Summary of Contents for DeRoyal Aqua-Box 1200-00
- Page 1 F l u i d W a s t e E v a c u a t i o n & D i s p o s a l Aqua-Box Owner’s Manual ® Models: 1200-00, 1300-00, 1500-00 & 1300-R...
-
Page 2: Table Of Contents
A q u a - B o x O w n e r ’ s M a n u a l TABLE OF CONTENTS GENERAL INFORMATION ............3-6 About this Manual ......................3 Introduction ........................3 OSHA & EPA Considerations ..................... 4 Sales &... -
Page 3: General Information
And because the Aqua-Box offers a safer alternative for handling the potentially Administration’s efforts to enforce Title 29, Part 1910.1030, concerning healthcare personnel safety, DeRoyal realizes infectious fluids, hospitals and surgery centers can expect fewer... -
Page 4: Osha & Epa Considerations
If there is a unit failure maintenance requirements and potential cost savings, the that cannot be resolved by phone, by a visit by a DeRoyal Aqua-Box is becoming the standard for waste fluid disposal. representative, or by a sub-contracted plumber during the warranty period, DeRoyal will ship a replacement unit. - Page 5 Suction Hose Adapters o Reduced Pressure Zone (RPZ) valve • This warranty does not apply outside the USA. Extended Warranty A three-year extension for all Aqua-Box models is available for an additional charge. Contact your DeRoyal Sales Representative for additional information.
-
Page 6: Model Comparison
A q u a - B o x O w n e r ’ s M a n u a l DEROYAL AQUA-BOX MODEL COMPARISON Automatic with Large Small Small Small Feature Canister Rinsing Automatic Automatic Manual Manual Model #... -
Page 7: Technical Information
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l TECHNICAL INFORMATION DIMENSIONS Controller Box 1300-R 1500-00 1300-00 1200-00 1100-00 (all models) 18 in. -
Page 8: Installation Requirements
A q u a - B o x O w n e r ’ s M a n u a l INSTALLATION REQUIREMENTS 1100 does not have a disinfectant solution inlet. POWER SWITCH/TIMER A standard 110/120 AC Volt, 15/60-Hertz cycle, 3 Amp Models 1500-00 &... -
Page 9: Installation
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l INSTALLATION The following procedures are important for correct mounting, steel screws and matching anchors provided. The electrical plumbing and electrical installation of the Aqua-Box. -
Page 10: Plumbing Connections
A q u a - B o x O w n e r ’ s M a n u a l 6. For 1200 & 1100 Models: Connect the outlet of the RPZ valve to the inlet of the Aqua-Box. PLUMBING CONNECTIONS: ALL UNITS 1. -
Page 11: Installation Diagrams: Plumbing Connections
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l INSTALLATION DIAGRAM: PLUMBING CONNECTIONS Applies to 1500 & 1300 Models ™... -
Page 12: Installation Diagrams: Plumbing Connections
A q u a - B o x O w n e r ’ s M a n u a l INSTALLATION DIAGRAM: PLUMBING CONNECTIONS Applies to 1200 & 1100 Models ™ (1/2” for Model 1100) -
Page 13: Electrical Connections
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l ELECTRICAL CONNECTIONS: NON-RINSING UNITS For Models 1500-00 and 1300-00 only, the following steps provide the instructions for the electrical connections. 1. - Page 14 A q u a - B o x O w n e r ’ s M a n u a l ELECTRICAL CONNECTIONS: RINSING UNITS For Model 1300-R only, the following steps provide the instructions for the electrical connections. The 1300-R ships completely pre-wired.
-
Page 15: Adjusting The Automatic Timer Switch (Models 1500 & 1300)
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l ADJUSTING THE AUTOMATIC TIMER SWITCH (MODELS 1500-00 & 1300-00) For Models 1500 and 1300, the Aqua-Box power button is 1. -
Page 16: Instructions For Use
A q u a - B o x O w n e r ’ s M a n u a l INSTRUCTIONS FOR USE NON-RINSING UNITS A - “Start” Switch B - “Kill” Switch C - Suction Hose (Grey) D - Thumb Valve E - Treatment Solution Valve F - Treatment Solution Tube (Yellow) G - Suction Hose Hanger... -
Page 17: Liner Systems
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l 8. When canister is empty, leave thumb valve open for a NOTE: A liner adapter can only be used with flexible liners. -
Page 18: Rinsing Units
A q u a - B o x O w n e r ’ s M a n u a l RINSING UNITS A - “Start” Switch B - “Kill” Switch C - Suction Hose (Grey) D - Thumb Valve E - Treatment Solution Valve F - Treatment Solution Tube (Yellow) G - Suction Hose Hanger... -
Page 19: Liner Systems
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l 10. When the last canister has been evacuated, and with the 2. -
Page 20: Evacuation Tubes
A q u a - B o x O w n e r ’ s M a n u a l EVACUATION TUBES 4. Attach a NEW Evacuation Tube to the Aqua-Box hose. The Evacuation Tube is the disposable portion of the Aqua- Box’s suction line that enters the suction canister. -
Page 21: Troubleshooting
F l u i d W a s t e E v a c u a t i o n & D i s p o s a l TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION The electricity is not connected (models 1500 •... -
Page 22: Replacement Parts
A q u a - B o x O w n e r ’ s M a n u a l REPLACEMENT PARTS ™ ™ Diagram Location Part Description Reorder Number Thumb Control Valve (Aluminum) 1500-00-01 Suction Hose, ½” (Grey) 1500-00-02 Suction Hose Check Valve 1500-00-03... - Page 23 F l u i d W a s t e E v a c u a t i o n & D i s p o s a l Diagram Location Part Description Reorder Number Disinfectant Hose (Yellow) 1500-00-04 Disinfectant Ball Valve (PVC) 1500-00-05 Disinfectant Hose Fitting 1500-00-06...
- Page 24 A q u a - B o x O w n e r ’ s M a n u a l For additional information call RehabMart: 800.827.8283 Customer Care Center 1353 Athens Highway Elberton, GA 30635-4484 1-800-827-8283...
Need help?
Do you have a question about the Aqua-Box 1200-00 and is the answer not in the manual?
Questions and answers