITES DANS LA NOMENCLATURE DES PIECES. DV-610AV-S...
Page 59
V_ADJ TP4038 R4063 R4072 R4073 W849 +-1% PCB130 DMG100 NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DURING PLAYBACK. DV-610AV-S...
SW662 SW663 -18.0 -18.0 -18.0 -16.0 -16.0 -16.0 -16.0 -16.0 -16.0 EVQ11L05R EVQ11L05R -SKIP PAUSE SW664 SW665 EVQ11L05R EVQ11L05R NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC DIA OF PRINTING AND SU MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-610AV-S...
Page 61
.0 -16.0 -16.0 FFC(1.0mm pitch) V+3E V+3E C604 DGND CD601 C605 33P CH 2H0B1003 DGND FLDC+ FLDC+ -28V -28V FLDC- FLDC- V+3E PCB270 DEG149 OTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-610AV-S...
:SINCE THESE PARTS MARKED BY DANGEREUSES AN POINT DE VUE SECURITE NOTE:THE DC VOLTAGE EACH PART WAS CRITICAL FOR SAFETY,USE ONES N'UTILISER QUE CELLS DECRITES MEASURED WITH THE DIGITAL TES DESCRIBED IN PARTS LIST ONLY DANS LA NOMENCLATURE DES PIECES. DURING PLAYBACK. DV-610AV-S...
Page 63
EMATIC DIAGRAM IS THE LATEST AT THE TIME ING AND SUBJECT TO CHANGE WITHOUT NOTICE. NOTE: THE RESISTOR MARKED F IS FUSE RESISTOR. OLTAGE EACH PART WAS THE ALUMI ELECTROLYTIC CAPACITOR MARKED NP ED WITH THE DIGITAL TESTER IS NON POLAR ONE. PLAYBACK. DV-610AV-S...
Q8104 KTC3875S_Y_RTK 390 1/4W KRC104SRTK 12.1 11.4 R8101 4.7K NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE EACH PART WAS OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-610AV-S...
Page 65
YK_P +-1% 1/10W DVD_RGB_H_OUT Q8105 KRA102SRTK B_H_OUT 04SRTK R8109 +-1% 1/10W * The parts except mark cannot be changed. On that occasion, replace whole Assy. CH PART WAS HE DIGITAL TESTER CAUTION: DIGITAL TRANSISTOR CAUTION: DIGITAL TRANSISTOR PCB240 DPG017 DV-610AV-S...
Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator 11.1 LOADING MOTOR and SW SIDE A SIDE A LOADING MOTOR (INSERTED PARTS) DED020A M2602 M2601 SIDE B SIDE B LOADING MOTOR (CHIP MOUNTED PARTS) M2603 CD2302 DV-610AV-S...
IC 8001 IC TC7SHU04FU I55F004FU0 IC 8003-8005 PCM1742KE/2K I17F042KE0 IC 8008 IC RC4580IDR I04J045800 OTHERS 7302 RCA JACK 060R451013 7304 JACK 063R700013 8001 RCA JACK 060R451012 8002 RCA JACK 060R451014 CP 5901 CONNECTOR PCB SIDE 06GEYJ3048 X 4001 CRYSTAL (27 MHz) 100GT02720 DV-610AV-S...