The front panel is a secondary tool used to manipulate some of the STB functions. The number of front panel buttons is limited compared to the RCU, but the user should be able to operate most important STB functions via those buttons. 1.1. Front Panel Buttons for HSS-730/830 & UFD505/515 ž Standby On /Off Key ž...
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB Rear Panel The rear panel provides all the connectors required to place the STB into the home video systems. ※ Full option (HSS-730/830 & UFD505/515 Rear Panel) 2.1. Rear Panel Connectors...
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB Hardware This section describes the entire architecture and an individual module of the STB hardware. 3.1. System Block Diagram The hardware is modularly designed to support as many markets as possible while minimizing the burden on developing the derivative hardware.
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.3. Network Interface Module 3.3.1. NIM Module 3.3.1.1. Block Diagram The NIM module has digital tuner as depicted in the following figure. Digital Tuner Module Transport Satellite Stream QPSK RF In...
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.3.1.3. Electrical Specification of Digital Tuner 75 Ω Impedance Return Loss > 8dB Frequency Range 950 to 2150 MHz Signal Level -65 to -25 dBm AFC Range + - 3MHz Connector...
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.4. Software Download The resident software boots up the STB, downloads the entire new software as needed, and tests the hardware integrity of the STB. These software modules are stored in non-volatile memory so that these should not be erased during a power outrage or other catastrophic events.
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.4.3. Software Download with Serial Link Cable from other STB Procedure to download the software First, connect the serial link cable between the master STB and slave STB and make sure that the STB is in the standby or power off mode.
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.5. Output Interfaces 3.5.1. TV and VCR/AUX Scart Configuration The STB presents the audio and video data to the user in a variety of formats. The following figure describes the logical wiring of the STB outputs.
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.5.2. TV Scart Connector Pin Configuration PIN number Signal name Description AOUTR Audio right output to TV AINR Audio right input from TV AOUTL Audio left output to TV RTN5 Ground...
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.5.4. RCA Cinch Connector The MPEG stereo audio and CVBS video and digital audio(SPDIF) are available through four cinch connectors. Color Description Yellow Video (CVBS) White Audio left Audio right Black Digital Audio (SPDIF) 3.5.5.
Page 17
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 3.5.7. Front Panel Connector Configuration PIN number Signal Description Digit1 FND digit1 select Digit2 FND digit2 select Digit3 FND digit3 select Digit4 FND digit4 select Standby5V Power 5V Digit_data1 FND digit data1...
Page 18
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB Electrical Specifications 4.1 Power Supply Type Switching mode power supply AC Line Voltage 88 to 264 V AC Line Frequency 47 to 63 Hz Power Consumption 30W max for operational, 5 W max for standby...
Page 19
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.3. Key in front panel doesn’t operate Check that Cable is connected between front and main board. CPU boots up correctly. Ch1 LOW0 (STi5518 pin42) Ch2 COL0 (STi5518 pin39) 5.4. RF-Modulator doesn’t operate (Option) Check that The type of RF Module is correct in menu.
Page 20
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.5. RCA Video doesn’t output Check that A/V mode sets to CVBS in menu. Video signal outputs from STi5518 pin Video signal inputs to Scart controller (STV6412) pin 4. Video signal outputs from Scart controller (STV6412) pin 36.
Page 21
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB Scart controller (STV6412) signal are input to Scart controller (STV6412 pin 55, pin 56). Video signal(Y) outputs to Scart controller (STV6412) pin 44 for TV Scart. Video signal(C) outputs to Scart controller (STV6412) pin 42 for TV Scart.
Page 22
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.8. Audio doesn’t output. Check that Audio PCM LR clock, PCM data, PCM clock, master clock input to AUDIO DAC(WM8725ED) pin 1, 2, 3, 14. Audio signal outputs from AUDIO DAC (at pin 6, 9 of WM8725ED).
Page 23
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.9. A digit in FND doesn’t display Check that Pulse signals which control 4 digit output from transistor. Digit data from in GPIO buffer (74HCT374) output corrected. Ch1 DIGIT1 Ch2 DIGIT2...
Page 24
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.11. Can’t download software via RS-232C Port Check that Power is provided to RS-232C Driver. U3 is in good condition (pin 7 of RS-232C Driver showes –10V with main power on. If the measurement is 0V the device is in fail).
