Table Of Contents - Bard P1060A1 Installation Instructions Manual

Contents
Getting Other Informations and Publications ........ 1
General Instructions
Important ................................................................ 4
Shipping Damage .................................................... 4
General ................................................................ 4
Field-Installed Heater Packages (Optional) ............. 4
Installation
Location ................................................................ 6
Typical Installations .................................................. 6
Condensate Drain Trap ............................................ 9
Air Filters ................................................................ 9
Wiring - Main Power .............................................. 10
Wiring - 24V Low Voltage Control Circuit .............. 10
Transformer Taps ................................................... 10
Thermostats ........................................................... 10
Start Up and Operation
Three Phase Scroll Compressor Start Up
Information .............................................................. 11
Sequence of Operation ........................................... 11
Start Up Notes ........................................................ 11
High Pressure Switch and Lockout Relay ............... 11
Service and Troubleshooting
Service Hints ......................................................... 12
Pressure Service Ports .......................................... 12
Refrigerant Charge ................................................ 12
Fan Blade Settings ................................................. 12
Suction and Discharge Tube Brazing ..................... 12
Pressure Table ....................................................... 13
Figures
Figure 1 Prefabricated Rood Curb
Specifications .......................................... 5
Figure 2 Field Fabricated Curbing ......................... 5
Figure3 Elevated Mounting Platforms .................. 7
Figure 4 Airflow and Service Access
Clearances .............................................. 7
Figure 5 Roof Top Application ............................... 8
Figure 6 Slab Mounting at Ground Level ............... 8
Figure 7 Condensate Drain Trap ........................... 9
Figure 8 Low Voltage Wiring ............................... 10
Figure 9 Fan Blade Setting Dimensions .............. 12
Figure 10 Brazing Diagram ................................... 13
Tables
Table 1 Electrical Data ......................................... 2
Table 2 Optional Field Installed Heater
Packages ................................................ 2
Table 3 Optional Field Installed Heater Table ....... 3
Table 4 Maximum ESP of Operation ................... 4
Table 5 Rated CFM and Rated ESP .................... 6
Table 5A ESP in Inches H
Table 6 Air Filter Area and Size ........................... 9
Table 7 Thermostat Wire Size ........................... 10
Table 8 Wall Thermostat and Subbase
Combinations ........................................ 10
Table 9 Refrigerant Charge ............................... 12
Table10 Pressure Table ...................................... 13
O .................................. 6
2