Thank you for purchasing PEREKO boiler. This technical docu- A set of documents intended for the user contains manual for mentation applies to feeder boilers from the Q-PER series and the microprocessor temperature controller (regulator), feeder and contains all necessary information and recommendations for their fan, which should be read and understood.
Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
Takes fuel from the hopper and ensures automatic feeding of the ment intended for operation at elevated temperature. burner section, using a steel screw conveyor. Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
13. 1”return end 6. Ash drawer 14. Power strip 7. Charging hopper 15. Flue 8. Feeder unit with gearmotor Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
*maximum water temperature in the boiler – 95°C; **for rooms height 2.5 m and insulation with styrofoam 15 cm (q = 55 W/m2); ***PN-EN 12809, PN-EN 303-5:2002; Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
0.25 m. Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
Protection of open water heating installations – Specifi- cations/. The manufacturer reserves the right to introduce design modifications. Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Page 9
Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
4. Close boiler drain cock and disconnect flexible hose from the stances. Water hardness should not exceed 2-4 (mval/l). Too equipment when the system is filled. Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Page 11
(to avoid freezing and therefore damaging to the system) and refilling it with wa- ter when the frost is over. Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
2. Check the heating system: 5. Perform chimney draught measurement. • check tightness, inspect for any leakages from the boiler or the installation, Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Feeder standstill time [s] Fuel feeding time [s] 60 / 10 80 / 10 80 / 10 80 / 10 Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
After damping and cooling down of the fuel and causes excessive soot formation Cleaning hole of air chamber of the burner Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Fuel suspends in the container Too moist fuel Remove fuel from the container and dry it Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
ENVO sp. z o.o. It should not be copied and use by the other intended for removal of fault. Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Page 17
10. Corrosion of steel components resulting from maintaining too low temperature of water - below 57°C with simultane- ous use of incorrect, moist fuel. Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications. Page...
Page 18
SERVICE ASSISTANCE Date Comments Signature Page Operation and maintenance manual for the Q-PER series boilers with feeders. The producer reserves the right to introduce technical modifications.
Page 19
Guarantee for tightness of welding connections of water casing in the boiler is provided for 10 years, 60 months for tightness of the heat exchanger and 24 months for the other components. The beginning of the warranty period for the PEREKO boiler is the date of purchase confirmed by a proof of purchase.