Page 25
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.14. 22kHz doesn’t output.(view circuit diagram) Check that LNB_ENT at pin 193 STi5518 is good operation. HIGH -> 22kHz On, LOW -> 22kHz Off. At Pin 14 of Digital tuner module, 22kHz signal generate good.
Page 26
HSS-730/830 & UFD505/515 SERVICE MANUAL HDT DVB SATELLITE STB 5.16. Tuner signal Lock, But A/V not display to TV (view circuit diagram) Check that I2C bus operate good. Digital tuner module outputs serial transport stream correctly for FTA model. Digital tuner module outputs parallel transport stream correctly for FTA model.
Page 27
ž Ref to appendix B 6.3. SMPS circuit diagram ž Ref to appendix C PCB Pattern 7.1. HSS-730/830 & UFD505/515 Silk & PCB pattern ž Ref to appendix D 7.2. HSS-730/830 Front Silk & pattern ž Ref to appendix E 7.3.
Page 37
* These parts may not be used in some derivative models. HDT LAB. 1 Title FRONT BOARD Size Document Number D.G. HAN D.G. HAN J.S. LEE K.J. LEE HSS-730/830 & UFD505/515 Front DRAW BY DESIGN BY CHECK BY APPROVE BY Date: Tuesday, January 29, 2002 Sheet...
Page 49
Appendix J Part list for HSS-730/830 & UFD505/515 수량 단위 PART NO. DESCRIPTION LOCATION B104200200A H-SINK,27*27*5,ZIVA3 EA B109100601A SCREW,PCMCIA,2*16(H4) EA E104300150A CON,PCMCIA,DIP,P1T2B1392 EA H-SINK VCD 공용 B104200003A EAREG2 E104100011A JACK RS-232C 9P EACON1 E104100015A RCA,2*2,JE040060PN EACON5 E104100016B SCART,1*2,SHIELD EACON2 E104300111A...
Page 53
Appendix K Part list for HSS-730/830 Front PART NO. DESCRIPTION 수 량 단 위 LOCATION E104600188A CBL-FFC,1000IR,26P,300mm 1 EA B106802000A FND,SPACER,GRUNDIG 2 EA B106803000A RUBBER,SPACER,SENSOR,10*14*8T 1 EA E104300113A CON,FFC,26P,LS 1 EA CON1 E106400008A LED,7SEG,88:88 1 EA E106800007A SENS,TSOP1838SB1 1 EA...
Page 54
Appendix L Part list for UFD505/515 Front PART NO. DESCRIPTION 수 량 단 위 LOCATION E104600079B CBL-FFC,26P,110mm(6) 1 EA P-5150-FM0A 515,FRT,M/I 1 ST B106800900A RUBBER,FND,BDT 1 EA B106802100A R/SENSOR,SPACER,GRUNDIG 1 EA E104300113A CON,FFC,26P,LS 1 EA CON1 E106400014B FND,7SEG,88:88,SOCKET,8.9mm 1 EA E106800011A REMOTE,SEN,ORC-354HF 1 EA...
Page 55
Appendix M Part list for SMPS 수 량 PART NO. DESCRIPTION LOCATION YRE16010 1/8W 470 ohm J YRE15210 1/8W 4.7K ohm J R19,23 1/8W 1.0K ohm -(F) YRE63410 YRE6B910 1/8W 1.06K ohm -(F) YRE10320 1/4W 10 ohm J YRE18920 1/4W 20 ohm J YRE15520 1/4W 68K ohm J YRE13830...
Page 56
수 량 PART NO. DESCRIPTION LOCATION YID05002 BAR 5x20(7.0uH) YID07000 LTV817B,C/TCET1105T YIC10006 1N5822L SB360L YDI40206 YDI40M06 UF5404L YDI36306 KA7812/KA78M12 YIC10014 3941P03VP01 YCN00850 SVC471D-10A/INR10D471 AC 250V 50CT2A YVA32110 YFU12102 STR-G6153T YIC10018 KA278R33 YIC10017 23x17x19(HOLE)x35(H) YHS00015 15x5x22(HOLE)x26(H) FOR U1 YHS00013 M3 * 6 ASSEMBLY FOR U3 YBT03000 M3 * 8 ASSEMBLY...